Documente Academic
Documente Profesional
Documente Cultură
LOCTITE® 262™
December-2009
l
ee
St
Viscosity Medium, thixotropic 75
Cure Anaerobic Zinc dichromate
Secondary Cure Activator
Application Threadlocking 50
Strength Medium to High Brass
® 25 el
LOCTITE 262™ is designed for the permanent locking and s ste
sealing of threaded fasteners. The product cures when in les
Sta
confined in the absence of air between close fitting metal 0
surfaces and prevents loosening and leakage from shock and 1min 5min10min 30min 1h 3h 6h 24h 72h
Cure Time
vibration. Typical applications include the locking and sealing
of large bolts and studs (up to M25 ). The thixotropic nature of Cure Speed vs. Bond Gap
LOCTITE® 262™ reduces the migration of liquid product after The rate of cure will depend on the bondline gap. Gaps in
application to the substrate. threaded fasteners depends on thread type, quality and size.
The following graph shows shear strength developed with time
Mil-S-46163A on steel pins and collars at different controlled gaps and tested
LOCTITE® 262™ is tested to the lot requirements of Military according to ISO 10123.
Specification Mil-S-46163A. Note: This is a regional approval. 100
% of Full Strength on Steel
m
ASTM D5363
5m
m
5m
m
Each lot of adhesive produced in North America is tested to
0.0
2
0.1
0.
the general requirements defined in paragraphs 5.1.1 and 50
5.1.2 and to the Detail Requirements defined in section 5.2.
NSF International 25
Registered to NSF Category P1 for use as a sealant where
there is no possibilty of food contact in and around food
processing areas. Note: This is a regional approval. Please 0
contact your local Technical Service Center for more 1min 5min10min 30min 1h 3h 6h 24h 72h
information and clarification. Cure Time
C°
Compressive Shear Strength, ISO 10123:
22
50 Steel pins and collars N/mm² ≥3LMS
(psi) (≥435)
°C
5 °C
40
25
% Strength @ 22 °C
100 75
% of Full Strength on Steel
75 50
No activator
49
50 25
76
71
74
25 0
0 50 100 150
Temperature, °C
0
1min 5min10min 30min 1h 3h 6h 24h 72h
Cure Time Heat Aging
Aged at temperature indicated and tested @ 22 °C
TYPICAL PROPERTIES OF CURED MATERIAL 125
% Initial Strength @ 22 °C
Physical Properties:
Coefficient of Thermal Expansion, 80×10-6 100
ISO 11359-2, K-1
Coefficient of Thermal Conductivity, ISO 8302, 0.1
W/(m·K) 75
120 °C
Specific Heat, kJ/(kg·K) 0.3
50
After 24 hours @ 22 °C 0
Breakaway Torque, ISO 10964: 0 1000 2000 3000 4000 5000
M10 steel nuts and bolts N·m 22 Exposure Time, hours
(lb.in.) (190)
Reference 0.7