Documente Academic
Documente Profesional
Documente Cultură
10
9 8 7
© Allendale Group
3
4 5
2
8 7
5
© Allendale Group © Allendale Group 3
© Allendale Group 5
© Allendale Group
3
4 1
2 Standard1Depth Gauge Depth Gauge with Hook Depth Gauge with Hook3 Depth Gauge with Hook
4 25 4
Depth Measurement
1 Depth Measurement 2 Thickness Measurement
2 Step Measurement
(add hook thickness to display value) (add hook thickness
6 to display value)
Battery Replacement
3
4 5 Magnet
8
Positive (+)
7
5 tipped
3 side up
2 5
tool 7
5
3 3
1 4
2
machine-dro.co.uk
6 4 6 4
2 2
1. Slide open the battery cover. 2. Lift battery cover front edge. 4. Remove battery (a magnet tip 6. Insert replacement battery
3. Remove cover. tool can be used). edge against side contact.
5. Locate side spring contact. 7. Press down on other edge.
8
7 10
11 8
10
12 11
9 11
12
8. Insert the two lugs on the 10. Pull battery cover outward 12. Slide battery cover fully
cover.
8 sightly closed.
9. Gently lower battery cover. 11. Fully lower cover 10
10 10
www.machine-dro.co.uk - Allendale Electronics Ltd, Pindar Road, Hoddesdon, Hertfordshire. EN11 0BZ.
Images & Content ©2010 Allendale Electronics Limited. E&OE - Specifications subject to change without prior11
notice.
11 9 12 11
Calibrating Standard Depth Gauge
Metric/Inch conversion
mm
25.40 mm/inch in
1.000 mm/inch
Trouble Shooting
Problem Possible Cause Solution
Flashing display Low voltage Replace battery
machine-dro.co.uk
Poor contact Clean contact
No display Dead or weak battery Replace battery
Poor contact Clean contact
No change to display Internal error Remove battery for 1 hour
"H" shown on display Remove battery for 5 minutes
Can't zero Hold function active Switch off function
Tolerance function active Switch off function
Erratic or frozen display Contamination between beam & head Wipe clean
low voltage Replace battery
Erroneous reading Low voltage Replace battery
Contamination between beam & head Wipe clean
Low ambient temperature Store at normal room temperature
www.machine-dro.co.uk - Allendale Electronics Ltd, Pindar Road, Hoddesdon, Hertfordshire. EN11 0BZ.
Images & Content ©2010 Allendale Electronics Limited. E&OE - Specifications subject to change without prior notice.