Documente Academic
Documente Profesional
Documente Cultură
133-121
Specification
Model K 1800 IB
Operating pressure 1800 PSI
Water volume 2.0 GPM
Engine 4.0 HP Briggs & Stratton Quattro
Model K 2200 IB
Operating pressure 2200 PSI
Water volume 2.2 GPM
Engine 6.0 HP Briggs & Stratton Quantum
Manual Part No. 9.139-111
MODEL K 1800 IB/2200 IB OVERVIEW
NOTE: Engines controls shown may appear different.
Item Description
1. Water inlet 9 8
2. Detergent suction tube 7 6
3. Oil fill cap 14
4. Knob Assembly (two each):
Hex Head Screw 5
Serrated Washer Knob 10
5. High pressure hose
6. Detergent filter
7. Handle 11
8. Trigger gun safety lock
9. Trigger gun
10. Pull start
11. Gas tank
12. Vario spray wand
3
13. High pressure outlet
14. Accessory rack
15. Manual
16. 4 screws for accessory 4
rack (not pictured)
12
2
1
13
14
NEVER!
Never add fuel with the engine running or operate where fuel has been spilled.
Never operate without the water turned on and never use hot water.
IMPORTANT PRECAUTIONS – Read First!
Step 1 Slide the handle through the Step 2 Align the holes of the accessory
accessory rack. rack to the handle and fasten the four (4) screws.
Step 3 Check oil level. Oil level should Step 4 Insert the detergent tray into one
always be between the “FULL” and “ADD” of the slots of your choice and screw in the
marks on the dipstick. Be sure the machine is fastener. Fill with the proper detergent for
level when checking the oil level. (Refer to the your cleaning project.
engine’s operating manual for seasonal
grades.)
Step 6 Model K 1800 IB: Step 6 Model K 2200 IB: Slide the throttle con-
Slide the throttle control to the fast trol to the fast position. Thenmove the choke lever
position. Then push primer ball three to the “CHOKE” position (only if engine is
times. Wait 3 seconds between each cool).After starting, move the choke to “RUN”.
push.
Note: in cold weather push 5 times
In USA Call:
1-800-537-4129
or visit our website:
www.karcher-usa.com
The following Kärcher detergents
Step 3 Fill a container with Karcher are available:
detergent. Place the filter end of detergent • Vehicle Wash • House Wash
suction tube into the container. • Degreaser • Deck Wash
• All Purpose Cleaner
Step 5 Disconnect the Step 6 Disconnect the high pressure hose from the
garden hose from the high pressure outlet and engage the gun safety lock.
water inlet on the unit.
Step 1 Turn off the Step 2 Press trigger to Step 3 Engage gun
engine. release water pressure. safety lock.
10
Unit does not reach Diameter of garden hose Replace with a 3/4 inch garden
high pressure. is too small. hose.
Water supply is restricted. Check garden hose for kinks, leaks
and blockage.
Not enough inlet water supply. Open water source full force.
Water inlet filter is clogged. Remove filter and rinse out in warm
water.
Output pressure Not enough inlet water sup- Turn water on full force. Check gar-
varies high and low. ply. den hose for kinks, leaks or blockage.
Pump is sucking air. Check that hoses and fittings are air
tight. Turn off machine and purge
pump by squeezing trigger gun until
a steady flow of water emerges
through the nozzle.
Water inlet filter is clogged. Remove filter and rinse out in warm
water.
Discharge nozzle is Blow out or remove debris with a
obstructed. fine needle.
Calcified gun, hose or Run distilled vinegar through
spray wand. detergent suction tube.
TROUBLE SHOOTING - continued
Spray wand leaks. Spray wand not properly Insert the spray wand into the trigger
attached. gun. Carefully press in against the
11 spring tension and twist into the
locked position.
Broken o-ring or plastic Call Kärcher customer service
insert. hotline and order repair kit
(part no. 2.883-111.0).
Pump is noisy. Pump is sucking air. Check that hoses and fittings are air
tight. Turn off machine and purge
pump by squeezing trigger gun until
a steady flow of water emerges
through the nozzle.
Water leaks from Loose fittings. Check that all fittings are tight.
pump (up to 10 drops
per minute Thermal protection device Thermal protection device will
is permissible). has been activated. automatically reset.