Documente Academic
Documente Profesional
Documente Cultură
-D
IA
LO
Features
Quiet operation
Compressors
- Low-noise scroll compressors with low vibration level
- The compressor assembly is installed on an independent
chassis and supported by anti-vibration mountings
- Dynamic suction and discharge piping support,
minimising vibration transmission (Carrier patent)
Condenser (30RB)/air evaporator/condenser (30RQ)
section
- Vertical condenser coils
- Protection grilles on anti-vibration mountings to protect
the heat exchanger against possible shocks.
- Low-noise latest-generation Flying Bird IV fans, made
of a composite material (Carrier patent) are now even
quieter and do not generate intrusive low-frequency
noise
- Rigid fan installation for reduced start-up noise (Carrier
patent)
Hydronic module
Environmental care
Economical operation
Superior reliability
State-of-the-art concept
- Cooperation with specialist laboratories and use of limit
simulation tools (finite element calculations) for the
design of the critical components, e.g. motor supports,
suction/discharge piping etc.
Auto-adaptive control
- Control algorithm prevents excessive compressor
cycling and permits reduction of the water quantity in
the hydronic circuit (Carrier patent)
- Hydronic module with integrated pressure transducers
allowing measurement of the water pressure at two
points, as well as measurement of the water flow rate
and detection of lack of water and pressure. This
considerably reduces the risk of problems such as frost
accumulation on the water heat exchanger.
- Automatic compressor unloading in case of abnormally
high condensing pressure. If an anomaly occurs (e.g.
fouled air heat exchanger coil, fan failure) Aquasnap
continues to operate, but at reduced capacity.
Exceptional endurance tests
- Corrosion resistance tests in salt mist in the laboratory
- Accelerated ageing test on components that are
submitted to continuous operation: compressor piping,
fan supports
- Transport simulation test in the laboratory on a
vibrating table.
Pro-Dialog+ control
Pro-Dialog+ interface
\\MAINMENU\STATUS
CAPB_T
DEM_LIM
SP
CTRL_PNT
EMSTOP
0
100
4.2
-28.9
dsable
unit
%
%
C
C
START/STOP
ENTER
PRO-DIALOG+
Energy management
- Seven-day internal time schedule clock: permits unit on/
off control and operation at a second set point
- Set point reset based on the outside air temperature or
the return water temperature or on the water heat
exchanger delta T
- Master/slave control of two units operating in parallel
with operating time equalisation and automatic changeover in case of a unit fault (accessory).
- Change-over based on the outside air temperature
Integrated features
- Night mode: capacity and fan speed limitation for
reduced noise level
- With hydronic module: water pressure display and water
flow rate calculation
Ease-of-use
- The new backlighted LCD interface includes a manual
control potentiometer to ensure legibility under any
lighting conditions.
- The information is displayed clearly in English, French,
German, Italian and Spanish (for other languages please
consult Carrier)
- The Pro-Dialog+ navigation uses intuitive tree-structure
menus, similar to the Internet navigators. They are userfriendly and permit quick access to the principal operating parameters: number of compressors operating,
suction/discharge pressure, compressor operating hours,
set point, air temperature, entering/leaving water
temperature
No.
2B
Advantages
Improved corrosion resistance, recommended for urban,
industrial and rural environments
Improved corrosion resistance, recommended for marine
environments
Noise emission reduction
25
Description
Coils with factory-applied Blygold Polual
treatment
Fins made of pre-treated aluminium
(polyurethane or epoxy)
Acoustic compressor enclosure and lowspeed fans (12 r/s or 720 rpm)
Electronic compressor starter
Soft starter
Winter operation
28
42
High-pressure single-pump
hydronic module
High-pressure dual-pump
hydronic module
Low-pressure single-pump
hydronic module
Low-pressure dual-pump
hydronic module
High-pressure variable-speed
single-pump hydronic module
High-pressure variable-speed
dual-pump hydronic module
JBus gateway
116B
BacNet gateway
148C
LonTalk gateway
148D
264
Remote interface
Board for additional heating
stages
3A
15LS
116C
116F
116G
116J
116K
148B
266
Use
30RBS 039-160
30RBS/RQS
039-160
30RBS/RQS
039-160
30RBS/RQS
039-080
30RBS 039-160
30RBS/RQS
039-160
See hydronic module chapter
30RBS/RQS
039-160
See hydronic module chapter
Easy and fast installation, operating safety
30RBS/RQS
039-160
See hydronic module chapter
Easy and fast installation
30RBS/RQS
039-160
See hydronic module chapter
Easy and fast installation, operating safety
30RBS/RQS
039-160
See hydronic module chapter
Easy and fast installation, power consumption reduction of 30RBS/RQS
the water circulation pump
039-160
See hydronic module chapter
Easy and fast installation, operating safety, power
30RBS/RQS
consumption reduction of the water circulation pump
039-160
Two-directional communications board,
Easy connection by communication bus to a building
30RBS/RQS
complies with JBus protocol
management system
039-160
Two-directional communications board,
Easy connection by communication bus to a building
30RBS/RQS
complies with BacNet protocol
management system
039-160
Two-directional communications board,
Easy connection by communication bus to a building
30RBS/RQS
complies with LonTalk protocol
management system
039-160
Inlet/outlet screw connection sleeves
Permit connection of the unit to a screw connection
30RBS/RQS
039-160
Welded inlet/outlet connection sleeves
Permit connection of the unit to a connection other than a 30RBS/RQS
Victaulic connection
039-160
Description
Advantages
Use
Unit equipped with an additional field-installed Operation of two units connected in parallel with operating 30RBS/RQS
leaving water temperature sensor, allowing
time equalisation
039-160
master/slave operation of two units connected
in parallel
Remotely installed user interface (via
Remote unit control up to 300 m
30RBS/RQS
communication bus).
039-160
Boiler or supplementary electric heat control Used as on/off control for boilers (Aquasmart system) or
30RQS 039-160
board
as four control stages for an electric heater. To be installed
separately, requires a 400 V-3 ph-50 Hz power supply.
* Winter operation option: This option allows operation of the unit down to -20C outside temperature due to the optimised control of the condensing temperature. One fan is equipped with a
frequency converter.
039
kW
39.3
kW
13.7
kW/kW 2.88
C
045
44.6
16.1
2.77
C
050
51.9
18.9
2.75
C
060
58.4
21.2
2.76
C
070
66.7
24.4
2.74
C
080
78.6
29.0
2.71
C
090
89.4
31.8
2.81
C
100
99.9
35.9
2.78
C
120
117.0
43.2
2.71
C
140
134.3
49.1
2.74
C
160
157.1
57.9
2.71
C
kW/kW
kW/kW
kW
kW
kW/kW
4.04
4.71
52.6
15
3.4
4.09
4.69
59.2
17
3.3
4.07
4.70
72.7
20
3.4
4.06
4.72
80.2
23
3.4
4.04
4.56
81.8
26
3.1
4.04
4.76
107.0
30
3.3
4.22
4.67
120.1
35
3.3
4.20
4.61
133.1
40
3.2
4.12
4.67
154.6
48
3.1
4.14
4.53
184.2
52
3.4
4.13
4.66
218.2
62
3.4
kg
458
466
489
515
502
533
835
845
876
982
1046
kg
kg
488
514
496
522
519
545
545
571
531
557
562
588
867
912
877
922
912
960
1021
1058
1085
1122
dB(A)
dB(A)
80
49
81
49
81
49
81
49
87
55
87
55
84
52
84
52
84
52
90
58
90
58
dB(A)
dB(A)
80
48
83
51
83
51
83
51
83
51
83
51
2
2
3
3
3
3
3
3
2
2
4
2
2
4
15.5
-
19.0
-
20.0
-
25.0
-
12.5
12.5
16.0
16.0
50
33
33
33
25
25
1
5300
16
2
7600
12
2
7600
12
2
7600
12
2
10600
16
2
10600
16
79
80
80
80
80
48
48
48
48
48
Hermetic scroll compressors, 48.3 r/s
2
2
2
2
2
2
2
2
2
2
R-410A
8.5
9.0
12.5
15.0
12.5
Pro-Dialog +
50
50
50
50
50
Grooved copper tubes and aluminium fins
Axial Flying Bird IV with rotating shroud
1
1
1
1
1
3800
3800
3800
3800
5300
12
12
12
12
12
Direct expansion. plate heat exchanger
2.6
3.0
3.3
4.0
4.8
5.6
8.7
9.9
11.3
12.4
14.7
kPa
1000
1000
1000
1000
1000
1000
1000
kg
kg
%
l/s
r/s
l
bar
kPa
in
mm
1000
1000
1000
1000
Pump, Victaulic screen filter, safety valve, expansion tank, purge valves (water + air), pressure sensors
12
12
12
12
12
12
35
35
35
35
35
1
1
1
1
1
1
1.5
1.5
1.5
1.5
1.5
400
400
400
400
400
400
400
400
400
400
400
Victaulic
2
2
2
2
2
2
2
2
2
2
2
60.3
60.3
60.3
60.3
60.3
60.3
60.3
60.3
60.3
60.3
60.3
Colour code: RAL7035
* Standard Eurovent LCP/A/P/C/AC conditions in cooling mode: evaporator entering/leaving water temperature 12C/7C, outside air temperature 35C, evaporator fouling factor 0.18 x 10-4 (m2 K)/W
** Standard Eurovent LCP/A/P/C/CHF conditions in cooling mode: evaporator entering/leaving water temperature 23C/18C, outside air temperature 35C, evaporator fouling factor 0.18 x 10-4 (m2 K)/W
*** Weight shown is a guideline only. To find out the unit refrigerant charge, please refer to the unit nameplate.
**** In accordance with ISO 9614-1 and certified by Eurovent. The values have been rounded and are for information only and not contractually binding
For information, calculated from the sound power level Lw(A)
When delivered, the standard pre-inflation of the tank is not necessarily the optimal value for the system. To permit changing the water volume, change the inflation pressure to a pressure that is
close to the static head of the system.
039
38.4
13.0
2.96
B
045
43.7
15.7
2.77
C
050
49.9
18.4
2.71
C
060
58.4
20.8
2.80
C
070
63.9
23.1
2.77
C
078
73.9
28.1
2.63
D
080
77.7
27.4
2.84
C
090
85.8
31.1
2.76
C
100
96.2
34.8
2.76
C
120
113.2
41.3
2.74
C
140
131.6
46.6
2.82
C
160
149.7
56.9
2.63
D
kW
kW
kW/kW
kW
kW
kW/kW
4.00
4.68
41.6
13.3
3.12
B
48.1
13.9
3.45
42.4
11.2
3.80
4.01
4.68
46.4
15.0
3.09
B
55.0
16.7
3.29
46.5
12.3
3.80
4.00
4.69
53.0
17.3
3.07
B
63.8
19.9
3.20
54.2
14.1
3.83
3.80
4.26
61.0
19.8
3.08
B
71.5
22.4
3.20
62.3
16.4
3.80
3.83
4.26
69.1
22.3
3.10
B
79.6
24.9
3.20
71.1
18.7
3.80
3.75
4.27
77.0
26.5
2.91
C
93.9
30.6
3.07
79.3
22.5
3.53
4.00
4.76
79.2
25.5
3.11
B
95.2
29.1
3.27
82.2
21.7
3.80
4.06
4.49
92.3
30.2
3.06
B
107.4
33.4
3.22
94.4
24.9
3.80
4.03
4.40
100.3
32.2
3.12
B
118.4
37.0
3.20
102.5
26.7
3.84
4.04
4.61
116.2
37.5
3.10
B
142.2
44.5
3.20
120.2
31.7
3.80
4.00
4.35
136.9
44.2
3.10
B
163.9
50.1
3.27
140.6
37.0
3.80
3.91
4.36
157.0
52.2
3.01
B
188.4
62.4
3.02
161.4
44.2
3.65
kg
506
513
539
552
553
560
748
895
903
959
1060
1078
kg
kg
535
561
543
569
569
594
582
608
582
608
590
616
778
804
927
972
935
980
995
1043
1099
1136
1117
1127
dB(A)
dB(A)
80
49
81
49
81
49
86
55
87
55
87
55
84
52
84
52
84
52
84
52
90
58
90
58
dB(A)
dB(A)
83
51
83
51
83
51
83
51
83
51
83
51
2
2
3
3
3
3
3
3
2
2
4
2
2
4
21.5
-
27.5
-
28.5
-
33.0
-
19.0
19.0
18.5
18.5
50
33
33
33
25
25
2
7600
12
2
7600
12
2
7600
12
2
7600
16
2
2
10600 10600
16
960
79
80
80
80
80
80
48
48
48
48
48
48
Hermetic scroll compressors, 48.3 r/s
2
2
2
2
2
2
2
2
2
2
2
2
R-410A
12.5
13.5
16.5
17.5
18.0
16.5
Pro-Dialog +
50
50
50
50
50
50
Grooved copper tubes and aluminium fins
Axial Flying Bird IV with rotating shroud
1
1
1
1
1
1
3800 3800 3800 5300 5300 5300
12
12
12
12
12
16
Direct expansion. plate heat exchanger
2.6
3.0
4.0
4.8
4.8
5.6
8.7
8.7
9.9
11.3
12.4
14.7
kPa
1000
1000
1000
1000
1000
1000
1000
kW
kW
kW/kW
kW/kW
kW/kW
kW
kW
kW/kW
kg
kg
%
l/s
r/s
l
bar
kPa
in
mm
1000
1000
1000
1000
1000
Pump, Victaulic screen filter, safety valve, expansion tank, purge valves (water + air), pressure sensors
12
12
12
12
12
12
35
35
35
35
35
35
1
1
1
1
1
1
1
1.5
1.5
1.5
1.5
1.5
400
400
400
400
400
400
400
400
400
400
400
400
Victaulic
2
2
2
2
2
2
2
2
2
2
2
2
60.3
60.3
60.3
60.3
60.3
60.3
60.3
60.3
60.3
60.3
60.3
60.3
Colour code: RAL 7035
* Standard Eurovent LCP/A/P/C/AC conditions in cooling mode: evaporator entering/leaving water temperature 12C/7C, outside air temperature 35C, evaporator fouling factor 0.18 x 10-4 (m2 K)/W.
Standard Eurovent LCP/A/P/C/AC conditions in heating mode: water heat exchanger entering/leaving water temperature 40C/45C, outside air dry bulb/wet bulb temperature 7C/6C, water heat
exchanger fouling factor 0.18 x 10-4 (m2 K)/W
** Standard Eurovent LCP/A/P/C/CHF conditions in cooling mode: evaporator entering/leaving water temperature 23C/18C, outside air temperature 35C, evaporator fouling factor 0.18 x 10-4 (m2 K)/W
Standard Eurovent LCP/A/P/C/CHF conditions in heating mode: water heat exchanger entering/leaving water temperature 30C/35C, outside air dry bulb/wet bulb temperature 7C/6C, water
heat exchanger fouling factor 0.18 x 10-4 (m2 K)/W
*** Weight shown is a guideline only. To find out the unit refrigerant charge, please refer to the unit nameplate.
**** In accordance with ISO 9614-1 and certified by Eurovent. The values have been rounded and are for information only and not contractually binding
For information, calculated from the sound power level Lw(A)
When delivered, the standard pre-inflation of the tank is not necessarily the optimal value for the system. To permit changing the water volume, change the inflation pressure to a pressure that is
close to the static head of the system.
1k
75.1
76.0
76.0
76.0
82.9
82.9
78.7
78.8
78.9
85.9
85.9
2k
71.9
72.8
72.4
73.7
76.9
77.2
75.9
76.1
76.8
79.9
80.2
4k
67.2
67.3
67.8
68.8
72.6
71.1
70.7
73.7
71.4
75.6
74.1
Sound power
levels
dB(A)
dB(A)
dB(A)
dB(A)
dB(A)
dB(A)
dB(A)
dB(A)
dB(A)
dB(A)
dB(A)
80
81
81
81
87
87
84
84
84
90
90
1k
75.4
76.0
76.0
82.7
82.8
82.8
78.4
78.7
78.8
78.9
85.8
85.9
2k
72.6
72.8
72.4
76.8
76.9
77.2
75.6
75.9
76.1
76.8
79.9
80.2
4k
66.9
67.3
67.8
70.8
72.6
71.1
69.9
70.7
73.7
71.4
75.6
74.1
Sound power
levels
dB(A)
dB(A)
dB(A)
dB(A)
dB(A)
dB(A)
dB(A)
dB(A)
dB(A)
dB(A)
dB(A)
dB(A)
80
81
81
86
87
87
84
84
84
84
90
90
Sound power
levels
dB(A)
dB(A)
dB(A)
dB(A)
dB(A)
dB(A)
dB(A)
dB(A)
dB(A)
dB(A)
dB(A)
79
80
80
80
80
80
83
83
83
83
83
Sound power
levels
dB(A)
dB(A)
dB(A)
dB(A)
dB(A)
dB(A)
dB(A)
dB(A)
dB(A)
dB(A)
dB(A)
dB(A)
79
80
80
80
80
80
83
83
83
83
83
83
The required protection level for this class is IP43BW (according to reference
document IEC 60529). All 30RB/RQ units are protected to IP44CW and fulfil
this protection condition.
039
045
050
060
070
080
090
100
120
140
160
168.8
0.83
42.2
57.8
73.7
88.3
195.8
0.81
45.5
67.1
81.2
108.1
239.8
0.79
52.4
82.7
96.2
118.0
226.2
0.81
62.3
91.2
111.6
149.2
275.2
0.78
71.5
112.2
131.6
162.4
V-ph-Hz 400-3-50
V
360-440
24 V via internal transformer
A
A
112.7
130.9
141.0
143.4
170.4
209.4
74.7
86.5
93.8
96.2
114.4
139.8
0.83
0.81
0.81
0.83
0.81
0.78
18.8
20.8
24.4
27.8
31.2
35.8
25.7
30.6
34.9
38.3
45.6
55.8
32.9
37.3
43.5
48.3
55.8
65.8
38.1
49.1
51.3
57.9
74.6
81.2
Customer reserve at the 24 V control power circuit
See table Short-circuit stability current below
kW
A
A
A
* Maximum instantaneous start-up current at operating limit values (maximum operating current of the smallest compressor(s) + fan current + locked rotor current of the largest compressor).
** Power input, compressors and fans, at the unit operating limits (saturated suction temperature 10C, saturated condensing temperature 65C) and nominal voltage of 400 V (data given on the unit
nameplate).
*** Standardised Eurovent conditions: evaporator entering/leaving water temperature 12C/7C, outside air temperature 35C.
**** Maximum unit operating current at maximum unit power input and 400 V (values given on the unit nameplate).
Maximum unit operating current at maximum unit power input and 360 V.
Short-circuit stability current (TN system*) - standard unit (with main disconnect without fuse)
30RBS
Value without upstream protection
Short-term current at 1s - Icw kA rms
Admissible peak current - Ipk - kA pk
Value with upstream protection by circuit breaker
Conditional short-circuit current Icc - kA rms
Schneider circuit breaker - Compact series
Reference No.**
039
045
050
060
070
080
090
100
120
140
160
3.36
20
3.36
20
3.36
20
3.36
20
3.36
20
3.36
15
5.62
20
5.62
20
5.62
15
5.62
20
5.62
15
40
40
40
40
40
40
40
40
40
30
30
NS100H NS100H NS100H NS100H NS100H NS100H NS100H NS160H NS160H NS250H NS250H
29670
29670
29670
29670
29670
29670
29670
30670
30670
31671
31671
039
045
050
060
070
078
V-ph-Hz
V
400-3-50
360-440
24 V via internal transformer
A
A
kW
A
A
A
080
090
100
120
140
160
209.4
0.78
35.5
55.8
65.8
80.6
168.8
0.83
42.2
57.8
73.7
88.3
195.8
0.81
45.5
67.1
81.2
108.1
239.8
0.79
52.4
82.7
96.2
118.0
226.2
0.81
62.3
91.2
111.6
149.2
275.2
0.78
71.5
112.2
131.6
162.4
* Maximum instantaneous start-up current at operating limit values (maximum operating current of the smallest compressor(s) + fan current + locked rotor current of the largest compressor).
** Power input, compressors and fans, at the unit operating limits (saturated suction temperature 10C, saturated condensing temperature 65C) and nominal voltage of 400 V (data given on the unit
nameplate).
*** Standardised Eurovent conditions: water heat exchanger entering/leaving water temperature 12C/7C, outside air temperature 35C.
**** Maximum unit operating current at maximum unit power input and 400 V (values given on the unit nameplate).
Maximum unit operating current at maximum unit power input and 360 V.
Short-circuit stability current (TN system*) - standard unit (with main disconnect without fuse)
30RQS
039
Value without upstream protection
Short-term current at 1s - Icw kA rms
3,36
Admissible peak current - Ipk - kA pk
20
Value with upstream protection by circuit breaker
Conditional short-circuit current Icc - kA rms
40
Schneider circuit breaker - Compact series
NS100H
Reference No.**
29670
045
050
060
070
078
080
090
100
120
140
160
3,36
20
3,36
20
3,36
20
3,36
20
3,36
15
3,36
15
5,62
20
5,62
20
5,62
15
5,62
20
5,62
15
40
40
40
40
40
40
40
40
40
30
30
NS100H NS100H NS100H NS100H NS100H NS100H NS100H NS160H NS160H NS250H NS250H
29670
29670
29670
29670
29670
29670
29670
30670
30670
31671
31671
039
045
050
060
070
080
090
100
120
140
160
0.9
0.9
0.9
0.9
1.0
1.2
1.3
1.5
1.7
2.0
2.3
3.0
3.4
3.7
4.2
5.0
5.5
6.8
7.7
8.5
10.6
11.2
* Maximum flow rate at a pressure drop of 100 kPa in the plate heat exchanger (unit without
hydronic module).
** Maximum flow rate at an available pressure of 20 kPa (unit with low-pressure hydronic
module) or 50 kPa (high-pressure module).
*** Maximum flow rate with single pump is 2 to 4% higher, depending on the size.
Operating range
30RBS
Evaporator
Entering water temperature at start-up
Leaving water temperature during operation
Entering/leaving water temperature difference
Condenser
Entering air temperature***
Minimum Maximum
C
C
K
7.5*
5**
3
30
20
10
-10
48
* For entering water temperatures below 7.5C at start-up, contact Carrier. Please refer to
options 28 and 42 for low-temperature applications (< -10C).
** For low-temperature applications, where the leaving water temperature is below 5C, a frost
protection solution must be used.
*** Ambient temperature: For transport and storage of the 30RB units the minimum and maximum
allowable temperatures are -20C and +48C. It is recommended that these temperatures
are used for transport by container.
Minimum load
30RQS
039
045
050
060
070
078
080
090
100
120
140
160
0.9
0.9
0.9
0.9
1.0
1.2
1.2
1.3
1.5
1.7
2.0
2.3
3.0
3.4
4.2
5.0
5.0
5.5
6.8
6.8
7.7
8.5
10.6
11.2
* Maximum flow rate at a pressure drop of 100 kPa in the plate heat exchanger (unit without
hydronic module).
** Maximum flow rate at an available pressure of 20 kPa (unit with low-pressure hydronic
module) or 50 kPa (high-pressure module).
*** Maximum flow rate with single pump is 2 to 4% higher, depending on the size.
Minimum Maximum
C
C
K
7,5
5*
3
30
20
10
-10
48
30RQS
Condenser
Entering water temperature at start-up
Leaving water temperature during operation
Entering/leaving water temperature difference
Evaporator
Air temperature
40
30
20
10
0
-10
-20
0
Full load
10
10
15
20
25
Maximum
C
C
K
8
25
3
45
55
10
-15
40
Minimum
Full load
-10
10
20
30
40
50
Dimensions/clearances, 30RBS
Legend:
All dimensions are given in mm
Control box
Water inlet
Water outlet
1
2
Notes:
A
Non-certified drawings.
Refer to the certified dimensional drawings supplied with the unit or available
on request, when designing an installation.
For the location of fixing points, weight distribution and coordinates of the
centre of gravity refer to the certified dimensional drawings.
In multiple-chiller installations (maximum four units), the side clearance
between the units should be increased from 1000 to 2000 mm.
The height of the solid surface must not exceed 2 m.
B
C
11
Dimensions/clearances, 30RBS
Legend:
All dimensions are given in mm
Control box
Water inlet
Water outlet
1
2
12
Notes:
A
Non-certified drawings.
Refer to the certified dimensional drawings supplied with the unit or available
on request, when designing an installation.
For the location of fixing points, weight distribution and coordinates of the
centre of gravity refer to the certified dimensional drawings.
In multiple-chiller installations (maximum four units), the side clearance
between the units should be increased from 1000 to 2000 mm.
The height of the solid surface must not exceed 2 m.
B
C
Dimensions/clearances, 30RQS
Legend:
All dimensions are given in mm
Control box
Water inlet
Water outlet
Notes:
A
Non-certified drawings.
Refer to the certified dimensional drawings supplied with the unit or available
on request, when designing an installation.
For the location of fixing points, weight distribution and coordinates of the
centre of gravity refer to the certified dimensional drawings.
In multiple-unit installations (maximum four units), the side clearance between
the units should be increased from 1000 to 2000 mm.
The height of the solid surface must not exceed 2 m.
B
C
13
Dimensions/clearances, 30RQS
Legend:
All dimensions are given in mm
Control box
Water inlet
Water outlet
14
Notes:
A
Non-certified drawings.
Refer to the certified dimensional drawings supplied with the unit or available
on request, when designing an installation.
For the location of fixing points, weight distribution and coordinates of the
centre of gravity refer to the certified dimensional drawings.
In multiple-unit installations (maximum four units), the side clearance between
the units should be increased from 1000 to 2000 mm.
The height of the solid surface must not exceed 2 m.
B
C
045
050
ESEER (EUROVENT)
060
070
080
090
100
120
140
160
Legend
Load %
Cap kW
Unit kW
EER
LOAD
%
100
75
50
25
100
75
50
25
100
75
50
25
100
75
50
25
100
75
50
25
100
75
50
25
100
75
50
25
100
75
50
25
100
75
50
25
100
75
50
25
100
75
50
25
CAP
kW
39.4
29.5
19.7
9.83
44.6
33.4
22.3
11.1
51.4
39.0
26.0
13.0
58.4
43.8
29.2
14.6
66.7
50.0
33.3
16.7
78.4
58.9
39.3
19.6
89.4
67.0
44.7
22.3
99.9
74.9
49.9
25.0
117
87.8
58.5
29.3
134
101
67.1
33.6
157
118
78.6
39.3
UNIT
kW
13.7
8.20
4.55
2.27
16.1
9.34
5.05
2.52
18.8
10.9
5.91
2.95
21.2
12.2
6.67
3.35
24.4
14.1
7.63
3.87
30.1
16.5
9.00
4.54
31.8
17.4
10.1
4.87
35.9
19.0
11.4
5.62
43.2
23.3
13.7
6.46
49.1
28.0
15.2
7.21
57.9
33.4
17.9
8.31
EER
kW/kW
2.88
3.60
4.32
4.34
2.77
3.58
4.41
4.43
2.74
3.57
4.39
4.41
2.76
3.59
4.38
4.36
2.74
3.56
4.37
4.31
2.61
3.56
4.36
4.33
2.81
3.86
4.41
4.59
2.78
3.95
4.37
4.45
2.71
3.77
4.28
4.53
2.74
3.59
4.40
4.66
2.71
3.52
4.38
4.73
ESEER
kW/kW
4.04
4.09
4.07
4.06
4.04
4.04
4.22
4.20
4.12
4.14
4.13
15
045
050
060
070
078
080
090
100
120
140
160
16
Legend
Load %
Cap kW
Unit kW
EER
LOAD
%
100
75
50
25
100
75
50
25
100
75
50
25
100
75
50
25
100
75
50
25
100
75
50
25
100
75
50
25
100
75
50
25
100
75
50
25
100
75
50
25
100
75
50
25
100
75
50
25
CAP
kW
38.4
28.8
19.2
9.60
43.7
32.7
21.8
10.9
49.9
37.4
24.9
12.5
58.4
43.8
29.2
14.6
63.9
47.9
31.9
16.0
73.9
55.5
37.0
18.5
77.7
58.3
38.9
19.4
85.8
64.3
42.9
21.4
96.2
72.1
48.1
24.0
113
84.9
56.6
28.3
132
99
65.8
32.9
150
112
74.9
37.4
UNIT
kW
13.0
8.00
4.52
2.25
15.7
9.29
5.06
2.52
18.4
10.9
5.76
2.86
20.8
12.7
7.22
3.67
23.1
13.7
7.78
4.02
28.1
16.6
9.22
4.62
27.4
16.4
9.13
4.49
31.1
17.5
10.1
4.83
34.8
19.6
11.4
5.53
41.3
24.0
13.5
6.12
46.6
28.1
15.6
7.37
56.9
33.4
18.1
8.38
EER
kW/kW
3.05
3.71
4.38
4.40
2.81
3.57
4.37
4.39
2.73
3.47
4.37
4.39
2.75
3.38
3.97
3.90
2.75
3.47
4.08
3.94
2.78
3.53
4.24
4.23
2.80
3.50
4.19
4.26
2.78
3.72
4.29
4.49
2.76
3.69
4.22
4.35
2.73
3.53
4.19
4.61
2.94
3.66
4.39
4.65
2.70
3.45
4.25
4.58
ESEER
kW/kW
4.00
4.01
4.00
3.80
3.83
3.75
4.00
4.06
4.03
4.04
4.00
3.91
Legend:
LWT
CAP kW
COMP kW
UNIT kW
COOL l/s
COOL kPa
039
045
050
060
070
080
090
100
120
140
160
039
045
050
060
070
080
090
100
120
140
160
039
045
050
060
070
080
090
100
120
140
160
30RBS 039-160
COMP
kW
11.6
13.4
15.9
18.1
21.3
24.4
26.8
30.5
37.0
40.9
49.0
11.9
13.7
16.4
18.4
21.9
24.9
27.5
31.3
38.8
42.2
50.6
12.3
14.1
17.4
18.9
22.7
25.7
28.5
32.7
40.5
44.3
52.8
UNIT
kW
12.3
14.3
16.7
18.9
21.7
26.2
28.3
32.1
38.6
43.9
52.2
12.6
14.6
17.3
19.2
22.3
26.7
29.0
32.9
40.3
45.3
53.8
13.0
15.1
18.2
19.7
23.1
27.5
30.1
34.2
42.1
47.3
56.0
COOL
kPa
42.2
53.1
62.7
63.7
64.4
71.4
53.3
55.3
62.8
68.3
75.2
47.0
58.1
70.2
71.5
71.1
79.4
59.0
60.8
68.9
75.5
84.0
54.9
66.2
82.5
84.0
78.8
93.3
68.3
69.7
79.3
87.4
98.9
35
CAP
kW
37.2
42.0
48.7
54.5
62.8
74.1
84.2
94.3
111.0
126.8
147.5
39.3
44.6
51.9
58.4
66.7
78.6
89.4
99.9
117.0
134.3
157.1
42.6
48.4
57.1
64.5
71.2
85.6
97.3
108.5
126.5
146.1
172.1
COMP
kW
12.7
14.9
17.5
20.1
23.3
26.7
29.6
33.5
39.8
44.7
53.1
13.0
15.1
18.0
20.4
24.0
27.2
30.2
34.4
41.6
46.1
54.8
13.5
15.6
19.0
20.9
24.8
28.0
31.3
35.8
44.0
48.4
57.5
UNIT
kW
13.4
15.8
18.3
20.9
23.7
28.5
31.1
35.0
41.4
47.7
56.3
13.7
16.1
18.9
21.2
24.4
29.0
31.8
35.9
43.2
49.1
57.9
14.1
16.6
19.9
21.7
25.2
29.8
32.9
37.3
45.6
51.3
60.6
Application data:
Standard units, refrigerant: R410A
Evaporator temperature rise: 5 K
Evaporator fluid: chilled water
Fouling factor: 0.18 x 10-4 (m2 K)/W
Performances in accordance with EN 14511
COOL
l/s
1.86
2.12
2.47
2.78
3.20
3.77
4.27
4.79
5.62
6.47
7.50
1.97
2.25
2.64
2.99
3.40
4.00
4.54
5.08
5.94
6.87
7.99
2.14
2.45
2.91
3.29
3.63
4.37
4.96
5.53
6.45
7.49
8.77
COOL
l/s
1.77
2.00
2.32
2.59
2.99
3.53
4.01
4.49
5.28
6.04
7.03
1.87
2.12
2.48
2.78
3.18
3.74
4.26
4.76
5.58
6.41
7.50
2.04
2.31
2.73
3.08
3.40
4.09
4.65
5.18
6.04
6.98
8.22
COOL
kPa
38.2
47.9
55.7
55.9
56.7
62.5
47.3
49.0
55.6
60.0
66.3
42.5
52.5
62.2
62.9
62.6
69.5
52.3
53.9
61.0
66.2
74.2
49.5
59.7
73.0
74.2
69.6
81.7
60.5
61.8
69.9
76.5
87.2
40
CAP
kW
34.9
38.7
45.0
50.0
58.0
68.7
77.9
87.4
103.4
117.0
136.9
36.9
41.1
48.1
53.7
61.5
72.8
82.8
92.5
109.0
123.9
145.8
40.0
44.7
52.9
59.5
65.9
79.4
90.2
100.4
117.5
134.6
159.9
COMP
kW
14.0
16.4
19.4
22.2
25.5
29.3
32.6
36.7
43.0
48.9
57.9
14.3
16.6
19.8
22.5
26.2
29.7
33.2
37.6
44.8
50.3
59.5
14.8
17.1
20.8
23.0
27.1
30.5
34.4
39.1
47.7
52.5
62.3
UNIT
kW
14.7
17.3
20.3
23.0
25.8
31.2
34.1
38.2
44.5
51.8
61.0
15.0
17.6
20.7
23.4
26.5
31.6
34.8
39.2
46.4
53.2
62.7
15.4
18.0
21.7
23.9
27.4
32.4
35.9
40.6
49.3
55.5
65.4
COOL
l/s
1.66
1.84
2.14
2.38
2.76
3.27
3.71
4.16
4.92
5.58
6.52
1.76
1.96
2.29
2.56
2.93
3.48
3.95
4.41
5.20
5.91
6.95
1.91
2.13
2.53
2.84
3.15
3.79
4.31
4.80
5.61
6.43
7.64
COOL
kPa
33.5
41.5
48.2
47.8
48.7
53.5
40.8
42.6
48.5
51.5
57.3
37.2
45.6
53.9
53.8
53.8
59.7
45.2
46.8
53.1
56.8
64.0
43.4
52.0
63.3
64.0
60.2
69.9
52.4
53.6
60.5
65.4
75.5
45
CAP
kW
32.3
35.2
40.8
45.2
52.5
62.8
71.0
79.7
94.7
105.9
125.3
34.2
37.4
43.7
48.5
55.6
66.5
75.6
84.3
100.2
112.2
133.5
37.1
40.8
48.1
53.9
59.9
72.6
82.5
91.5
107.9
121.8
146.5
COMP
kW
15.6
18.0
21.6
24.7
27.8
32.2
35.9
40.2
47.0
53.5
63.2
15.9
18.2
21.8
25.0
28.5
32.6
36.6
41.1
48.2
54.6
64.8
16.4
18.6
22.7
25.5
29.5
33.3
37.7
42.5
51.1
56.9
67.5
UNIT
kW
16.3
18.9
22.4
25.5
28.1
34.2
37.4
41.7
48.5
56.4
66.2
16.5
19.1
22.7
25.8
28.8
34.6
38.1
42.6
49.7
57.5
67.8
17.0
19.5
23.6
26.3
29.7
35.4
39.2
44.0
52.6
59.7
70.5
COOL
l/s
1.54
1.68
1.94
2.15
2.50
2.99
3.38
3.79
4.51
5.05
5.97
1.63
1.78
2.09
2.31
2.65
3.18
3.60
4.02
4.78
5.36
6.37
1.77
1.95
2.30
2.57
2.86
3.47
3.94
4.37
5.15
5.82
7.00
COOL
kPa
28.5
35.1
40.2
39.6
40.6
44.6
34.2
35.9
40.8
42.6
48.2
31.7
38.6
45.2
44.7
44.7
49.8
38.1
39.4
45.1
47.0
53.9
37.0
44.3
53.1
53.4
50.5
58.4
44.3
45.1
51.3
54.1
63.6
17
18
Legend:
LWT
CAP kW
COMP kW
UNIT kW
COOL l/s
COOL kPa
039
045
050
060
070
080
090
100
120
140
160
039
045
050
060
070
080
090
100
120
140
160
30RBS 039-160
COMP
kW
13.0
15.0
18.1
19.9
23.2
27.1
30.5
35.3
43.0
46.0
55.2
13.5
15.6
18.5
20.7
23.4
27.9
31.9
37.0
44.7
47.2
56.7
UNIT
kW
13.7
16.0
19.0
20.8
23.6
28.9
32.1
36.8
44.6
49.0
58.4
14.2
16.5
19.4
21.5
23.8
29.7
33.4
38.5
46.3
50.2
59.9
COOL
kPa
70.5
81.4
107.1
105.4
91.6
121.0
85.9
86.5
99.3
113.0
129.2
81.7
91.3
124.1
120.0
97.7
141.6
97.8
97.8
112.8
131.1
151.1
35
CAP
kW
48.7
55.0
66.6
74.2
78.3
98.6
111.2
123.6
143.8
169.0
199.9
52.6
59.2
72.7
80.2
81.8
107.0
120.1
133.1
154.6
184.2
218.2
COMP
kW
14.2
16.5
20.0
21.9
25.7
29.4
33.4
38.4
46.6
50.7
60.1
14.7
17.1
20.4
22.6
25.9
30.3
34.8
40.1
48.3
51.8
61.7
UNIT
kW
14.8
17.5
20.9
22.7
26.0
31.3
34.9
39.9
48.2
53.6
63.2
15.3
18.1
21.3
23.5
26.2
32.3
36.3
41.7
49.9
54.8
64.8
COOL
l/s
2.33
2.63
3.19
3.55
3.75
4.72
5.32
5.91
6.88
8.10
9.58
2.52
2.84
3.49
3.85
3.92
5.13
5.75
6.38
7.41
8.83
10.47
Application data:
Standard units, refrigerant: R410A
Evaporator temperature rise: 5 K
Evaporator fluid: chilled water
Fouling factor: 0.18 x 10-4 (m2 K)/W
Performances in accordance with EN 14511
COOL
l/s
2.45
2.80
3.41
3.79
4.00
5.04
5.68
6.32
7.34
8.70
10.20
2.65
3.01
3.73
4.10
4.18
5.49
6.14
6.81
7.91
9.49
11.14
COOL
kPa
63.6
73.1
94.6
93.7
81.0
106.0
76.0
76.6
87.5
98.5
114.2
73.7
82.1
109.9
106.5
86.7
123.1
86.5
86.6
99.3
114.4
133.6
40
CAP
kW
45.7
50.8
61.4
68.8
72.4
91.4
103.2
114.2
133.3
154.9
185.7
49.4
54.7
67.2
74.3
75.8
99.1
111.4
122.9
143.2
168.9
202.8
COMP
kW
15.6
17.9
22.2
24.0
28.4
32.0
36.5
41.7
50.5
55.7
65.5
16.1
18.5
22.6
24.8
28.6
32.9
37.9
43.4
52.2
56.9
67.1
UNIT
kW
16.2
18.9
23.0
24.8
28.7
33.9
38.0
43.2
52.1
58.6
68.7
16.7
19.5
23.4
25.6
28.9
34.9
39.4
44.9
53.7
59.7
70.2
COOL
l/s
2.18
2.43
2.94
3.29
3.46
4.38
4.94
5.47
6.38
7.42
8.90
2.37
2.62
3.22
3.56
3.63
4.75
5.34
5.89
6.86
8.10
9.73
COOL
kPa
55.7
63.5
81.6
81.5
70.0
90.9
65.9
66.2
75.5
83.4
98.8
64.5
71.3
94.8
92.7
75.3
105.7
75.1
74.7
85.5
97.0
115.7
45
CAP
kW
42.2
46.5
55.5
62.9
66.0
83.6
94.5
104.1
121.7
138.9
170.2
45.6
50.1
60.7
68.0
69.1
90.6
102.1
111.9
130.6
151.7
186.0
COMP
kW
17.2
19.5
24.5
26.4
30.9
34.7
39.9
45.1
54.7
61.1
71.6
17.7
20.1
24.9
27.1
31.5
35.6
41.4
46.8
56.3
62.3
73.1
UNIT
kW
17.8
20.4
25.3
27.2
31.1
36.8
41.4
46.6
56.2
63.9
74.6
18.3
21.0
25.7
28.0
31.8
37.7
42.9
48.3
57.8
65.1
76.1
COOL
l/s
2.02
2.23
2.66
3.01
3.16
4.01
4.52
4.98
5.83
6.65
8.15
2.19
2.40
2.91
3.26
3.31
4.35
4.89
5.36
6.26
7.27
8.92
COOL
kPa
47.3
54.4
67.6
69.1
58.9
75.9
55.8
55.8
63.2
67.7
83.3
54.8
61.0
78.6
78.7
63.3
88.0
63.6
62.9
71.5
79.0
97.6
10
Legend:
LWT
CAP kW
COMP kW
UNIT kW
COOL l/s
COOL kPa
039
045
050
060
070
078
080
090
100
120
140
160
039
045
050
060
070
078
080
090
100
120
140
160
039
045
050
060
070
078
080
090
100
120
140
160
C
5
LWT
30RQS 039-160
COMP
kW
10.9
13.2
15.7
17.0
19.2
23.8
23.3
26.3
29.7
35.8
38.9
48.3
11.1
13.5
15.9
17.4
19.6
24.4
23.7
26.8
30.4
36.6
39.7
49.4
11.5
13.8
16.4
17.9
20.2
25.2
24.4
27.6
31.4
37.7
40.9
51.3
UNIT
kW
11.7
14.0
16.4
18.7
20.8
25.4
24.8
27.8
31.2
37.4
42.0
51.4
11.9
14.2
16.7
19.0
21.2
26.0
25.3
28.3
31.9
38.1
42.8
52.6
12.3
14.6
17.2
19.6
21.9
26.8
26.0
29.1
32.9
39.3
44.1
54.4
COOL
kPa
39.2
50.2
46.8
48.4
60.0
58.4
42.7
49.1
54.4
59.5
65.7
70.3
44.2
55.4
51.6
53.5
66.7
65.5
47.6
54.7
60.5
66.6
73.1
78.4
52.4
64.1
59.3
62.3
77.7
77.7
55.7
63.8
70.8
78.7
85.5
91.9
35
CAP
kW
36.1
40.9
47.0
55.0
60.1
69.4
73.0
80.5
90.3
106.1
123.7
140.8
38.4
43.7
49.9
58.4
63.9
73.9
77.7
85.8
96.2
113.2
131.6
149.7
42.0
47.9
54.3
63.9
70.0
81.1
85.2
93.9
105.4
124.3
144.1
163.7
COMP
kW
12.0
14.7
17.3
18.8
21.1
25.9
25.4
29.1
32.6
39.0
42.7
52.6
12.2
15.0
17.6
19.2
21.5
26.5
25.8
29.6
33.4
39.8
43.5
53.8
12.5
15.3
18.1
19.8
22.1
27.4
26.6
30.4
34.5
41.0
44.8
55.7
UNIT
kW
12.8
15.5
18.1
20.5
22.7
27.5
26.9
30.6
34.1
40.6
45.8
55.7
13.0
15.7
18.4
20.8
23.1
28.1
27.4
31.1
34.8
41.3
46.6
56.9
13.3
16.1
18.9
21.5
23.7
29.0
28.1
31.9
36.0
42.5
47.9
58.8
Application data:
Standard units, refrigerant: R410A
Evaporator temperature rise: 5 K
Evaporator fluid: chilled water
Fouling factor: 0.18 x 10-4 (m2 K)/W
Performances in accordance with EN 14511
COOL
l/s
1.81
2.07
2.38
2.77
3.04
3.52
3.69
4.08
4.59
5.38
6.26
7.14
1.93
2.20
2.52
2.95
3.24
3.75
3.93
4.35
4.90
5.74
6.67
7.60
2.11
2.42
2.75
3.23
3.55
4.12
4.32
4.77
5.39
6.31
7.32
8.32
COOL
l/s
1.72
1.95
2.24
2.62
2.86
3.31
3.47
3.83
4.30
5.05
5.89
6.71
1.83
2.08
2.38
2.78
3.05
3.53
3.71
4.09
4.58
5.40
6.27
7.14
2.01
2.29
2.59
3.05
3.34
3.87
4.07
4.49
5.03
5.93
6.88
7.82
COOL
kPa
35.3
45.2
41.9
43.5
53.6
51.5
38.1
43.6
48.2
52.7
58.5
62.2
39.7
50.1
46.2
48.1
59.5
57.8
42.5
48.6
53.5
59.1
65.0
69.5
47.2
58.1
53.2
56.0
69.4
68.6
49.8
56.8
62.4
69.8
76.1
81.4
40
CAP
kW
33.7
37.7
43.7
50.9
55.7
64.6
67.9
74.3
83.5
98.6
114.8
131.0
35.9
40.2
46.4
54.0
59.3
68.8
72.4
79.2
89.0
105.3
122.1
139.3
39.3
44.2
50.6
59.2
64.9
75.5
79.4
86.9
97.5
115.7
133.8
152.4
COMP
kW
13.3
16.2
19.2
20.8
23.2
28.4
27.7
32.1
35.9
42.7
47.1
57.6
13.5
16.5
19.5
21.1
23.7
29.0
28.2
32.7
36.7
43.5
48.0
58.8
13.8
16.8
20.0
21.8
24.3
29.9
28.9
33.5
37.9
44.7
49.3
60.7
UNIT
kW
14.1
17.0
20.0
22.4
24.8
30.0
29.2
33.7
37.4
44.3
50.2
60.7
14.3
17.2
20.3
22.8
25.2
30.6
29.7
34.2
38.2
45.0
51.0
61.9
14.6
17.6
20.8
23.4
25.9
31.5
30.4
35.0
39.3
46.2
52.4
63.8
COOL
l/s
1.60
1.79
2.08
2.42
2.65
3.07
3.24
3.54
3.97
4.70
5.46
6.24
1.71
1.92
2.21
2.58
2.83
3.28
3.45
3.78
4.24
5.02
5.82
6.64
1.88
2.11
2.42
2.83
3.10
3.60
3.79
4.15
4.65
5.52
6.39
7.28
COOL
kPa
30.7
39.0
36.6
37.6
46.5
44.4
33.3
37.4
41.7
45.7
50.6
54.0
34.6
43.3
40.5
41.6
51.7
49.9
37.2
41.8
46.4
51.3
56.4
60.2
41.1
50.3
46.7
48.6
60.3
59.3
43.6
48.9
54.0
60.7
66.0
70.7
45
CAP
kW
31.0
34.1
39.8
46.3
50.7
59.2
62.4
67.4
75.8
90.5
104.7
120.2
33.1
36.5
42.4
49.3
54.0
63.1
66.6
72.0
80.8
96.6
111.4
127.9
36.3
40.2
46.4
54.1
59.2
69.3
73.1
79.2
88.6
106.2
122.1
140.0
COMP
kW
14.8
17.9
21.4
22.9
25.6
31.2
30.4
35.5
39.4
47.0
51.9
63.2
15.0
18.1
21.7
23.3
26.0
31.8
30.8
36.1
40.2
47.7
52.8
64.4
15.3
18.4
22.2
23.9
26.7
32.7
31.6
37.0
41.4
48.8
54.1
66.3
UNIT
kW
15.6
18.6
22.1
24.6
27.1
32.8
31.9
37.0
40.9
48.5
54.9
66.3
15.8
18.8
22.4
24.9
27.6
33.3
32.3
37.6
41.7
49.2
55.8
67.4
16.1
19.2
22.9
25.5
28.3
34.2
33.1
38.5
42.9
50.3
57.2
69.3
COOL
l/s
1.48
1.62
1.90
2.21
2.42
2.82
2.97
3.21
3.61
4.31
4.98
5.72
1.58
1.74
2.02
2.35
2.58
3.01
3.17
3.43
3.85
4.61
5.31
6.10
1.73
1.92
2.21
2.58
2.83
3.31
3.49
3.78
4.23
5.07
5.83
6.69
COOL
kPa
25.8
32.8
30.9
31.6
39.1
37.2
28.4
31.2
34.9
38.6
42.5
45.6
29.1
36.5
34.4
35.1
43.5
41.9
31.7
34.9
38.8
43.4
47.3
50.9
34.8
42.6
39.8
41.1
50.8
49.8
37.2
41.0
45.2
51.4
55.4
59.8
19
20
18
Legend:
LWT
CAP kW
COMP kW
UNIT kW
COOL l/s
COOL kPa
039
045
050
060
070
078
080
090
100
120
140
160
039
045
050
060
070
078
080
090
100
120
140
160
C
15
LWT
30RQS 039-160
COMP
kW
12.1
14.4
17.3
18.9
21.4
26.7
25.4
29.1
32.4
39.6
43.1
54.7
12.1
14.4
17.5
18.9
21.5
26.8
25.4
29.1
32.5
39.6
43.2
54.9
UNIT
kW
12.9
15.2
18.1
20.5
23.0
28.3
27.0
30.6
33.9
41.1
46.2
57.8
12.9
15.2
18.3
20.5
23.1
28.4
27.0
30.6
34.0
41.1
46.3
58.0
COOL
kPa
68.5
80.5
74.6
75.8
97.6
101.9
67.4
80.9
86.1
100.6
108.0
118.1
67.5
79.2
77.5
74.7
96.2
102.2
66.5
79.7
84.8
99.1
106.3
117.5
35
CAP
kW
48.1
55.0
62.5
71.5
79.5
93.9
95.1
107.3
118.3
142.0
163.8
188.3
48.1
55.0
63.8
71.5
79.6
93.9
95.2
107.4
118.4
142.2
163.9
188.4
COMP
kW
13.2
15.9
19.0
20.7
23.2
29.0
27.6
31.8
35.5
42.9
46.9
59.2
13.2
16.0
19.1
20.7
23.3
29.0
27.6
31.9
35.5
42.9
47.0
59.3
UNIT
kW
13.9
16.7
19.8
22.4
24.8
30.6
29.1
33.4
37.0
44.4
50.0
62.3
13.9
16.7
19.9
22.4
24.9
30.6
29.1
33.4
37.0
44.5
50.1
62.4
COOL
l/s
2.30
2.63
2.99
3.42
3.81
4.49
4.55
5.14
5.66
6.80
7.84
9.02
2.31
2.63
3.05
3.43
3.81
4.50
4.56
5.15
5.68
6.81
7.86
9.03
Application data:
Standard units, refrigerant: R410A
Evaporator temperature rise: 5 K
Evaporator fluid: chilled water
Fouling factor: 0.18 x 10-4 (m2 K)/W
Performances in accordance with EN 14511
COOL
l/s
2.43
2.80
3.17
3.64
4.08
4.77
4.85
5.49
6.09
7.27
8.40
9.60
2.44
2.80
3.26
3.65
4.08
4.82
4.86
5.50
6.09
7.28
8.40
9.66
COOL
kPa
61.0
72.1
67.1
67.4
85.8
90.1
59.7
71.2
75.3
88.3
94.8
104.4
60.1
71.1
68.6
66.5
84.6
88.9
58.9
70.3
74.4
87.1
93.5
102.9
40
CAP
kW
44.7
50.3
58.4
65.8
73.2
86.7
88.2
98.6
108.6
131.4
151.1
174.1
44.8
50.3
58.9
65.9
73.3
86.8
88.4
98.8
108.8
131.7
151.3
174.4
COMP
kW
14.4
17.4
21.0
22.6
25.4
31.4
29.9
34.9
39.0
46.6
51.4
64.1
14.4
17.4
21.1
22.7
25.4
31.5
30.0
35.0
39.1
46.7
51.5
64.2
UNIT
kW
15.2
18.2
21.8
24.3
27.0
33.0
31.4
36.4
40.5
48.1
54.5
67.2
15.2
18.2
21.9
24.3
27.0
33.1
31.5
36.5
40.6
48.2
54.6
67.3
COOL
l/s
2.14
2.41
2.79
3.15
3.50
4.15
4.22
4.72
5.20
6.30
7.23
8.33
2.14
2.41
2.82
3.16
3.51
4.16
4.23
4.73
5.21
6.31
7.25
8.36
COOL
kPa
52.3
61.6
59.2
57.8
73.6
76.7
51.8
60.7
64.3
76.0
81.2
89.4
51.7
60.8
59.3
57.1
72.7
75.8
51.2
59.9
63.6
75.1
80.3
88.5
45
CAP
kW
40.9
45.3
53.3
59.8
66.2
78.9
80.8
89.2
97.5
120.1
136.8
88.5
41.0
45.4
53.4
59.9
66.4
79.1
81.0
89.5
97.8
120.5
137.2
88.7
COMP
kW
15.9
18.9
23.1
24.8
27.7
34.1
32.5
38.3
42.9
50.6
56.1
28.6
15.9
19.0
23.1
24.8
27.7
34.2
32.6
38.4
43.0
50.7
56.2
28.6
UNIT
kW
16.6
19.7
23.9
26.4
29.2
35.6
34.0
39.8
44.3
52.1
59.1
31.6
16.6
19.7
23.9
26.4
29.3
35.7
34.1
39.9
44.4
52.2
59.3
31.7
COOL
l/s
1.96
2.17
2.55
2.86
3.17
3.77
3.87
4.27
4.67
5.75
6.55
4.24
1.96
2.18
2.56
2.87
3.18
3.79
3.88
4.29
4.69
5.77
6.57
4.25
COOL
kPa
43.4
51.3
50.0
48.2
61.0
63.2
43.8
50.2
52.8
63.6
67.2
23.8
43.0
50.8
49.5
47.8
60.5
62.7
43.4
49.7
52.2
63.1
66.5
23.5
Legend:
LWT
CAP kW
COMP kW
UNIT kW
COND l/s
COND kPa
039
045
050
060
070
078
080
090
100
120
140
160
039
045
050
060
070
078
080
090
100
120
140
160
039
045
050
060
070
078
080
090
100
120
140
160
30RQS 039-160
UNIT
kW
10.0
11.0
12.6
14.7
16.6
19.6
19.0
22.2
23.7
27.4
32.7
38.5
10.9
12.2
14.0
16.1
18.1
21.3
20.5
24.3
25.9
29.7
35.7
41.8
12.0
13.5
15.5
17.7
19.8
23.3
22.4
26.8
28.4
32.7
39.0
45.9
COND
kPa
21.9
27.3
25.5
24.5
30.8
32.0
21.9
26.0
27.0
30.9
35.0
36.2
21.5
27.1
24.8
23.8
30.1
30.9
21.0
25.3
26.5
29.7
34.2
35.1
21.2
26.9
24.2
23.1
29.3
30.1
20.2
24.5
25.9
28.7
33.4
34.2
0 (-0.9)
CAP
kW
35.8
39.2
45.8
52.7
59.9
67.2
69.6
79.8
86.5
101.8
118.4
136.6
35.7
39.3
45.5
52.4
59.6
66.5
68.6
79.3
86.2
100.4
117.8
135.3
35.6
39.6
45.3
52.2
59.2
65.9
67.6
78.8
85.9
99.3
117.1
134.2
COMP
kW
9.2
10.2
11.8
13.0
15.0
18.3
17.8
20.6
22.3
26.6
29.9
36.3
10.1
11.3
13.2
14.3
16.5
19.8
19.3
22.7
24.5
28.9
32.8
39.4
11.1
12.6
14.7
16.0
18.3
21.8
21.1
25.2
27.1
31.7
36.3
43.2
UNIT
kW
10.1
11.1
12.7
14.9
16.9
20.2
19.6
22.5
24.1
28.4
33.4
39.9
11.0
12.2
14.1
16.2
18.4
21.8
21.1
24.5
26.3
30.7
36.4
43.0
12.0
13.5
15.6
17.9
20.2
23.7
22.9
27.1
28.9
33.4
39.8
46.8
COND
l/s
1.72
1.88
2.20
2.53
2.88
3.23
3.34
3.83
4.15
4.89
5.69
6.56
1.72
1.89
2.19
2.52
2.87
3.20
3.30
3.81
4.15
4.83
5.67
6.51
1.72
1.91
2.18
2.52
2.85
3.17
3.26
3.80
4.14
4.78
5.64
6.47
Application data:
Standard units, refrigerant: R410A
Condenser temperature rise: 5 K
Condenser fluid: water
Fouling factor: 0.18 x 10-4 (m2 K)/W
Performances in accordance with EN 14511
COND
l/s
1.43
1.57
1.82
2.10
2.38
2.67
2.75
3.18
3.46
4.03
4.71
5.43
1.44
1.59
1.82
2.10
2.39
2.65
2.72
3.17
3.46
4.00
4.72
5.41
1.45
1.60
1.82
2.09
2.38
2.65
2.70
3.16
3.47
3.98
4.71
5.41
COND
kPa
32.0
37.7
36.1
34.7
43.8
47.1
31.7
37.2
37.9
45.1
50.2
52.5
31.0
37.0
34.9
33.6
42.4
45.1
30.2
35.9
36.9
42.9
48.7
50.4
30.2
36.7
33.9
32.7
41.0
43.3
28.8
34.8
35.9
41.1
47.1
48.6
7 (6)
CAP
kW
42.8
46.7
54.6
62.8
71.7
80.3
83.5
95.0
103.2
122.0
141.8
163.5
42.4
46.5
54.2
62.3
71.1
79.3
82.2
94.4
102.5
120.2
140.6
161.4
42.0
46.6
53.7
61.8
70.3
78.2
80.8
93.5
101.6
118.2
139.1
159.3
COMP
kW
9.5
10.3
12.0
13.3
15.4
18.9
18.4
20.9
22.8
27.6
30.7
37.6
10.3
11.4
13.3
14.6
16.8
20.6
19.9
23.1
25.0
29.9
33.6
40.7
11.3
12.7
14.7
16.1
18.5
22.4
21.7
25.5
27.5
32.6
36.9
44.4
UNIT
kW
10.3
11.2
12.9
15.1
17.3
20.8
20.1
22.7
24.5
29.3
34.2
41.1
11.2
12.3
14.1
16.4
18.7
22.5
21.7
24.9
26.7
31.7
37.0
44.2
12.2
13.5
15.6
18.0
20.4
24.3
23.4
27.3
29.3
34.3
40.4
48.0
COND
l/s
2.06
2.24
2.62
3.01
3.44
3.86
4.01
4.56
4.96
5.86
6.81
7.85
2.04
2.24
2.61
3.00
3.42
3.81
3.96
4.54
4.93
5.78
6.77
7.76
2.03
2.24
2.59
2.98
3.39
3.77
3.89
4.51
4.90
5.70
6.70
7.68
COND
kPa
46.2
51.3
49.9
48.1
61.3
67.7
44.9
51.8
52.6
64.1
70.9
74.6
44.4
49.8
48.0
46.4
58.9
64.5
42.6
50.0
50.8
60.9
68.2
71.2
42.7
48.9
46.2
44.8
56.5
61.4
40.3
48.1
49.0
57.8
65.3
68.0
15 (13)
CAP
kW
52.6
57.6
66.9
76.8
88.8
99.3
103.2
116.6
127.3
150.5
175.5
202.0
52.0
56.8
66.4
76.2
87.9
97.8
101.6
115.8
126.3
148.1
173.8
199.2
51.2
56.4
65.6
75.2
86.5
96.1
99.5
114.2
124.5
145.1
170.9
196.0
COMP
kW
9.8
10.5
12.3
13.6
16.0
19.7
18.9
21.4
23.6
28.6
32.0
39.1
10.7
11.5
13.5
15.0
17.4
21.5
20.6
23.7
25.7
31.1
34.8
42.5
11.6
12.8
14.9
16.4
19.0
23.3
22.4
25.9
28.0
33.8
37.8
46.1
UNIT
kW
10.7
11.3
13.1
15.4
17.9
21.6
20.6
23.2
25.3
30.3
35.4
42.6
11.6
12.4
14.4
16.8
19.3
23.3
22.3
25.5
27.4
32.8
38.2
45.9
12.5
13.6
15.8
18.2
20.8
25.2
24.1
27.7
29.8
35.5
41.1
49.6
COND
l/s
2.53
2.77
3.22
3.69
4.27
4.77
4.96
5.60
6.12
7.23
8.43
9.70
2.50
2.73
3.20
3.67
4.23
4.71
4.89
5.57
6.08
7.13
8.36
9.59
2.47
2.72
3.16
3.62
4.17
4.63
4.79
5.50
6.00
6.99
8.24
9.44
COND
kPa
71.0
74.3
72.5
70.2
91.5
104.0
67.1
76.4
77.6
96.6
106.5
113.1
67.9
70.7
69.8
67.7
87.7
98.8
63.6
73.7
74.7
91.6
102.2
107.7
64.4
68.5
66.8
64.6
83.3
93.4
59.9
70.3
71.3
86.2
96.9
102.1
21
22
Legend:
LWT
CAP kW
COMP kW
UNIT kW
COND l/s
COND kPa
039
045
050
060
070
078
080
090
100
120
140
160
039
045
050
060
070
078
080
090
100
120
140
160
30RQS 039-160
UNIT
kW
13.4
15.3
17.3
19.5
21.8
25.8
24.7
29.6
31.3
36.1
42.8
50.8
15.4
17.3
19.4
21.5
23.9
28.9
27.5
32.7
34.4
40.5
47.0
56.9
COND
kPa
21.1
26.2
23.7
22.1
28.3
29.5
19.6
23.4
25.1
27.9
32.3
33.6
21.1
25.2
23.4
21.1
27.4
29.3
19.1
22.2
24.4
27.4
31.3
33.4
0 (-0.9)
CAP
kW
35.5
39.3
44.9
51.4
58.4
65.2
66.6
77.7
85.1
98.0
115.7
133.1
35.4
38.6
44.7
50.5
57.6
64.7
65.7
76.2
84.1
96.9
114.2
132.3
COMP
kW
12.4
14.1
16.4
17.8
20.2
24.0
23.2
28.1
30.0
34.9
40.2
47.7
14.0
15.8
18.5
19.8
22.5
26.8
25.7
31.3
33.4
38.7
44.6
53.2
UNIT
kW
13.3
15.0
17.3
19.7
22.1
26.0
25.0
29.9
31.8
36.7
43.7
51.3
14.9
16.7
19.4
21.7
24.4
28.7
27.5
33.1
35.2
40.5
48.1
56.7
COND
l/s
1.71
1.90
2.17
2.48
2.82
3.15
3.21
3.75
4.10
4.73
5.58
6.42
1.71
1.87
2.16
2.44
2.78
3.13
3.17
3.68
4.07
4.68
5.52
6.40
Application data:
Standard units, refrigerant: R410A
Condenser temperature rise: 5 K
Condenser fluid: water
Fouling factor: 0.18 x 10-4 (m2 K)/W
Performances in accordance with EN 14511
COND
l/s
1.46
1.60
1.82
2.06
2.37
2.65
2.69
3.11
3.46
3.97
4.69
5.42
1.48
1.58
1.83
2.04
2.35
2.67
2.69
3.07
3.44
3.98
4.66
5.46
COND
kPa
29.4
35.5
32.7
31.1
39.3
41.7
27.5
33.2
34.5
39.3
45.1
46.8
28.7
33.8
31.8
29.6
37.5
40.3
26.2
31.4
33.2
37.7
43.2
45.5
7 (6)
CAP
kW
41.6
46.4
53.0
61.0
69.1
77.0
79.2
92.3
100.3
116.2
136.9
157.0
41.1
45.5
52.3
59.6
67.8
75.7
77.5
90.2
98.7
113.9
134.2
154.8
COMP
kW
12.4
14.1
16.4
18.0
20.5
24.6
23.7
28.4
30.4
35.7
40.7
48.7
13.9
15.8
18.4
20.0
22.7
27.1
26.0
31.6
33.8
39.3
45.3
53.7
UNIT
kW
13.3
15.0
17.3
19.8
22.3
26.5
25.5
30.2
32.2
37.5
44.2
52.2
14.8
16.6
19.3
21.8
24.6
29.0
27.8
33.4
35.5
41.0
48.7
57.2
COND
l/s
2.01
2.24
2.56
2.94
3.34
3.72
3.82
4.45
4.84
5.61
6.61
7.58
1.99
2.20
2.53
2.88
3.27
3.66
3.74
4.36
4.77
5.50
6.49
7.48
COND
kPa
41.0
47.5
44.3
42.8
53.7
58.3
38.1
46.0
46.9
54.7
62.2
64.8
39.3
45.0
42.5
40.3
50.8
55.4
35.9
43.2
44.6
51.7
58.8
61.8
15 (13)
CAP
kW
50.4
56.3
64.6
74.3
84.9
94.3
97.2
112.6
122.6
142.0
167.8
192.4
49.3
55.1
63.2
72.2
82.5
92.0
94.5
109.7
119.7
138.3
163.3
188.2
COMP
kW
12.7
14.2
16.5
18.2
20.8
25.5
24.5
28.7
30.9
37.0
41.4
50.4
14.0
15.8
18.3
20.2
23.0
27.9
26.8
31.9
34.1
40.4
45.7
55.1
UNIT
kW
13.6
15.1
17.4
20.0
22.6
27.4
26.2
30.5
32.6
38.7
44.8
53.9
14.9
16.7
19.2
22.0
24.8
29.8
28.5
33.7
35.8
42.1
49.0
58.6
COND
l/s
2.43
2.72
3.12
3.58
4.09
4.55
4.69
5.44
5.91
6.85
8.10
9.29
2.38
2.67
3.06
3.49
3.99
4.45
4.57
5.30
5.79
6.68
7.89
9.10
COND
kPa
61.1
66.9
63.7
61.9
78.8
88.0
56.2
67.1
67.9
81.0
91.8
96.5
57.3
63.3
60.1
57.6
73.4
82.3
52.3
62.6
63.8
75.5
85.5
90.7
039
045
050
060
070
078
080
090
100
120
140
160
kg
kg
kg
kg
488
514
535
561
496
522
543
569
519
545
569
594
545
571
582
608
531
557
582
608
590
616
562
588
778
804
867
912
927
972
877
922
935
980
912
960
995
1043
1021
1058
1099
1136
1085
1122
1117
1127
l
kPa
12
12
12
400
400
400
Victaulic screen filter
12
400
12
400
12
400
12
400
35
400
35
400
35
400
35
400
35
400
kW
kW
A
A
kW
kW
A
A
in
mm
Pump, Victaulic screen filter, safety valve, expansion tank, purge valves (water and air), pressure sensors
0,87
0,87
0,87
0,87
0,87
0,87
0,87
0,87
1,26
1,26
1,90
1,90
1,20
1,20
1,20
1,20
1,20
1,20
1,20
1,20
1,50
1,50
2,30
2,30
1,9
1,9
1,9
2,0
2,0
2,1
2,1
2,1
2,9
3,0
3,8
4,0
2,3
2,3
2,3
2,3
2,3
2,3
2,3
2,3
3,1
3,1
4,3
4,3
Pump, Victaulic screen filter, safety valve, expansion tank, purge valves (water and air), pressure sensors
1,90
1,90
1,90
1,90
1,90
1,90
1,90
1,90
1,90
2,56
2,56
2,56
2,30
2,30
2,30
2,30
2,30
2,30
2,30
2,30
2,30
3,00
3,00
3,00
3,1
3,2
3,2
3,3
3,3
3,4
3,4
3,5
3,6
5,0
5,1
5,3
4,3
4,3
4,3
4,3
4,3
4,3
4,3
4,3
4,3
5,8
5,8
5,8
Victaulic
2
2
2
2
2
2
2
2
2
2
2
2
60,3
60,3
60,3
60,3
60,3
60,3
60,3
60,3
60,3
60,3
60,3
60,3
* Weight shown is a guideline only. To find out the unit refrigerant charge, please refer to the unit nameplate.
** To obtain the maximum power input of a unit with hydronic module, add the maximum unit power input to the pump power input (**).
*** To obtain the maximum current draw of a unit with hydronic module, add the maximum unit current draw to the pump current draw (***).
30RQS only
Legend
Components of the unit and hydronic module
1 Victaulic screen filter
2 Expansion tank
3 Safety valve
4 Available pressure pump
Note: x 1 for a single pump, x 2 for a dual pump
5 Air purge
6 Water drain valve
Note: A second valve is located on the heat exchanger leaving piping
Pressure sensor
Note: Gives pump suction pressure information (see installation manual)
Temperature probe
Note: Gives heat exchanger leaving temperature information (see
installation manual)
Temperature probe
Note: Gives heat exchanger entering temperature information (see
installation manual)
Pressure sensor
Note: Gives unit leaving pressure information (see installation manual)
Check valve
Note: x 2 for a dual pump, not provided for a single pump
Plate heat exchanger
Water heat exchanger frost protection heater
Installation components
14 Temperature probe well
15 Air vent
16 Flexible connection
17 Shut-off valve
18 Screen filter (obligatory for a unit without hydronic module)
19 Pressure gauge
20 Water flow control valve
Note: Not necessary for a hydronic module with a variable-speed pump
21 Charge valve
22 Frost protection bypass valve (when shut-off valves [17] are closed during
winter)
--- Hydronic module (unit with hydronic module)
23
Low-pressure pump
Legend
Legend
1.
2.
3.
4.
5.
6.
1.
2.
3.
4.
5.
30RBS 039
30RBS 045
30RBS 050
30RBS 060
30RBS 070
30RBS 080
30RBS 090
30RBS 100
30RBS 120
30RBS 140
30RBS 160
High-pressure pump
Legend
Legend
1.
2.
3.
4.
5.
6.
1.
2.
3.
4.
5.
24
30RBS 039
30RBS 045
30RBS 050
30RBS 060
30RBS 070
30RBS 080
30RBS 090
30RBS 100
30RBS 120
30RBS 140
30RBS 160
Low-pressure pump
130
110
100
90
80
70
60
50
40
30
20
200
190
180
170
160
150
140
130
120
110
100
90
80
70
60
50
40
30
20
120
5
0,0
0,5
1,0
1,5
2,0
2,5
3,0
3,5
4,0
4,5
5,0
5,5
Legend
Legend
1. 30RQS 039
2. 30RQS 045
3. 30RQS 050
4. 30RQS 060
5. 30RQS 070
6. 30RQS 078
4
5
6
Water flow rate, l/s
1. 30RQS 080
2. 30RQS 090
3. 30RQS 100
4. 30RQS 120
5. 30RQS 140
200
190
180
170
160
150
140
130
120
110
100
90
80
70
60
50
0,0
High-pressure pump
1
0,5
1,0
1,5
2,0
2,5
3,0
3,5
Water flow rate, l/s
4,0
4,5
6
5,0
5,5
230
220
210
200
190
180
170
160
150
140
130
120
110
100
90
80
70
60
50
Legend
Legend
1. 30RQS 039
2. 30RQS 045
3. 30RQS 050
4. 30RQS 060
5. 30RQS 070
6. 30RQS 078
1. 30RQS 080
2. 30RQS 090
3. 30RQS 100
4. 30RQS 120
5. 30RQS 140
25
Operating logic
Curves, pump pressure head and power input/water flow rate (fixed speed)
2400
220
2200
200
160
140
C B
2000
1600
1800
180
120
100
80
60
1400
1200
1000
800
400
200
20
0
26
600
40
0
10
11
10
11
2 VWF system
The flow rate control uses the Pro-Dialog+ interface to
modify the rotational speed of the pump. The reduction in
consumption is more significant (20%) as both flow rate
and pressure at the pump outlet are affected.
Curves, pump pressure head and power input/water flow rate (with VWF)
220
2400
160
1800
140
120
100
50Hz
80
45Hz
60
40
1400
40Hz
1000
46Hz
800
35Hz
30Hz
25Hz
200
5
6
7
Water flow rate, l/s
45Hz
1200
400
25Hz
1600
600
40Hz
35Hz
30Hz
20
2000
46Hz
180
50Hz
2200
200
10
11
5
6
7
Water flow rate, l/s
10
11
Curves, pump pressure head and power input/water flow rate (fixed speed)
220
2400
200
180
2000
160
2200
D C
140
120
100
80
60
1600
1400
1200
1000
800
600
40
400
20
0
1800
200
0
10
11
10
11
27
2 VWF system
Constant unit outlet pressure control mode
- A = Flow rate/pressure at full load
- A = Flow rate/pressure at part load with two-way valves
220
Curves, pressure head and power input/water flow rate, pumps with VWF and constant pressure
2400
180
45Hz
140
1800
2000
46Hz
160
120
100
50Hz
80
45Hz
60
20
25Hz
1400
1200
1000
A
40Hz
46Hz
46Hz
800
35Hz
45Hz
45Hz
30Hz
400
35Hz
30Hz
45Hz
1600
600
40Hz
40
0
50Hz
2200
200
25Hz
200
7
10
11
10
11
Curves, pressure head and power input/water flow rate, pumps with VWF and constant delta T
220
2400
2000
46Hz
160
140
38Hz
120
80
1800
A
34Hz
50Hz
A'
45Hz
60
40
20
0
180
100
50Hz
2200
200
30Hz
25Hz
35Hz
1400
1000
800
400
200
7
10
11
1200
600
40Hz
45Hz
1600
40Hz
46Hz
46Hz
35Hz
A
A'
38Hz
38Hz
30Hz
34Hz
34Hz
25Hz
4
5
6
7
Water flow rate, l/s
10
11
VWF system
Pressure control
Delta T control
Full load
1720 W (100%)
1380 W (80%)
1380 W (80%)
Part load
1660 W (97%)
1250 W (73%)
760 W (44%)
VWF system
Pressure control
Delta T control
Full load
Part load
1380 W (80%)
1380 W (80%)
1720 W (100%)
1380 W (80%)
1720 W (100%)
580 W (34%)