Documente Academic
Documente Profesional
Documente Cultură
SS-MS215
SERVICE MANUAL
AEP Model
UK Model
E Model
Australian Model
Chinese Model
Photo: SA-WMS215
Photo: SS-MS215
SPECIFICATIONS
SS-MS215 Front, center and rear speakers
SA-WMS215 Subwoofer
Speaker system
System
Speaker system
Active subwoofer,
magnetically shielded
Speaker units
5 cm cone type
Speaker unit
Enclosure type
Bass reflex
Enclosure type
Rated impedance
8 ohms
50 W
Power handling
capacity
(Maximum input
power)
60 watts
Continuous RMS
power output
(8 ohms, 20 - 250 Hz)
Reproduction
frequency range
32 Hz - 250 Hz
Sensitivity level
84 dB (1W, 1m)
High frequency
cut-off frequency
250 Hz
Frequency range
150 Hz - 20,000 Hz
Dimensions (w/h/d)
Approx. 76 100 86 mm
including front grille
Mass
Approx. 425 g
Input
LINE IN (input pin jack)
General
Power requirements
Power consumptions
45 W
Dimensions (w/h/d)
Mass
Approx. 8 kg
SPEAKER SYSTEM
SECTION 1
DIAGRAMS
IC Block Diagram
Q
B C
E
These are omitted.
IC302
F/F
OFFSET DET
Note :
The components identified by
mark 0 or dotted line with mark
0 are critical for safety.
Replace only with part number
specified.
LATCH/
AUTORESET
AC OFF
DET
U : B+ Line.
V : B Line.
Voltages are dc with respect to ground under no-signal
conditions.
Voltages are taken with a VOM (input impedance 10 M).
Voltage variations may be noted due to normal production tolerances.
Signal path.
F : AUDIO
VCC
1
uPC1237HA
POWER IC board
CONTROL board
SA-VE215/WMS215/SS-MS215
1-2. SCHEMATIC DIAGRAM (SA-WMS215) See page 3 for IC block diagram.
SA-VE215/WMS215/SS-MS215
1-3. PRINTED WIRING BOARD (SA-WMS215) See page 3 for Circuit Boards Location.
Location
Ref. No.
Location
D301
D302
D303
D304
D401
D402
D403
B-3
B-2
C-6
C-4
B-6
B-4
B-4
IC101
IC102
IC103
IC302
B-1
C-1
D-2
C-4
Q101
Q102
Q303
C-2
B-2
D-4
SECTION 2
EXPLODED VIEWS
NOTE:
-XX, -X mean standardized parts, so they may
have some differences from the original one.
Items marked * are not stocked since they
are seldom required for routine service. Some
delay should be anticipated when ordering these
items.
The mechanical parts with no reference number
in the exploded views are not supplied.
56
not supplied
#5
#3
not
supplied
#5
53
T401
#4
not
supplied
58
supplied
with RV201
not supplied
#5
#2
#2
5
Amplifier
section
not
supplied
#2
55
51
#3
#2
54
#4
#4
6
SP1
#4
#1
#1
#4
11
52
not supplied
10
12
12
12
#5
12
11
12
11
11
Ref. No.
Part No.
Description
1
2
3
4
5
A-4412-320-A
4-229-516-01
4-220-465-01
4-229-517-01
1-678-476-11
PANELASSY, FRONT
KNOB (VOL)
WASHER, INSULATING
KNOB (SW)
POWER SWITCH BOARD
6
7
8
Remarks
Ref. No.
Part No.
Description
9
10
11
12
SP1
A-4412-321-A
4-229-514-01
4-229-522-11
4-229-966-01
1-529-764-11
CABINET ASSY
PANEL, BOTTOM
FOOT
SCREW (4X16), +BV TAPPING
SPEAKER (16cm)
#1
#2
#5
Remarks
Ref. No.
51
52
53
54
54
* 55
Part No.
Description
1-678-477-11
A-4473-638-A
1-678-474-11
4-228-899-11
4-228-899-21
POWER IC BOARD
MAIN BOARD, COMPLETE
POWER SUPPLY BOARD
REAR PANEL (AEP,EE,CIS,CH,AUS,UK)
REAR PANEL (HK,MY,SP)
Remarks
Ref. No.
Part No.
Description
0 56
58
0 T401
#3
#4
1-777-071-11
3-710-901-11
1-435-608-11
7-685-647-79
7-685-648-79
CORD, POWER
SCREW, TAPPING
TRANSFORMER, POWER
SCREW +P3X10 TYPE2 NON-SLIT
SCREW +P3X12 TYPE2 NON-SLIT
#5
Remarks
2-3. SS-MS215
102
103
not supplied
#7
101
SP2
#6
#6
#6
Ref. No.
101
102
103
SP2
Part No.
Description
A-4412-322-A
A-4412-277-A
1-694-516-11
1-529-763-11
Remarks
Ref. No.
#6
#7
Part No.
Description
Remarks
CONTROL
LED
SECTION 3
MAIN ELECTRICAL PARTS LIST
NOTE:
Due to standardization, replacements in the
parts list may be different from the parts
specified in the diagrams or the components
used on the set.
-XX, -X mean standardized parts, so they
may have some difference from the original
one.
Items marked * are not stocked since they
are seldom required for routine service.
Some delay should be anticipated when
ordering these items.
CAPACITORS:
uF: F
Ref. No.
Part No.
RESISTORS
All resistors are in ohms.
METAL: metal-film resistor
METAL OXIDE: Metal Oxide-film resistor
F: nonflammable
COILS
uH: H
SEMICONDUCTORS
In each case, u: , for example:
uA...: A... , uPA... , PA... ,
uPB... , PB... , uPC... , PC... ,
uPD..., PD...
Description
Remarks
1-126-964-11 ELECT
10uF
Part No.
Description
Remarks
C306
C307
C308
C309
C310
1-162-215-31
1-126-967-11
1-126-967-11
1-104-665-11
1-126-963-11
CERAMIC
ELECT
ELECT
ELECT
ELECT
47PF
47uF
47uF
100uF
4.7uF
5%
20.00%
20.00%
20.00%
20.00%
50V
50V
50V
10V
50V
C311
C401
C402
C403
C404
1-104-664-11
1-136-165-00
1-136-165-00
1-119-940-51
1-119-940-51
ELECT
MYLAR
MYLAR
ELECT
ELECT
47uF
0.1uF
0.1uF
4700uF
4700uF
20.00%
5.00%
5.00%
20.00%
20.00%
25V
50V
50V
50V
50V
C405
C406
1-104-665-11 ELECT
1-104-665-11 ELECT
100uF
100uF
20.00% 25V
20.00% 25V
20.00% 50V
Ref. No.
* CN104
* CN105
CN106
CN109
1-564-104-00
1-568-951-11
1-691-765-11
1-564-320-00
D801
8-719-080-25 DIODE SEL6414LF62 (POWER)
**************************************************************
A-4473-638-A MAIN BOARD, COMPLETE
*********************
D301
D302
D303
D304
D401
8-719-911-19
8-719-911-19
8-719-911-19
8-719-911-19
8-719-025-03
DIODE
DIODE
DIODE
DIODE
DIODE
1SS133T-72
1SS133T-72
1SS133T-72
1SS133T-72
RBA-402
D402
D403
1-162-286-31
1-126-964-11
1-162-286-31
1-136-167-00
1-136-159-00
CERAMIC
ELECT
CERAMIC
MYLAR
MYLAR
220PF
10uF
220PF
0.15uF
0.033uF
10%
20.00%
10%
5.00%
5.00%
50V
50V
50V
50V
50V
C106
C107
C108
C109
C110
1-136-169-00
1-136-169-00
1-136-169-00
1-136-169-00
1-136-164-00
MYLAR
MYLAR
MYLAR
MYLAR
MYLAR
0.22uF
0.22uF
0.22uF
0.22uF
0.082uF
5.00%
5.00%
5.00%
5.00%
5.00%
50V
50V
50V
50V
50V
C111
C112
C301
C302
C305
1-136-168-00
1-126-964-11
1-136-165-00
1-126-933-11
1-136-169-00
MYLAR
ELECT
MYLAR
ELECT
MYLAR
0.18uF
10uF
0.1uF
100uF
0.22uF
5.00%
20.00%
5.00%
20.00%
5.00%
50V
50V
50V
16V
50V
IC101
IC102
IC103
IC302
8-759-634-50
8-759-634-50
8-759-634-50
8-759-111-68
IC
IC
IC
IC
M5218AL
M5218AL
M5218AL
uPC1237HA
J101
Q101
Q102
Q303
8-729-119-78 TRANSISTOR
8-729-119-78 TRANSISTOR
8-729-900-80 TRANSISTOR
2SC2785TP-E
2SC2785TP-E
BA1A4M-TP
MAIN
Ref. No.
Part No.
POWER IC
Description
Remarks
POWER SUPPLY
Ref. No.
Part No.
POWER SWITCH
Description
Remarks
1-249-417-11
1-249-441-11
1-249-441-11
1-249-429-11
1-249-429-11
CARBON
CARBON
CARBON
CARBON
CARBON
1K
100K
100K
10K
10K
5%
5%
5%
5%
5%
1/4W F
1/4W
1/4W
1/4W
1/4W
R106
R107
R108
R109
R110
1-249-424-11
1-249-436-11
1-249-424-11
1-249-417-11
1-249-435-11
CARBON
CARBON
CARBON
CARBON
CARBON
3.9K
39K
3.9K
1K
33K
5%
5%
5%
5%
5%
1/4W F
1/4W
1/4W F
1/4W F
1/4W
R111
R112
R113
R114
R115
1-249-425-11
1-249-439-11
1-249-417-11
1-249-417-11
1-249-435-11
CARBON
CARBON
CARBON
CARBON
CARBON
4.7K
68K
1K
1K
33K
5%
5%
5%
5%
5%
1/4W F
1/4W
1/4W F
1/4W F
1/4W
R116
R117
R118
R119
R303
1-249-438-11
1-249-427-11
1-249-427-11
1-249-427-11
1-249-427-11
CARBON
CARBON
CARBON
CARBON
CARBON
56K
6.8K
6.8K
6.8K
6.8K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R304
R305
R307
R308
R309
1-249-433-11
1-249-412-11
1-249-478-81
1-249-433-11
1-249-433-11
CARBON
CARBON
CARBON
CARBON
CARBON
22K
390
2.2
22K
22K
5%
5%
5%
5%
5%
1/4W
1/4W F
1/2W
1/4W
1/4W
R310
R311
R312
R313
R314
1-249-441-11
1-249-441-11
1-249-427-11
1-249-429-11
1-215-892-11
CARBON
CARBON
CARBON
CARBON
METAL OXIDE
100K
100K
6.8K
10K
1K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W F
1/4W
2W
0 S1
1-554-920-61 SWITCH, PUSH (AC POWER)(1 KEY)(POWER)
**************************************************************
R315
R316
R318
R401
R402
1-249-439-11
1-249-430-11
1-215-868-00
1-216-456-00
1-216-456-00
CARBON
CARBON
METAL OXIDE
METAL OXIDE
METAL OXIDE
68K
12K
680
820
820
5%
5%
5%
5%
5%
1/4W
1/4W
1W
2W
2W
0 56
1-777-071-11 CORD, POWER
103
1-694-516-11 TERMINAL, SPEAKER
SP1
1-529-764-11 SPEAKER (16cm)
SP2
1-529-763-11 SPEAKER (5cm)
0 T401
1-435-608-11 TRANSFORMER, POWER
**************************************************************
1-113-924-11 CERAMIC
0 F401
1-532-500-31 FUSE TL 0.63A/250V
**************************************************************
1-678-476-11 POWER SWITCH BOARD
********************
F
F
F
F
1-113-915-11 CERAMIC
0.001uF
20.00% 250V
MISCELLANEOUS
**************
1-162-286-31 CERAMIC
220PF
10%
50V
IC301
8-759-299-53 IC LM3886T
< RESISTOR >
R306
1-249-435-11 CARBON
33K
5%
1/4W
**************************************************************
SA-VE215/WMS215/SS-MS215
9-929-500-11
Sony Corporation
Audio Entertainment Group
10
2000G1661-1
Printed in Japan 2000.7
Published by HA Quality Assurance Dept.