Documente Academic
Documente Profesional
Documente Cultură
HTTP
HTTPS
WEP2
TFTP
Refer to the exhibit. A new branch office has been added to the corporate network and a new router is to be installed
branch office users to access the database server at headquarters. How should the serial 0/0/0 interface of the new b
office router be configured to connect to the headquarters router?
branch_23(config-if)# ip address 192.168.5.19 255.255.255.240
branch_23(config-if)# no shutdown
branch_23(config-if)# encapsulation hdlc
branch_23(config-if)# ip address 192.168.5.25 255.255.255.240
branch_23(config-if)# no shutdown
branch_23(config-if)# encapsulation ppp
branch_23(config-if)# no shutdown
branch_23(config-if)# encapsulation ppp
branch_23(config-if)# ip address 192.168.5.33 255.255.255.240
branch_23(config-if)# encapsulation ppp
branch_23(config-if)# ip address 192.168.5.21 255.255.255.240
branch_23(config-if)# no shutdown
3 Which two commands ensure that any password that permits access to the privileged EXEC mode is not shown in plai
when the configuration files are displayed? (Choose two.)
Router(config)# enable secret cisco
4 A new network is to be configured on a router. Which of the following tasks must be completed to configure this inter
implement dynamic IP routing for the new network? (Choose three.)
Select the routing protocol to be configured.
Update the ip host configuration information with the device name and new interface IP address.
Configure the routing protocol with the new interface IP address and subnet mask.
Configure the routing protocol in use on all other enterprise routers with the new network information.
The TCP Protocol Interpreter process verifies the transmitted data at source and destination.
6 A network administrator is asked to design a system to allow simultaneous access to the Internet for 250 users. The I
this network can only supply five public IPs. What can be used to accomplish this task?
routable translation
dynamic translation
static translation
RIP
OSPF
EIGRP
Refer to the exhibit. The network administrator needs to configure the router with a name. Which command will the
administrator use to configure the router name?
Router# ip hostname Boise
to allow the receiving host to assemble the packet in the proper order
to select the paths that are used to direct traffic to destination networks
11 Which two statements are true about the use of the debug ip rip command on a Cisco router? (Choose two.)
The debug ip rip command displays RIP routing activity in real time.
The debug ip rip command can be issued at the user EXEC configuration mode.
The debug ip rip command displays a combination of the information that is displayed by the show ip route an
ip protocols commands.
Because of router processor usage, the debug ip rip command should be used only when necessary.
The debug ip rip command should be used instead of the show ip route command whenever possible.
12 What minimum configurations must be set on a host to allow a request to be sent to http://www.cisco.com/? (Choose
DNS server
WINS server
IP address
NetBIOS
subnet mask
default gateway
13 A Catalyst 2960 switch has been taken out of storage to be used as a temporary replacement for another switch that
be repaired. About a minute after the switch has started, the SYST LED on the front of the switch transitions from blin
green to amber. What is the meaning of the amber SYST LED?
The switch has no configuration file in NVRAM.
The switch has failed POST and must be sent for service.
15After an unsuccessful ping to the local router, the technician decides to investigate the router. The technician observes
and fan on the router are not operational. In which layer of the OSI model is the problem most likely occurring?
transport
network
data link
physical
What are three characteristics of the TCP protocol? (Choose three.)
exchanges datagrams unreliably
is responsible for breaking messages into segments and reassembling them at their destination
17
Refer to the exhibit. The network shown is connected using services from the same ISP. How will the Fohi router d
learn routes to the 192.168.16.16/28, 192.168.16.32/28, and 192.168.16.64/28 subnetworks?
with BGP
18
Refer to the exhibit. Which type of UTP cable should be used to connect Host A to Switch1?
rollover
console
crossover
straight-through
19 When customers use credit cards to make purchases at a small business, a modem is heard dialing a telephone nu
transfer the transaction data to the central office. What type of WAN serial connection is in use?
leased line
packet switched
circuit switched
point-to-point
20 A user reports being unable to access the Internet. The help desk technician employs a bottom-up approach to
troubleshooting. The technician first has the user check the patch cable connection from the PC to the wall, and the
user verify that the NIC has a green link light. What will the technician have the user do next?
Enter an IP address into the WWW browser address bar to see if DNS is at fault.
Use traceroute to identify the device along the path to the ISP that may be at fault.
Verify the IP address, subnet, and gateway settings using ipconfig on the PC.
Connect to the user home router to check firewall settings for blocked TCP ports.
21
A ping 192.1.1.20 command is issued on workstation A to determine if workstation B can be reached. What even
if this command is successful? (Choose two.)
The router will block the ping request message.
The router will reply to the echo request with a proxy ping response.
23
Refer to the exhibit. Which two statements describe the data conversation shown? (Choose two.)
The data conversation was started by the HTTP application process running on the client.
The Internet server will send data to port 8547 on the client.
determining the IP address of the destination host in preparation for data transfer
synchronizing sequence numbers between source and destination in preparation for data transfer
network address
broadcast address
multicast address
26 A customer reports connectivity problems to an ISP technician. Upon questioning the customer, the technician disc
all network applications are functioning except for FTP. What should the technician suspect is the problem?
misconfigured firewall
27
The show ip route command was executed on one of the routers shown in the graphic and the following output w
displayed:
28 Refer to the exhibit. Which two sets of commands are required to configure passwords for all management ports o
2960 switch? (Choose two.)
ALSwitch(config)# interface vlan 1
ALSwitch(config-if)# password cisco
ALSwitch(config-if)# login
ALSwitch(config)# line vty 0 4
ALSwitch(config-line)# password cisco
ALSwitch(config-line)# login
ALSwitch(config)# line vty 0 15
ALSwitch(config-line)# password cisco
ALSwitch(config-line)# login
ALSwitch(config)# enable secret class
ALSwitch(config)# enable password cisco
ALSwitch(config)# interface fa0/1
ALSwitch(config-if)# password cisco
ALSwitch(config-if)# no shutdown
ALSwitch(config)# line cons 0
ALSwitch(config-line)# password cisco
ALSwitch(config-line)# login
29 A user reports being able to access the Internet but not being able to download e-mail from the mail server at the
should the user check on the user workstation?
the POP3 and SMTP server settings in the e-mail application
the patch cable connections at the back of the workstation and at the wall plate
30
Refer to the graphic. Which command will configure a static route on Router A to direct traffic from LAN A that is d
LAN C?
RouterA(config)# ip route 192.168.4.0 255.255.255.0 192.168.5.2
31 Which subnet masks could be used when subnetting a Class B IP address? (Choose two.)
255.255.255.240
255.255.192.0
255.255.0.0
255.192.0.0
240.0.0.0
255.0.0.0
32
Refer to the exhibit. The network administrator has configured the RTA and RTB interfaces. In order to allow hosts
attached to RTA to reach the server that is attached to RTB, a static route from RTA to the server LAN and a defau
from RTB back to RTA need to be configured. Which two commands will the administrator use to accomplish these
the two routers? (Choose two.)
RTA(config)# ip route 10.16.10.5 255.255.255.252 10.16.10.6
They alert network administrators to various type of denial of service attacks as they occur.
They prevent viruses, worms, and Trojans from infecting host computers and servers.
34
Refer to the exhibit. The network administrator of the building in the graphic needs to choose the type of cable best
ServerB to the network. Which cable type is the best choice?
STP
UTP
coaxial
fiber optic
35 What is used by a routing protocol to determine the best path to include in the routing table?
Convergence time
Default distance
Metric
Type of router
36
Refer to the exhibit. Which IP addresses could be assigned to the hosts in the diagram? (Choose two.)
192.168.65.31
192.168.65.32
192.168.65.35
192.168.65.60
192.168.65.63
192.168.65.64
37
Given the network 192.168.25.0 shown in the graphic, which subnet mask would accommodate the number of hos
subnet?
255.255.0.0
255.255.224.0
255.255.255.0
255.255.255.224
255.255.255.240
255.255.255.248
38 Which two protocols allow network devices to report their status and events to a centralized network management
(Choose two.)
Syslog
Telnet
HTTP
HTTPS
SNMP
Dynamic NAT allows hosts to receive the same global address each time external access is required.
40
Refer to the exhibit. The graphic shows the output of a command issued on router RTB. According to the output, w
statements are true of router RTB? (Choose two.)
The router is connected to a router named Boise.
The RTB router is connected to two Cisco devices by Fast Ethernet links.
41
Refer to the exhibit. The network administrator uses the command below to configure a default route to the ISP ne
A ping issued from the ISP is successful to router RTB. However, ping echo request packets arrive at a host that is
the Fa0/0 interface of RTB, and the replies do not make it back to the ISP router. What will fix this problem?
The ISP must be configured to forward packets from the 192.168.1.0 network.
The ip route command needs to be edited so that the next hop address is 10.1.1.5.
The ip route command needs to be edited so that the 192.168.1.1 address is the next hop address.
The ip route command should be removed from the RTB router configuration.
42 A network technician is using a network management station to gather data about the performance of devices and
the ISP. Which application layer protocol makes this possible?
SNMP
FTP
DHCP
SMTP
to simplify the administration of host and default gateway addressing on client computers
to assign TCP port numbers to hosts as part of the data transfer process
44 A hacker attempts to reach confidential information that is stored on a server inside the corporate network. A netw
security solution inspects the entire packet, determines that it is a threat, and blocks the packet from entering the
network. Which security measure protected the network?
an IDS
an IPS
a host-based firewall
Anti-X software
45How many host addresses may be assigned on each subnetwork when using the 130.68.0.0 network address with a
of 255.255.248.0?
30
256
2046
2048
4094
4096
46 In an IPv4 environment, what information is used by the router to forward data packets from one interface of a
another?
destination network address
47 A small tire retailer requires a low-cost WAN connection to its headquarters in order to manage its inventory and
customer sales in real time. Which WAN connection type is best suited to its needs?
Sonet
T3
dialup
DSL
leased line
48 The command copy tftp running-config has been entered on the router. What will this command do?
copy the configuration in RAM to a server
49
Refer to the exhibit. The network administrator needs to configure the Fa0/0 interface of RTB so that hosts from
connect to the server that is attached to RTB. Which two commands will the administrator use to accomplish thi
(Choose two.)
RTB# ip address 192.168.102.98 255.255.255.248
RTB(config)# no shutdown
RTB(config-if)# no shutdown
50
Refer to the exhibit. A NOC technician at an ISP enters the command shown. What are two reasons to use this c
(Choose two.)
to map the path to 192.168.1.7
to identify the ISPs that interconnect the NOC with the remote host with the address 192.168.1.7
to measure the time that packets take to reach 192.168.1.7 and return to the technician's workstation