Documente Academic
Documente Profesional
Documente Cultură
Installation
In case the Tegra FRA is installed in a traffic area, the grating
must be such that no direct wheel loads are transferred to
the shaft. The best practice in these cases is to use a
"floating" concrete slab around the shaft.
1. Prepare a suitable bedding material.
2. Position the Tegra FRA base on the bedding material on
spirit level.
3. Make pipe connections in the same way as the standard
ring seal jointing of fittings.
0702/4000
All information contained in this literature is given in good faith. The user should, however, check that the product is suitable for purpose,
in the application for which it shall be used. Please ensure compliance with all health and safety requirements. Whilst continuing its
programme of continuous development, Wavin Overseas B.V. reserves the right to modify or extend any published information
without any prior notification. No responsibility can be accepted for any error, omissions or incorrect assumptions.
Tegra FRA Range