Documente Academic
Documente Profesional
Documente Cultură
24 6:10 PM ˘ ` 2
Safety precautions
Safety Precautions
Warning ................................2 To prevent injury to the user or other people and property damage, the
following instructions must be followed.
Caution .................................3 ■ Incorrect operation due to ignoring of instruction will cause harm or
damage, the seriousness is classified by the following indications.
Operating Instructions
Preparation before operation ..4 This symbol indicates the possibility of death or serious injury.
Remote Control Features .....5
Operation Mode Selection ......7
Additional features..............13 This symbol indicates the possibility of injury or damage to
properties only.
Installation precautions
Care and Maintenance
Care and Maintenance .......16
Operation Tips ....................18 ■ Do not install, remove and reinstall the unit by yourself.
• Improper installation will cause water leakage, electrical
shock, or fire. Please consult authorized dealer or specialist
for the installation work. Please note fault caused by
Troubleshooting tips improper installation is not covered by warranty.
Before You • Unit must be installed in an easily accessible area. Any
Call For Service ...............19 additional cost required to hire a special equipment to
service the unit will be the responsibility of the customer.
Plug in the power plug Do not operate or stop the Do not damage or use an
properly. unit by inserting or pulling unspecified power cord.
out the power plug.
• Otherwise, it will cause • It will cause electrical shock • It will cause electrical shock or fire.
electrical shock or fire due to or fire due to heat • If the supply cord is damaged, it
heat generation. generation. must be replaced by the
manufacturer or its service agent
or a similarly qualified person in
order to avoid a hazard.
Do not modify power cord Do not operate with wet Do not insert anything into the
length or share the outlet hand. air inlet/air outlet.
with other appliances.
• It will cause electrical shock • It may cause electrical • Since the fan rotates at high
or fire due to heat shock. speed, this may cause an
generation. injury or damage the unit.
Do not expose the skin When an abnormality (smell of burning, etc) Repair or relocation should
directly to cool air for long occurs, stop the air conditioner, and disconnect not be done by the
periods of time. the power plug or turn off the breaker. customer.
• This could damage your • If the unit continues to be operated • If this is done incorrectly, it may
health. in an abnormal condition, it may cause a fire, electric shock, injury
cause a fire, damage, etc. In this by dropping of the unit, water
case, consult your dealer. leakage, etc. Consult your dealer.
1.A30052P(¿ ) 1994.11.24 6:10 PM ˘ ` 3
CAUTION
ENGLISH
• Contact the authorized Service technician for repair or maintenance of this unit.
• Contact the installer for installation of this unit.
• The air conditioner is not intended for use by young children or infirm persons
without supervision.
• Young children should be supervised to ensure that they do not play with the air
conditioner.
CAUTION
CAUTION
When the air filter is to be Do not clean the air Ventilate well when used
removed, do not touch the conditioner with water. together with a stove, etc.
metal parts of the indoor unit.
• It may cause an injury. • Water may enter the unit and • An oxygen shortage may
• Should be disconnected from degrade the insulation. It may occur.
supply cause an electric shock.
When the unit is to be Do not put a pet or house Do not leave on installation
cleaned, switch off, and turn plant where it will be stand which is damaged.
off the circuit breaker. exposed to direct air flow.
• Since the fan rotates at high • This could injure the pet or • The unit may drop or fall
speed during operation, it plant. down and cause an injury.
may cause an injury.
Do not apply an insecticide Do not put a stove, etc. Do not step on the
or flammable spray. where is exposed to direct indoor/outdoor unit and do
air flow. not put anything on it.
Do not insert hands through When the unit is not going to Do not step onto an unstable
vanes when the air conditioner be used for a long time, turn bench when cleaning and/or
is operationg off the circuit breaker. maintaining the unit.
• It will cause an injury by the • If not, dirt may collect and • It may cause an injury, etc.
rotating blower. cause a fire. by falling down.
3
1.A30052P(¿ ) 1994.11.24 6:10 PM ˘ ` 4
Insert new batteries making sure that the (+) and (-) of
battery are installed correctly.
NOTES:
Operating Instructions
Signal Receptor
Receives the signals from the remote control.(Signal receiving sound: two short beeps or one long beep.)
Operation Indication Lamps
Troubleshooting Tips
4
1.A30052P(¿ ) 1994.11.24 6:10 PM ˘ ` 5
ENGLISH
Features of the Remote Control- Door Closed
START/STOP BUTTON
1 Operation starts when this button is
pressed and stops when the button is
pressed again.
OPERATION MODE
2 SELECTION BUTTON
Used to select the operation mode.
3 ROOM TEMPERATURE
SETTING BUTTONS
5 6 Used to select the room temperature.
4 1
INDOOR FAN SPEED
4 SELECTOR
3 Used to select fan speed in four steps
low, medium, high, or CHAOS.
Flip-up door
(closed) 5 JET COOL
Used to start or stop the speed
2 cooling. (Speed cooling operates
super high fan speed in cooling mode.)
Operation Mode
Auto Operation
Auto Operation
Healthy Dehumidification Operation
5
1.A30052P(¿ ) 1994.11.24 6:10 PM ˘ ` 6
PLASMA
ROOM TEMPERATURE
6 CHECKING BUTTON
Used to check the room temperature.
7 PLASMA(OPTION)
Used to start or stop the plasma-purification
function. (See page 12)
RESET BUTTON
8 Used prior to resetting time or after replacing
batteries.
1.A30052P(¿ ) 1994.11.24 6:10 PM ˘ ` 7
Cooling Operation
ENGLISH
Press the Start/Stop button.
1 The unit will respond with
a beep.
7
1.A30052P(¿ ) 1994.11.24 6:10 PM ˘ ` 8
Safety Precautions
Auto Operation
8
1.A30052P(¿ ) 1994.11.24 6:10 PM ˘ ` 9
ENGLISH
Press the Start/Stop button.
1 The unit will respond with
a beep.
9
1.A30052P(¿ ) 1994.11.24 6:10 PM ˘ ` 10
Safety Precautions
10
1.A30052P(¿ ) 1994.11.24 6:10 PM ˘ ` 11
ENGLISH
Press the Start/Stop button.
1 The unit will respond with
a beep.
To cancel the Jet Cool mode, press the Jet Cool button
3 again or the fan speed button or the room temperature
setting button and the unit will operate in high fan speed on
cooling mode.
or or
NOTE:
❏ During the JET COOL function at any moment, the A/C starts to blow the cool air at
extremely high speed for 30 minutes setting the room temp. automatically to 18°C. It is
especially used to cool the room temp. in the shortest time in a hot summer.
In heat pump mode or neuro fuzzy mode however, the JET COOL function is not available.
❏ In order to return to the normal cooling mode from the JET COOL mode, you just press
either the operation mode selection button, airflow volume selection or temp. setting button
or the JET COOL button again.
11
1.A30052P(¿ ) 1994.11.24 6:10 PM ˘ ` 12
Safety Precautions
Set the fan speed again with door of the remote control
3
Care and Maintenance
12
1.A30052P(¿ ) 1994.11.24 6:10 PM ˘ ` 13
Additional features
Sleep Mode
ENGLISH
Press the Sleep Mode Auto button to set the To cancel the Sleep Mode, press the sleep
1 time you want the unit to turn off automatically. Mode Auto button several times until the star
( ) disappears from the operation display.
The Timer is programmed in one-hour
2 increments by pressing the Sleep Mode Auto Note: The Sleep Mode will be operated at
button 1 to 7 times. low fan speed (cooling) or medium fan
The sleep mode is available for 1 to 7 times. To speed (heat pump only) for quiet sleeping.
alter the time period in steps of 1 hour, press
the Sleep Mode Button while aiming at air IN COOLING MODE: The temperature will
conditioner. automatically rise by 1°C over the next 30
minutes and by 2°C in 1 hour for comfortable
3 Make sure the Sleep Mode Auto LED lights up. sleeping.
Delay OFF Timer Delay ON Timer Delay OFFand ON Timer Delay ONand OFF Timer
13
1.A30052P(¿ ) 1994.11.24 6:10 PM ˘ ` 14
1 Press the Start/Stop button. the unit will respond with a beep.
Open the door on the remote control. Press the Air Circulation button. Close the door on the
2 remote control. Now each time that you press the Indoor Fan Speed Selector, the fan speed is
shifted from low to CHAOS and back to low again.
Note:
❏ CHAOS Air economizes power consumption and prevents overcooling. The fan speed is
automatically changed from high to low or vice versa, depending on the ambient temperature.
1.A30052P(¿ ) 1994.11.24 6:10 PM ˘ ` 15
ENGLISH
FORCED OPERATION
Operation procedures when the remote control can't be
used.
Open the front panel upward and move the Slide
Switch to the Forced Operation position.
If you want to stop operation, move the Slide Switch to
the Auto Restart or the Remote Control position.
In case the power comes on again after power failure
on the Forced Operation position, the operating
conditions are automatically set as follows:
During Forced Operation, the initial mode continues.
Auto restart
In case the power comes on again after a power
failure, Auto Restarting Operation is the function to
operate procedures automatically to the previous
operating conditions.
In case the air conditioner does not receive any
signal from the remote control, it will turn off
automatically after 7 hours.
If you want to use this operation, Open the front
panel upward and move the slide switch to the
Auto Restart position.
If you do not want to use this operation, move the When you are out for a while, put the
Slide Switch to the Remote Control position. Slide Switch on the Remote Control.
Helpful information
Fan speed and cooling capacity.
The cooling capacity indicated in the specification is the
value when the fan speed is set to high, and the capacity will
be lower at low or medium fan speed.
High fan speed is recommended when you wish to cool the gh
room quickly. Hi eed
Sp
1.A30052P(¿ ) 1994.11.24 6:10 PM ˘ ` 16
CAUTION: Before performing any maintenance, turn off the main power to the system.
Indoor Unit
Grille, Case, and Remote Control ❏ Never use any of the followings:
❏ Turn the system off before cleaning. To • Water hotter than 40°C
clean, wipe with a soft, dry cloth. Do not Could cause deformation and/or
discoloration.
use bleach or abrasives.
• Volatile substances
NOTE: Could damage the surfaces of the air
Supply power must be disconnected before conditioner.
Operating Instructions
Pow
d er
G a s o li n e
may be deformed.
3 After washing with water, dry well in the
shade.
4 Re-install the air filter.
PLASMA FILTER, DEODORIZER
FILTER(OPTION) 1 After removing the air filters, pull slightly
The PLASMA filter behind the air filters should be forward to remove the PLASMA filter.
checked and cleaned once every 3 months or more
often if necessary. 2 Dip the PLASMA filter into the water mixed
with neutral detergent, for 20~30 minutes.
16
1.A30052P(¿ ) 1994.11.24 6:11 PM ˘ ` 17
ENGLISH
1 Open front panel and remove air 2 Remove air purifying filters.
filters.
3 Insert new air purifying filters.
Air filter 3
Outdoor Unit
The heat exchanger coils and panel vents of the (Rear)
outdoor unit should be checked regularly. If clogged (Side)
with dirt or soot, the heat exchanger and panel Air intake Piping
vents
vents may be professionally steam cleaned.
Drain Hose
NOTE: Air outlet
Dirty or clogged coils will reduce the vents
operating efficiency of the system and cause
higher operating costs.
(Rear)
(Rear)
(Side) (Side)
Air intake vents Piping Air intake
vents Piping
Drain Hose
Drain Hose
Air outlet vents Air outlet
vents
17
1.A30052P(¿ ) 1994.11.24 6:11 PM ˘ ` 18
Safety Precautions
When the air conditioner is not going to be used for a long time.
Operate the air conditioner on Air circulation Clean the air filter and install it in the indoor
mode (Refer to page 14) for 2 to 3 hours. unit.
(Refer to page 16 for cleaning filters.)
• This will dry out the internal mechanisms.
Operating Instructions
Operation Tips
Do not overcool the room. Keep blinds or curtains Keep the room temperature
closed. uniform.
This is not good for the health Do not let direct sunshine enter Adjust the vertical and
and wastes electricity. the room when the air horizontal airflow direction to
conditioner is in operation. ensure a uniform temperature
in the room.
Troubleshooting Tips
Make sure that the doors Clean the air filter regularly. Ventilate the room
and windows are shut tight. occasionally.
Avoid opening doors and Blockages in the air filter Since windows are kept closed,
windows as much as possible reduce the airflow and lower it is a good idea to open them
to keep the cool air in the room. cooling and dehumidifying and ventilate the room now and
effects. Clean at least once then.
every two weeks.
18
1.A30052P(¿ ) 1994.11.24 6:11 PM ˘ ` 19
ENGLISH
Check the following points before requesting repairs or service.... If the fault persists, please
contact your dealer or service center.
The room has a peculiar • Check that this is not a damp smell exuded by
odor. the walls, carpet, furniture, or cloth items in the -
room.
Does not cool or heat • Is the air filter dirty? See air filter cleaning 16
effectively. instructions.
• Has the temperature been set incorrectly? 7, 10
• Are the indoor unit's air inlet or outlet vents
obstructed? -
The air conditioner • For a noise that sounds like water flowing.
operation is noisy. -This is the sound of freon flowing inside the
air conditioner unit.
• For a noise that sounds like the compressed
air releasing into atmosphere. -
-This is the sound of the dehumidifying water
being processed inside the air conditioning
unit.
NOTE
WATER RESISTANT: The outdoor side of this appliance is WATER RESISTANT.
The indoor side is not water resistant and should not be exposed to excess water.
19