Documente Academic
Documente Profesional
Documente Cultură
Conplast WP400 will drastically reduce water absorption in An overdose of double the intended dose of Conplast WP400
structural and precast concrete. It is suitable for use in below may result in increased retardation and workability, hence
ground structures, reinforced concrete in marine areas, piles, reduce the short term strength development. Long term
water retaining structures, manholes, waste water treatment strength is unlikely to be affected.
and desalination plants.
Use at other dosages
Advantages Dosages other than those given on this sheet may be used
to meet particular mix requirements provided that adequate
Bitumen ammonia free system
supervision is available. Compliance with requirements must
Provides integral protection, ensuring reduced be assessed through trial mixes. Contact the Fosroc
permeability throughout the concrete Technical Department for advice in these cases.
Compatibility
Description
Conplast WP400 is compatible with Conplast SP432MS*†
Conplast WP400 chloride free admixture is supplied as a
when used in the same concrete mix, but should be added to
turbid liquid which instantly disperses in water.
the mix separately and must not be mixed together prior to
Conplast WP400 is an organic liquid which reacts with addition. The resultant properties of mixes containing more
products of the cement hydration process to produce a than one admixture should be assessed by the trial mix
hydrophobic material which repels external water, reducing procedure recommended on this data sheet.
absorption into the concrete.
Conplast WP400 is suitable for use with all types of Portland
cements, SRC cements and cement replacement materials
Technical support
such as PFA, GGBFS and microsilica.
Fosroc provides a technical advisory service for on-site
Dispensing
assistance and advice on admixture selection, evaluation
trials and dispensing equipment. Technical data and The correct quantity of Conplast WP400 should be measured
guidance can be provided for admixtures and other products by means of a recommended dispenser. The admixture
for use with fresh and hardened concrete. should then be added to the concrete with the mixing water to
obtain the best results. Contact the Fosroc Technical
Dosage Department for advice regarding suitable equipment and its
installation.
The optimum dosage of Conplast WP400 to meet specific
requirements should always be determined by trials using Curing
the materials and conditions that will be experienced in use.
As with all structural concrete, good curing practice should
This allows the optimisation of admixture dosage and mix
be maintained, particularly in situations where an overdose
design and provides a complete assessment of the mix.
has occurred. Water spray, wet hessian or a Concure*† spray
The normal recommended dosage is 1.5 to 2.0 litres per
applied curing membrane should be used.
100 kg of cement.
Conplast® WP400
Conplast® WP400
The use of Conplast WP400 will not make poor quality concrete Cleaning and disposal
waterproof. Good concrete practice must be followed at all
Spillages of Conplast WP400 should be absorbed onto
times. Well graded aggregates must be used and a minimum
sand, earth or vermiculite and transferred to suitable
cement content of 300 kg/m3 is recommended. Consult the
containers. Hose down remnants with large quantities of
fact sheet available on the use of Conplast plasticisers in
water.
water retaining structures for further information. Adequate
water bars must be provided between lifts of concrete and The disposal of excess or waste material should be carried
floor bays. out in accordance with local legislation under the guidance
of the local waste regulatory authority.
Conplast® WP400
Conplast® WP400
Ahmedabad : (079) 26762799 Ankleshwar :(02646) 220704/224687 Bhubaneshwar : (0674) 2546415 Chennai (044) 24899949/24853383
Chandigarh : (0172) 2639360 Cochin : (0484) 2356668 Coimbatore : (0422) 2472966 Goa : (0832) 2542465 Guwahati (0361) 2548793
Hyderabad : (040) 27662324/27662425 Hubli (0836) 09343402597 Indore : (0731) 504339/5061477 Jaipur : (0141) 2235349
Jamshedpur: (0657) 2223848 Lucknow :(0522) 2239044 Nagercoil 09842134873 Visakhapatnam : (0891) 2564850 / 2707607
INDIA/2005/01-111/A