Sunteți pe pagina 1din 8

HandA-Accessories.

com

Accessory Application Publications No.


AII 27857
INSTALLATION CD/CASSETTE PLAYER
CIVIC
2- AND 4-DOOR Issue Date
INSTRUCTIONS AUG 2004

PARTS LIST CD Player:


Cassette Player: P/N 08A53-S5D-100
P/N 08A53-S5A-100
CD player
Cassette player

Owner’s Manual

4 Washer-screws, 5 x 8 mm
Owner’s Manual
Washer-screw, 4 x 8 mm

Harness clip
5 Washer-screws, 5 x 8 mm

Rubber pad

Harness clip
TOOLS AND SUPPLIES REQUIRED
Phillips screwdriver
8 mm and 10 mm Sockets
Ratchet
Adhesive pad Shop towel
Utility knife
Isopropyl alcohol
Tape measure

Rubber pad INSTALLATION

Customer Information: The information in this


installation instruction is intended for use only by
skilled technicians who have the proper tools,
equipment, and training to correctly and safely add
equipment to your vehicle. These procedures should
not be attempted by “do-it-yourselfers.”

1. Make sure you have the anti-theft code for the


radio, then write down the radio station presets.
2. Disconnect the negative cable from the battery.

© 2004 American Honda Motor Co., Inc - All Rights Reserved. AII 27857 (0408) 08A53-S5A-1000-91 1 of 8
If the vehicle is equipped with a center console M/T Model:
armrest, go to step 6, otherwise; continue with step 3.
• Remove the shift knob from the lever by holding
3. Pull up on the parking brake lever, then remove the the plastic section above the boot down firmly
console box (nine clips). with one hand and turning the knob in a
counterclockwise with the other hand.
CLIPS (9)
CONSOLE BOX • Remove the two self-tapping screws, two
screws, and two clips that fasten the center
console and remove the console.

SHIFT
CLIP KNOB
SELF-TAPPING
PLASTIC SCREW
CLIP SECTION
BOOT

CENTER
CONSOLE

PARKING BRAKE
LEVER
Pull up
completely.

4. Remove the center console.


A/T Model: SHIFT LEVER
Place in the
SCREW
• Place the shift lever in the Neutral position. Neutral position.

3620030K
• Remove the two self-tapping screws, two
screws, and two clips that fasten the center
console and remove the console
• If equipped with an optional seat armrest,
remove the console after reclining the seat-
back.
SELF-TAPPING
SCREW
CLIP

CENTER
CONSOLE

SHIFT LEVER
Place in the SCREW
Neutral position.
3620020K

2 of 8 AII 27857 (0408) © 2004 American Honda Motor Co., Inc - All Rights Reserved.
5. Remove the dashboard center lower cover. If the vehicle is not equipped with a center console
armrest, go to step 10, otherwise; continue with step 6.
Without a Cigarette Lighter and Ashtray:
6. Remove the escutcheon, and the center console
• With the parking brake applied, place the gear
trim:
shift lever in the Neutral position.
A/T Model:
• Gently pry out on the lower cover to release the
six retaining clips. • With the parking brake applied, place the shift
lever in the Neutral position.
• Unplug the accessory power socket connector
(if equipped, unplug the fog light harness), and • Pry up on the four retaining tabs and remove
remove the lower cover. the escutcheon.
• Pry up on the three clips and six retaining tabs
and remove the center console trim.
ACCESSORY RETAINING
POWER TABS (6)
SOCKET
CONNECTOR CENTER CONSOLE
TRIM

FOG LIGHT SWITCH


CONNECTOR FOG LIGHT ESCUTCHEON
(if equipped) SWITCH
(if equipped)

CLIPS (6) DASHBOARD CENTER


LOWER COVER

CLIPS (3)
With a Cigarette Lighter and Ashtray:
• With the parking brake applied, place the gear
RETAINING
shift lever in the Neutral position. TABS (4)

• Remove the ashtray.


• Inside the ashtray opening, remove the one
self-tapping screw securing the dashboard
center lower cover.
• Gently pry out on the lower cover to release the
six retaining clips.

ILLUMINATION
BULB
CIGARETTE
LIGHTER
CONNECTOR

RETAINING ASHTRAY
CLIPS (6)

SELF-
TAPPING
SCREW

3304120W

DASHBOARD CENTER
LOWER COVER

© 2004 American Honda Motor Co., Inc - All Rights Reserved. AII 27857 (0408) 3 of 8
M/T Model: 7. Remove the dashboard center lower cover.
• Apply the parking brake. Without a Cigarette Lighter and Ashtray:
• Remove the shift knob from the lever by • Remove the two self-tapping screws that fasten
holding the plastic section above the boot down the dashboard center lower cover.
firmly with one hand and turning the knob
• Gently pry out on the dashboard center lower
counterclockwise with the other hand.
cover to release the rear four clips, then pull the
• Pry up on the three clips and six retaining tabs cover rearward to release five clips and one
and remove the center console trim. retaining tab.
• Unplug the accessory power socket connector
(If equipped, unplug the fog light harness), and
SHIFT KNOB RETAINING
TABS (6)
remove the dashboard center lower cover.
PLASTIC
SECTION
FOG LIGHT SWITCH
(if equipped) RETAINING TAB
BOOT
SELF-TAPPING
SCREW

DASHBOARD
CENTER
CLIPS (9) LOWER
COVER

CLIPS (3)

CENTER
CONSOLE TRIM 3624030K

FOG LIGHT
SWITCH ACCESSORY
CONNECTOR SOCKET
(if equipped) CONNECTOR
CENTER PANEL

KNOB

SELF-TAPPING
SCREW HEATER
CONTROL
PANEL

4 of 8 AII 27857 (0408) © 2004 American Honda Motor Co., Inc - All Rights Reserved.
With a Cigarette Lighter and Ashtray: 8. Open the center console lid, and remove the mat.
• Remove the ashtray. Inside the ashtray
opening, remove the one self-tapping screw. SELF-
TAPPING MAT
• Remove the two self-tapping screws that fasten SCREW
the dashboard center lower cover. CLIPS (2) CENTER
CENTER CONSOLE LID
• Gently pry out on the dashboard center lower CONSOLE
cover to release the rear four clips, then pull the
cover rearward to release five clips and one
retaining tab.
• Unplug the cigarette lighter connector, the
accessory power socket connector, and the
illumination bulb, then remove the lower cover.

DASHBOARD
CENTER
LOWER COVER

RETAINING TAB ASHTRAY

SCREW

SHIFT LEVER 3624040K


SELF- Move to the
TAPPING Neutral position.
CIGARETTE SCREW
LIGHTER
CONNECTOR
9. Remove the two clips, two self-tapping screws and
three screws that fasten the center console. Move
the shift lever to the Neutral position, and remove
the center console.

ILLUMINATION
BULB CLIPS (9)

3804020K

© 2004 American Honda Motor Co., Inc - All Rights Reserved. AII 27857 (0408) 5 of 8
10. Remove the center panel: 13. Remove the pocket (four self-tapping screws).
• Remove the two bolts from the bottom of the
center panel.
SELF-TAPPING SCREW
• Reach through the bottom opening, and push (Discard.)
out on the center panel bracket to release the
nine clips.
• Unplug the five connectors and the antenna
lead, then remove the center panel.

POCKET
CENTER VEHICLE HARNESS
PANEL CONNECTORS (5) CENTER
PANEL

RETAINING
CLIPS (9) ANTENNA
LEAD SELF-TAPPING
SCREW
(Discard.)

Push. 14. Use a tape measure to measure and mark the


CENTER rubber pad as shown. Using scissors, cut the
PANEL BOLT
BRACKET rubber pad into three pieces. Remove the adhesive
backing from each of the rubber pads, and attach
them to the center panel in the areas shown.
11. Gently pull out on each knob to remove them from
the heater control panel.
RUBBER
40 mm PAD
Thoroughly clean
40 mm
with isopropyl
CENTER PANEL alcohol.
RIB

ADHESIVE BACKING

KNOB

SELF-TAPPING
SCREW HEATER
CONTROL END OF CURVE CENTER PANEL
PANEL RUBBER PAD
(Cut.)

12. Remove the three self-tapping screws that fasten


the heater control panel to the center panel, and
remove the heater control panel.

6 of 8 AII 27857 (0408) © 2004 American Honda Motor Co., Inc - All Rights Reserved.
If you’re installing a cassette player, continue with 17. Slide the CD or cassette player into the opening of
step 15; otherwise, go to step 17. the center panel, then install the four screws
provided with the CD or cassette player.
15. Using a utility knife, cut off the bottom rib from the
center panel at the lower edge of the audio
opening. Remove all burrs. Before attaching the
CENTER PANEL
rubber pads, thoroughly clean the areas where the
rubber pads will attach with isopropyl alcohol.

CENTER PANEL

CD OR
CASSETTE
PLAYER

SCREWS (4)
(Provided with the
Install in CD or cassette
the lower player.)
hole.

Cut off the 18. Attach the harness clip to the rear of the CD or
bottom
rib. cassette player with the washer-screw provided.

Sectional
View
AUDIO UNIT
16. Remove the adhesive backing from the adhesive
pad, and attach it to the bottom of the cassette
player in the area shown.

ADHESIVE PAD
BOTTOM OF
CASSETTE PLAYER HARNESS
ADHESIVE CLIP
BACKING

CONNECTOR
CD OR
CASSETTE
PLAYER
WASHER-SCREW
CD player:
4 x 8 mm washer-
screw
Cassette player:
5 x 8 mm washer-
screw

19. Plug the connector from the CD or cassette player


into the rear of the audio unit, and secure the harness
with the harness clip.

© 2004 American Honda Motor Co., Inc - All Rights Reserved. AII 27857 (0408) 7 of 8
20. Reinstall the heater control panel and knobs on the 23. Reconnect the negative cable to the battery.
center panel.
24. Enter the anti-theft code, and reset the customer’s
radio station presets.
CENTER PANEL 25. Reset the clock.
26. Check operation of the CD or cassette player
according to the Owner’s Manual.
27. Reinstall all removed parts. Check that all clips
and fasteners are installed securely.
28. Place the Owner’s Manual for the CD player or the
cassette player in the glove box.
29. Test the operation of the accessory socket/
KNOB cigarette lighter.
NOTE: Whenever the battery is disconnected, the
SELF-TAPPING driver's window AUTO function is disabled.
SCREWS HEATER
CONTROL 30. Start the engine. Push down on the driver's window
PANEL
switch until the window is fully open.

To reinstall the 31. Pull up on the driver's window switch to close the
knobs, align the flat window completely, then hold the switch for 2
surface on the rod seconds or more.
with the flat surface
on the knob.
32. Lower and raise the driver's window to check
operation of the driver's window AUTO function.
21. Plug in the five vehicle harness connectors, then
plug the antenna lead into the rear of the audio 33. Do the ECM/PCM idle learn procedure.
unit. - Make sure all electrical items are turned off.
22. Reinstall the center panel with the two bolts. - Start the engine. Hold the engine speed at
3,000 rpm with no load (in Park or Neutral) until
the radiator fan comes on.
CENTER
PANEL VEHICLE HARNESS - Let the engine idle for about 5 minutes with
CONNECTORS (5) the throttle fully closed and with all electrical
items off.
NOTE: If the radiator fan comes on during this
step, the time it operates must not be included
in the 5 minutes.

ANTENNA
LEAD

BOLT
(reused)

8 of 8 AII 27857 (0408) © 2004 American Honda Motor Co., Inc - All Rights Reserved.

S-ar putea să vă placă și