Documente Academic
Documente Profesional
Documente Cultură
Fesler Billet makes every effort to ensure that you are provided with the most
accurate and up-to-date technical information. However, all technical
information is approximate and may vary upon application. Fesler Billet is not
responsible for any consequences resulting from manufacture’s technical mid-
year changes. Fesler Billet products should only be installed by a qualified,
licensed auto mechanic experienced in the installation of such products.
Fesler Billet designs all parts off original OEM applications. Due to the vast
array of manufacturers for aftermarket parts, it is possible that you may have to
INSTALLATION
make some minor adjustments to either our part or your sheet metal in order
for the part to fit properly. INSTRUCTIONS
FBTHG-70CHVL-CV
QUESTIONS OR COMMENTS? Trunk Hinges
1968 - 1972 Chevrolet Chevelle Convertible
Call us at 1-866-583-9787
INSTALLATION INSTRUCTIONS
1968-1972 Chevrolet Chevelle Convertible Trunk Hinges
Copyright 2011 © by Fesler Productions, LLC. All rights reserved.
Instructions:
9. Using the lower strut mount as a
1. Remove four bolts retaining trunk lid and remove trunk lid template, hold it against the trunk hinge
2. Remove trunk hinge springs. (Using vise grips or pliers will be helpful) support and push it back (towards front of
Each side has hooks on the body that the spring is locked car) and down until there is no movement.
into. Use and awl to mark the three holes.
3. Rotate the spring until the opposite end can be removed from the >>>>>>>>>>>>>>>>>>>>>>>>>>>>>>
hinge.
If you do not care about saving the springs you can cut
them with a die grinder to aid in the removal AFTER
SPRING TENSION IS RELEASED
4. With a die grinder carefully grind the head off the hinge pin
CAREFULLY, ***Be careful not to cut the outer body skin. 10. Center punch and drill holes using an angle
An angle die grinder works best. A mirror and light will drill. >>>>>>>>>>>>>>>>>>>>>>>>>>>>>
also be helpful.
Be sure to protect the carpet and all upholstery
5. After the head of the hinge pin is ground down remove the pin and
hinge. 11. Install lower strut mount using the three 5/16-18 6H bolts and flat
washers. Remove retaining pins from strut sockets and set aside (you
6. Install new hinges with studs for the struts pointing out towards the will need to replace them in step 12)
body
7. Line up the bushing with the hinge 12. Pop struts onto ball studs with the body
pin hole and install the provided attached to the hinge. Replace strut retaining
pin. Insert the pin from the center rings >>>>>>>>>>>>>>>>>>>>>>>>>>>>>>
of the car. >>>>>>>>>>>>>>>>>