Documente Academic
Documente Profesional
Documente Cultură
CAR revisions
WARNING
This document must be used for training purposes only Under no circumstances should this document be used as a reference It will not be updated.
Notice
No responsibility is assumed by the publisher for any injury and/or damage to persons or property as a matter of products liability, negligence or otherwise, or from any use or operation of any methods, products, instructions or ideas contained in the material herein.
Section 2 - Airworthiness CAR Series Part Issue No. and Date Subject Most Recent Amendment No. Date of Amendm ent
Series A PROCEDURE FOR ISSUE OF CIVIL AIRWORTHINESS REQUIREMENTS AND RESPONSIBILITY OF OPERATOR VIS-A-VIS AIRWORTHINESS DIRECTORATE Part I Issue II Responsibilities of Operators/ Owners 01.07.1977 Cancelled in view of CAR Section 2, CAR M Part II Issue III Procedure for CAR issue, amendments etc. 18.03.1993 Cancelled in view of CAR Section 1, Series 'A' Part III Part III Part IV Issue I Objectives and Targets of Airworthiness Dte. 12.03.1980 Issue I Airworthiness Regulation and Safety Oversight 28.08.1996 of Engineering Activities of Operators No Amdts
No Amdts No Amdts
Series B APPROVAL OF COCKPIT CHECK LIST, MEL, CDL Part I Issue IV Minimum Equipment List (MEL) 21.08.1990
Part II
Issue II Preparation and use of Cockpit and emergency Rev 1 to Pg 1 23.05.1978 check list and 2
03.06.200 5
Series C DEFECT RECORDING, MONITORING, INVESTIGATION AND REPORTING Part I Issue II Defect recording, reporting, investigation, 12.03.1980 rectification and analysis
Series D AIRCRAFT MAINTENANCE PROGRAMMES Part I Part II Issue I Reliability Programme (Engines) 26.09.1966 Issue IV 01.01.1985 No Amdts Rev. 1 to Pg 1 15.10.200 and 7 1 Rev. 2 to Pg 1 18.08.200 and 2 5 No Amdts Rev. 1 to Pg 1 15.10.200 1 Rev 1 to all pages Rev. 1 to Pg 1and 2 03.07.200 9 15.10.200 1
Issue II, On-condition maintenance of reciprocating 28.02.1978 engines (Piston engines) Issue I Time between overhaul - Revision programme 01.02.1968 Issue I Maintenance of fuel and oil consumption 27.01.1970 records - Light aircraft piston engines Issue I Fixing routine maintenance periods and 27.04.1992 component TBOs-Initials and Revisions CANCELLED
Part VI
Part VII
CAR 145 Revision 0, Approval of Maintenance Organisations 26.01.2005 CAR M Effective 31.07.201 0 Rev. 0, Continuing Airworthiness Requirements 02.03.2010
Revision 1, 28.02.2008
Series E APPROVAL OF ORGANISATIONS Part I Issue III Approval of organisation/ operators 24.04.1992
Rev 9 to Pg 1 and 2
09.03.200 7
No Amdts
Part IV Issue II Rev. 1 to Pg 1 24.01.200 Deleted 01.08.1975 2 Approval of organisation - Cat. C - Maintenance wef 8.10.2010 Part V Deleted wef 1.1.2011 Part VI Issue II 01.08.1975 Approval of organisation - Cat. D - Testing Laboratory Issue II Approval of organisation - Cat. E 01.08.1975 Fuel,Lubricant and spl. petroleum product Issue II Approval of firms - Cat. F - Stores and 01.08.1975 Distribution Cancelled in view of amendment to Rule 133B Part VIII Issue III 07.11.1997 Approval of organisation - Cat. G - Training schools/Establishments Rev.2 to Pg 1 and Pg 35 30.12.200 9 No Amdts
No Amdts
Part VII
No Amdts
Part IX
Issue I Requirements for infrastructure at stations other No Amdts 14.07.1995 than parent base
Series F AIRWORTHINESS AND CONTINUED AIRWORTHINESS Part I Issue II Procedure relating to registration of aircraft 10.09.1998
Part II Issue I Procedure for issue/revalidation of Type Cancelle 24.04.1992 Certificate of aircraft and its engines/propeller d (See CAR 21 - Certification Procedures for Aircraft and related products)
Rev 1 to Pg 1 and 8
24.01.200 2
Rev 2 to Pg 1 18.10.2000
Part V
Issue I Suspension of Certificate of Airworthiness and 20.03.1992 its subsequent revalidation Issue I Rebuilding of aircraft 20.03.1992 Issue II Special Flight permits 10.08.1999
Amdt 1 to Pg 1 16.08.199 9 No Amdts Rev 1 to Pg 1, 24.01.200 3&4 2 Rev. 2 to all pages 04.09.200 6
Part VIII
Issue III Maintenance and Certification of Aircraft 05.03.1998 Public Notice - Deletion of CAR Section 2 Series 'F' Part VIII - with effect from 1.7.2011
Rev. 7 to all pages 08.01.2007 Amdt 1 to Pg 4 26.03.199 3 Rev 2 to Pg 1 and 4 Rev. 1 to all pages Rev 2 to all pages 27.09.199 9 04.03.200 2 03.07.200 9
Part IX Issue I Cancelled Cancelled 20.03.1992 See CAR M - Continuing Airworthiness wef Requirements 12.10.201 0 Part X Issue I Airworthiness of ageing aircraft 20.03.1992
Part XI Issue I Cancelled Cancelled 20.03.1992 See CAR M - Continuing Airworthiness wef Requirements 12.10.201 0 Part XII Part XIII Issue I Inspection of wooden aircraft 20.03.1992 Issue I Airworthiness requirements for Gliders 20.03.1992
Part XV
Issue II Requirements for manufacture, registration and Rev.1 to Pg 1 01.09.1993 airworthiness control of hot air balloons and 4 Issue I Approval of flight manuals and their 20.03.1992 amendments Rev 1 to Pg 1 and 3 Rev 1 to Pg 1 and 2 No Amdts
Part XVI
Part XVII Issue I Pooling of aircraft parts by National Airlines of 20.03.1992 India with Foreign airlines Part XVIII Issue I Construction, Certification and operation of 23.10.1992 experimental/amateur built aircraft Part XIX Issue I Manufacture of aircraft and accessories and Valid upto 02.11.1992 airworthiness certification thereof 31.12.200 (See CAR 21 - Certification Procedures for 8 Aircraft and related products) Part XX Issue II Age of aircraft to be imported for charter hire/air 29.07.1993 taxi and other operations
Part XXI
Issue II Import/Export of aircraft, spares, item of 07.11.1997 equipment etc. for use on aircraft
Part XXII Issue I Load and trim sheet - requirements thereof 06.08.1993
Series H REQUIREMENTS OF AIRCRAFT FUEL, REFUELLING OF AIRCRAFT AND CALIBRATION OF AIRCRAFT FUELS Part I Part II Part III Series I Part I Issue I Unusable fuel supply-calibration of fuel quantity Rev 1 to Pg 1 04.12.1969 gauge of aircraft and 2 Issue I Aircraft fuelling procedures 28.04.1992 Issue I Aviation fuel at airport - Storage, handling and 27.08.1992 quality control Rev 1 to Pg 1 and 6 No Amdts 15.10.200 1 15.10.200 1
AIRCRAFT INSTRUMENT, EQUIPMENT AND ACCESSORIES Issue II Aircrafts instruments overhaul and periodical 15.03.1976 inspections Amdt 1 to Pg 2 14.09.199 & Pg 3 5 Rev 2 to Pg 1, 05.06.200 2 and 2A 9
Part II
Part V
Part VI
Issue I Cockpit voice recorders 12.12.1996 Issue II Ground Proximity Warning Systems (GPWS) 28.05.1999 Issue I Installation of Airborne Collision Avoidance 24.04.1997 System
Part VII
Part VIII
Series L AIRCRAFT MAINTENANCE ENGINEER - LICENSING Part I Issue I Issue of AME licences, its classification and 20.01.1992 experience requirements Issue I Procedure of Examination for issue/extension 20.01.1992 of Basic licence and Aircraft Maintenance Engineer's licence. Rev 2 to Pg 1 and 9 13.12.2007 Rev 4 to Pg 1 and 3 30.06.2009
Part II
Part III
Issue I Classification and certification responsibilities of No Amdts 20.01.1992 AME's Licence for Helicopters Issue II Endorsement of AME Licences 20.07.1999 Issue I Certification privileges of AMEs 20.01.1992 No Amdts
Part IV Part V
Issue II Grant of open AME Licences 28.01.1994 Issue I Procedure for renewal of AME's Licence 20.01.1992
Part X
Issue I Grant of approval to persons engaged in 20.01.1992 overhaul, major repairs components and Effective accessories of aircraft engines and their 1st March systems 2008 Part XI Issue III Approval of Flight Engineer Examiners and 24.02.1995 Check Flight Engineers
Issue I Approval of Graduate Engineers' Training 20.01.1992 Scheme Issue I Payment/Non-payment of fees for issue of 20.01.1992 duplicate AME/FE/SFE Licences Issue I 20.1.1992 Issue I 10.8.1999 Issue of Certificate of Competency
Part XV
Part XVI
Series M MANDATORY MODIFICATIONS AND INSPECTIONS Part I Issue III Mandatory Modifications/ Inspections 23.07.1999 Rev. 2 to all pages 24.07.2008
Series O OPERATIONAL REQUIREMENT FOR AIRCRAFT Part I Part II Issue IV Minimum requirements to be complied with by 24.04.1992 operators Issue IV Operation of Commercial Air Transport 15.07.1999 Aeroplanes Issue II Operation of General Aviation - Aeroplanes 15.07.1999 See CAR Section 8 Series 'O' Part III Cancelled Operation of General Aviation Aeroplanes No Amdts Rev 12 to all pages 21.07.2010 Rev. 3 to Pg 1, 21, 21A and 21B 01.05.2006
Part III
Part V
Issue II Operation of General Aviation Helicopters 27.07.1999 See CAR Section 8 Series 'O' Part V Cancelled Operation Of General Aviation Helicopters Issue II Registration, airworthiness and operation of 14.07.1993 hang gliders and powered hang gliders Issue I Exit row seating 22.11.1993
Part VI
Issue I Airworthiness, Maintenance and Operational Rev. 1 to Pg 1 06.09.200 11.08.1999 requirements for Extended Range Operations 4 with Twin Engine Aeroplanes for Commercial Air Transport Operations. 29.10.1999 Requirements for operation of aircraft in MNPS No Amdts airspace Issue II Requirements for preparation of operations 18.08.1999 manual. 29.10.1999 Requirements for implementation of Reduced Vertical Separation Minimum (RVSM) Rev 4 to Pg 1, 3 and 7 16.06.2007 Rev. 1 to all pages 24.11.200 3
Part IX Part X
Part XI
Part XII
Issue I, Performance Based Navigation (PBN) - Aircraft Issue II 28.10.1999 Airworthiness, Operational and Flight Crew Training Requirements for Required Navigation Performance (RNP)/ Area Navigation (RNAV) 18.01.2001 Requirements for Evaluation, Certification and Maintenance of Aircraft Flight Simulators and Synthetic Flight Training Devices. 19.03.2001 Airworthiness and Maintenance Requirements for Cat II and Cat IIIA operations. Rev 1 to all pages
22.08.200 8
Part XIII
29.06.200 7
Part XIV
No Amdts
Series R AIRBORNE COMMUNICATION, NAVIGATION AND RADAR Part I Part II Issue I Aircraft radio equipment 18.05.1983 Issue II Installation of Communication, Navigation and 27.04.1992 Radar equipment Rev 1 to Pg 1 No Amdts 28.04.200 0
Series S STORAGE OF AIRCRAFT PARTS Part I Issue III No Amdts Storage conditions and storage/service life of 16.10.1982 rubber parts and aircraft components containing rubber parts Issue I Fixation of Calendar period for determining 02.05.1974 overhaul life of reciprocating engines Rev 1 to Page 10.04.200 1& 2 1
Part II
Series T FLIGHT TESTING OF AIRCRAFT Part I Part II Issue I Flight testing of (Series) aircraft for the issue of 10.05.1967 C of A Issue III Flight testing of aircraft for which a C of A had 01.04.1976 been previously issued Rev 3 to Page 1 & 2 04.03.2002
Series X MISCELLANEOUS REQUIREMENTS Part I Issue I Registration markings of aircraft Cancelle 18.02.1976 shifted to Car sec 2 series F part 1 d Part II 14.05.1993 Weight and balance control of an aircraft No Amdts
Part III
Issue III Provision of Medical Supplies in Aircraft 12.06.1997 Revision 5 Effective from 1st March 2011 Issue III 25.2.1986 Use of furnishing materials in aircraft
Part V Part VI
Part Issue I Procedure for issue of type approval of aircraft IXCancel 23.01.1985 components and equipment including led instruments (See CAR 21 - Certification Procedures for Aircraft and related products)