Documente Academic
Documente Profesional
Documente Cultură
G1IF4 provides two RS485 communication ports. The first is for communication to protection
relays using the IEC60870-5-103 protocol. The second is dedicated for the interface of G1IF4
and TOSHIBA GR relays, and is used for monitoring and maintenance by RSM100.
The Ethernet LAN and TCP/IP protocol are used for communication to the station bus. The
transmission medium is 100 BASE-TX UTP cable or 100 BASE-FX optical fibre.
G1IF4 not only has serial communication interfaces, but also binary input circuits to acquire
many forms of non-IEC61850 data/signals.
Valuable information exists in the substation within non-digital or non-IEC61850 devices and
G1IF4 is used to integrate this information into the automation system.
ALARM Metering
1 Metering
1 Metering
1
Hard TEST
Wired
LAN CONN F AI L
IN SERVICE IN SERV ICE IN SERVICE
VIE W VIEW VIEW
TRIP TRIP TRIP
TIME SYNC LOSS ALARM ALARM ALARM
TRIP
A
BI Type GRT100
Model 201
In
Vn
fn
Vdc
100
B-10-10
1A
/110/115/120
50Hz
110/125V DC
V
7
4
8
5
9
6
Type GRT100
Model 201
In
Vn
fn
Vdc
100
B-10-10
1A
/110/115/120
50Hz
110/125V DC
V
7
4
8
5
9
6
Type GRT100
Model 201
In
Vn
fn
Vdc
100
B-10-10
1A
/110/115/120
50Hz
110/125V DC
V
7
4
8
5
9
6
MADE IN J APAN MADE IN J APAN MADE IN J A PAN
A B 0V 1 2 3 A B 0V 1 2 3 A B 0V 1 2 3
G 1 IF 4 0 . - 0 . - 0 . -
Type
Model 101A-10- L0
In -- CAN CAN CAN
ENTER END CEL ENTER END CEL ENTER END CEL
Vn --
fn --
Vdc 110/125DC
Made i n J apan
Functions:
o Interface from/to IEC61850
o RSM100 Gateway
o Time Synchronising
o Human Interface
o Operation Mode
o Automatic Supervision
o Event Recording
Communication Functions:
o IEC61850 station bus
o RSM100 local PC access
IEC60870-5-103 relays
Up to 10 relays
IEC61850 relays
RS485/RSM100
Binary I/O
Non-numerical devices
Binary I/O or BI/BO based devices
100BASE-TX/FX
IEC61850 Interface Unit
•Remote I/O Common circuits in relay panel
function •Protection function status: IN/OUT, ON/OFF
•Lockout relay status
•For each panel •Relay test status
•VT fail
Binary I/O
•DC/AC fail
•etc.
•Lockout relay reset command
Protection relay panel