Documente Academic
Documente Profesional
Documente Cultură
¾ An efficient system of drainage to carry away surface and soil water from a building is essential. If
the drain is unsound and leaking, the escaping water may be a risk to public health and may also
wash away the soil below the foundations, causing undue settlement of the building.
¾ Drains must satisfy various technical considerations and very often drainage economy influence the
sitting and planning of a building.
¾ Where a public sewer is available, it is usually economical to discharge the drainage into it.
¾ If the public sewer passes within 30m of the site, the local authority may insist that drainage be
connected to it.
Systems of Drainage
Combined System
¾ This uses a single drain to convey both foul and surface water to a shared sewer. The system is
economical to install, but the processing costs at the treatment plant are high.
Separate System
¾ Foul water discharges are conveyed by foul water drains to a foul water sewer or private sewer
disposal plant, while surface water is drained to a public surface water sewer or soak away.
¾ This is shown on the diagram above.
1
Partially Separate System
¾ Basically a separate system but in order to serve on drainage costs some isolated drain water inlets,
usually at the rear of the building, are allowed to be connected to a foul water drainage.
1. Two sets of drains, increases the cost - Only one drain for both foul & surface
of drainage. water which reduces the cost of drainage,
although this can be offset by size of
drain.
2. There is risk of wrong connection – - No risk of wrong connection
foul drain to surface water drain.
3. Foul water drain not thoroughly - Foul water thoroughly flushed by the
flushed by rainwater. surface water.
4. Size of sewer disposal plant is much - The size is greater.
smaller
5. Cost of sewage purification is less - Cost is greater
6. If sewage is pumped to the sewage - Possibly greater pumping costs.
disposal works there is reduction in cost
of pumping.
Drain Diameters
¾ The size of surface water drain should be sufficient to carry away the usual maximum rainfall
intensity for the area, with an allowance for the impermeability factors of various types of surfaces.
¾ If a drain is oversized, the depth of water will be reduced, which may not be sufficient to carry the
solids.
An undersized drain, on the other hand will lead to a surcharge and water will backflow through the
gully traps and becomes a nuisance to the environment.
¾ An allowance must be considered if there is a possibility of future expansion of community.
¾ Discharge capacity depends upon gradient, diameter and smoothness of the bore and accuracy pipe
laying.
¾ Various tables and charts may be used to find the diameter of both foul and surface water drains.
Alternatively the diameter may be found by calculations:
= A x RI x IF
3600
Question one
Calculate the diameter of a main surface water drain for an asphalt covered car park measuring 100 x 75m.
Assume the following:
3
¾ Rainfall intensity = 50mm/hr
¾ Velocity = 0.8m/sec
¾ Impermeability factor = 0.90
Question two
The total surface area of footpaths and roadways of a building development scheme is found to be 4000m2.
Calculate the diameter of the main surface water drain, using the following data:
¾ Rainfall intensity = 50mm/hr
¾ Impermeability factor = 0.80
¾ Full bore discharge
¾ Velocity of flow = 0.80m/s
Gradient
Various formulae and tables may be used to find the gradient or fall of the drain. One of the best known
formulae which may be used for pipes and channels, is known as ‘Chezy’s” expressed as follows:
For half or full bore discharge, the hydraulic mean depth is = D/4 (also from calculations)
Example
Calculate the gradient required for a 150 mm diameter private sewer flowing half full bore at a velocity of
0.8m/s.
V = C θ(D/4 x 1/L)
L = (C/V)^2 x D/4
L = 4726.5625 x 0.0375
L = 177
Gradient = 1 in 177
4
¾ Where sewer disposal is not provided by a municipal sewage system, it is necessary to install a small
sewage purification plant.
¾ Where a sewer is within 30m of site boundary the local authority often compels an owner of property
to connect his foul water to the public sewer.
¾ In rural areas, however, considerations of expense often prevent the LA from providing sewers and
sewage purification plants and it becomes necessary to install a small sewage purification plant for
one or more isolated buildings.
Wherever a private sewer has to be connected to the public sewer, a manhole has to be constructed, and
this can be:
i. Junction Manhole
5
ii. Drop manhole
¾ This is constructed where the branch sewer is higher than 60cm from the main line.
6
Waste water treatment
The purpose of sewage treatment can be summarized by the aims given below:
• To protect public health
• To protect the environment
• To convert waste water into stable end-products
• To dispose off the end products in a safe manner
• To recover and recycle materials if possible
• To operate without nuisance or offence
• To provide and economic system
• To comply with appropriate standards and legislation
1. A cesspool
• A watertight underground container used for the storage of household sewage.
• No treatment occurs and the tank must be periodically emptied and the sewage taken away for
treatment
7
• Constructed in a variety of ways including insitu concrete and prefabricated plastic and fibreglass
which are usually set in concrete.
• In order to reduce periodic empting costs a large capacity is desirable with min (BS) being 18m3.
• On the other extreme its not structurally viable to construct a cesspool of over 50m3.
• Effective storage calculations may be based on 150L per person/day
E.g. a 3-person household at 60 days emptying interval = 3 x 150 x 60 = 27000L/27m3
¾ A septic tank is a watertight chamber in which the sewage is acted upon by anaerobic bacteria
which breaks up the crude sewage and converts it into gases and liquid forms.
¾ The anaerobic bacteria work in the absents of oxygen hence the septic tank should be covered.
¾ Slug falls onto the bottom of the tank and scum floats on top of the liquid.
¾ Scum acts as an air-excluder and the liquid will flow out of the tank as new sewage enters.
¾ The inlet and outlet pipes of the tank should be submerged to ensure that the sewage can not flow
across the top of the tank without being broken down by bacteria and also to prevent the scum
which forms on top of the liquid from being broken. Bacteria, therefore, should not be destroyed
by passing in disinfectant into the lavatory pan or WC.
¾ The second process (aerobic digestion) collects liquid from the septic tank and allows it to
percolate through the soil or passing the liquid through a biological filter.
¾ Alternatively the effluent can be passed through a chamber that is filled with stones or broken
bricks which is ventilated for oxygen.
¾ The liquid is sprinkled onto broken stones or bricks whose surface will eventually get covered a
jelly containing one celled animals called ciliates together with aerobic bacteria.
¾ The ciliates feed on bacteria carried by water from 1st chamber while bacteria break down
organic materials such as urea aerobically.
¾ Water that runs out of the second chamber is quite safe to be deposited into rivers, or it can be
directed to orchards, fields or piped to a soak away.
¾ Slug (sediments) is removed from time to time at intervals of 6 - 12 months, pumped out by LA
vehicles or shoveled out and buried in pits / burned / used as fertilizers. Burying or burning is
very appropriate during times of disease outbreaks like cholera.
8
Size
The code of practice BS 1697 Small Sewage Treatment Works 1983 gives the following formula for
the total capacity of the tank, where dislodging is carried out at not more than 12 months:
C = 180P + 2000 where C = capacity of tank in liters with a minimum value of 2700 ltrs
P = population with min of 4.
Where the number of people served is 4 the capacity of the tank is: C = 180 x 4 + 2000
= 2720 liters.
This is in line with the Building regulations 1992 where the minimum capacity of the tank is 2700
liters.
Note that a double chamber septic tank is suitable for a community of 100 people and above.
9
Soak ways
Pit is dug on a sloping ground so that water flows away from the house ( if it for surface water only)
or pipe laid to a gradient from the septic tank.
The pit is filled with stones or brick rubbles to prevent sides caving in. Unfilled or hollow soak ways
be built of precast concrete or masonry.
3. Stabilization ponds
• A stabilization pond or lagoon is any enclosed body of water where organic waste is allowed
to oxidise by natural activity.
• Ponds can be simply contained by earth embarkments
• Easiest to operate where there is plenty of sunshine and land,
• Also simple to maintain and very effective at removing pathogens.
• They are the most common form of treatment in developing countries.
• Operation of ponds can be loosely grouped as follows:
10
Anaerobic ponds – the formation of sludge and a top crust creates good anaerobic
conditions. These are particularly suitable for strong and thicker waste.
Oxidation ponds– aerobic systems where oxygen is taken from the atmosphere and also
supplied by the activity of algae in the ponds. The ponds are kept shallow (1-2m) to allow
maximum penetration of sunlight.
Aeration ponds – in these ponds oxygen is supplied by aerators and not by the action of
algae.
The natural process associated with the growth of aquatic plants can be used in the treatment of
waste water.
E.g. Of plants include submerged algae, floating plants like hyacinth and ermerging plants like
reeds
Micro-organisms develop around the plants and their root systems and these allow both aerobic
and anaerobic bacteria to develop and to digest the sewage products
This vegetation can encourage the formation of artificial wetlands or reed beds and these can
then be used for the secondary and tertiary treatment of sewage
The plants are grown on beds of soil or gravel which are retained by an impervious lining.
11