Documente Academic
Documente Profesional
Documente Cultură
· AUTOMATIC GAIN
CONTROL ADAPTATION TO
ENVIRONMENTAL CHANGES
1 2 3 4 5
6 7 8 9 10
DETECTOR TESTING 4. Test the ultrasonic channel · Stay for a while to make Use the potentiometer R11 DETECTOR OPERATING
AND ADJUSTMENT operation. sure the green LED stops (Microphone Sensitivity), MODES
blinking, which means the to adjust the high-frequency
· First of all, make sure there The detector PATROL-USR
1. Remove the front cover. detector ultrasonic channel sound channel sensitivity.
are no humans or animals has two operating modes:
is configured correctly!
2. Set jumper J8 to MODE 2 within the protected area, If the green LED keeps 6. Simulate the alarm by
position. windows are closed; air blinking, check the premises activating the glass breakage
conditioners, fans and other without interferences, as simulator, and at the same
3. Connect the power – red possible sources of air flow described above. time taking a step towards
LED will blink. At the same are switched off. If necessary, reduce the the detector. The red alarm
time, keep the detector excessive ultrasonic channel LED will light.
field-of-view clear until the · Walk into the detector sensitivity with the J4
7. Set the desired operating MODE 1
red LED stops blinking - the field-of-view. The green LED (Ultrasonic Sensitivity)
mode using the J8 (MODE) For premises with stable
anti-masking function will should actively respond to your jumper.
jumper. environmental conditions.
then be correctly activated. movement. If needed, increase
Anti-mask startup (boot) the detector ultrasonic channel 5. Test the high-frequency
period is 30 seconds. sensitivity using J4 (Ultrasonic sound channel operation. · To operate the detector MODE 2
Sensitivity) jumper. without light indication, remove To provide extra security
If upon testing and detector Use the glass break simulator the J9 (LED) jumper. measures for banks, safes,
adjusting, the red LED keeps to simulate the high-frequency vaults, jewelry stores, pawn
blinking, it means the anti- glass breakage signal. 8. Replace the cover. shops, museums and other
masking function is activated. The yellow LED will respond facilities that store valuables.
Turn off the detector and then to each simulator activation.
turn it back on.
11 12 13 14 15
16 17 18 19 20