Documente Academic
Documente Profesional
Documente Cultură
1.3 Objectives
The objectives of this project and thesis are
i. To investigate ……
ii. To study …..
iii. To apply …..
iv. To design …
1.4 Scopes
1
Describe the scopes of your work here. There should be one line gap between two
sections, sub-sections or sub-sub-sections.
2
CHAPTER 2
LITERATURE REVIEWS
2.1 Introduction
Each chapter must present an introduction section and a summary section except
chapter one and the last chapter, i.e. conclusion chapter. In literature review section or
in any other section, citation must be given in square bracket. Reference orders must
be maintained.
2.2 Section
Each section must have text and/or figure or table.
2.3 Section
3
Page number must be at the bottom center of the page.
2.3.1 Sub-section
Writings must be justified.
Explain table close to the table presented. Table must be within the page margin.
2.4 Summary
Final summary of this chapter goes here.
4
CHAPTER 3
ANALYSIS AND SIMULATION
3.1 Introduction
Page margin must be 1.5 inch at left side and 1 inch in all other sides (top, bottom and
right sides) of the page.
3.2 Section
Page should be A4 in size and header and footer should be 0.5 inch each.
3.3 Section
There should be two lines gap between the Introduction section and chapter title.
5
Fig. 3.1 Figure caption must be below the figure
Figure must be clear and there must be x and y labels and its values in the figure. If
there are multiple curves in one figure then legends must be provided.
3.4 Summary
Final summary of this chapter goes here.
6
CHAPPTER 4
HARDWARE DEVELOPMENT
4.1 Introduction
This chapter will be explaining about the …..
4.2 Section
Chapter number should be in 36 font size and chapter title should be in 28 font size
and in Times New Roman font.
4.3 Summary
Final summary of this chapter goes here.
7
CHAPTER 5
RESULTS AND DISCUSSIONS
5.1 Introduction
This chapter will present all the results and calculations and relevant discussions.
5.2 Section
Results may be presented in graph/chart or table etc. Graphs and Tables should be
numbered as per chapter number.
5.2.1 Sub-section
Multiple results for one category may be presented in sub-section. Each figure or table
must accompany necessary explanation.
5.3 Summary
Final summary of this chapter goes here.
8
CHAPTER 6
CONCLUSIONS
6.1 Conclusions
Summarize your works here. Give your concluding remarks here.
9
REFERENCES (24 font size)
10
Appendix A
Any derivation
11
Appendix B
Any data sheets or IC pin configuration
12
Appendix C
Any figure with explanation that could not be accommodated in any chapter
13
Appendix D
Any name plate data can be here
14