Documente Academic
Documente Profesional
Documente Cultură
Hardware Structure
www.huawei.com
WMPT Mandatory 1 Slot 7 Preferentially configured in slot 7 in the case of a single WMPT
GTMU Mandatory 1 Slot 5 and slot 6 Only configuredin slot 5 and slot6
Only configured in slot 2 and slot 3 in the case of the WBBP that transmits
WBBP Mandatory 4 Slot 0 - Slot 3
CPRI Signals
UPEU Mandatory 2 PWR1 o PWR2 Preferentially configured in the PWR2 slot in the case of a single UPEU
In the case of less than or equal to four E1s, one UELP is required and
installed in slot 4. In the case of more than four but less than or equal to
UELP Optional 2 Slot 0 or slot 4 eight E1s, two UELPs are required and installed in slot 0 and slot 4. In the
case of more than eight E1s, the SLPU is required and the UELPs are
installed in the SLPU.
USB USB Enables the automatic software upgrade from a USB disk.
DIP Status
DIP Switch Description
1 2
DIP Status
DIP Switch Description
1 2 3 4
FE optical port
FE1 SFP connector
USB connector
TEST USB testing port
1 ON OFF ON
2 ON OFF ON
SW1
3 OFF ON ON
4 OFF ON ON
1 OFF ON
2 OFF ON
SW2
3 OFF ON
4 OFF ON
WBBPb1 3 64 64
u The UELP has one DIP switch, which is used to select whether the receive
terminal is grounded.
S1 ON ON ON ON 75-ohm E1 cable
u The panel of the UTRP configured with the UAEU or UIEU is different from
that of the UTRP configured with the UUAS.
)
Panel of the UTRP (with 2 FE/GEs
The module is
1s ON, 1s OFF
STATE running properly.
CPRI CPRI0 SFP female connector Connecting to the BBU, or the upper-level
RFU during the cascading.
Interconnection port RX_INB QMA female Input port of diversity signals in the
antenna channel.
for RF connector
Receive signals RX_OUTA Output port of diversity signals in the
antenna channel.
MRFU DL UL
Whole 25MHz frequency band
935-960MHz 890-915MHz
of 900MHz
Low 45MHz of 1800MHz 1805-1850MHz 1710-1755MHz
High 45MHz of 1800MHz 1835-1880MHz 1740-1785MHz
Low 40MHz of 1900MHz 1930-1970MHz 1850-1890MHz
High 40MHz of 1900MHz 1950-1990MHz 1870-1910MHz
u Power sharing doesn’t support Concentric cell, Co-BCCH, IBCA, RAN sharing while
static power can support these functions.
u MRFU supports 2-way RX diversity. 4-way RX diversity and TX diversity are not
supported.
GSM+UMTS 3 1 20 20
mode 4 1 20 10
4 1 17 20
3 2 20 10
3 2 12 20
4 2 13 10
5 1 15 10
0 1 0 60
0 2 0 40
UMTS mode
0 3 0 27
0 4 0 20
M M M M M M M M M
DCS R R R R R R R R R GSM
S888 R R R R R R R R S4/4/4
R
U U U U U U U U U
D D D D D D G G G
APM30
BBU W W W
EMUA R R R
R R R
U U U
W W W
Base Frame
WCDMA
S222