Documente Academic
Documente Profesional
Documente Cultură
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Porsche - Copyright 2004-2006 - 12 Volt Resource LLC Page 2 of 51
Porsche 911 Carrera 1984-1985
FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS
gnition #1: RED/BLACK GNTON SWTCH HARNESS
gnition #2: N/A
gnition #3: N/A
Accessory: RED/YELLOW GNTON SWTCH HARNESS
Brake Light: BLACK/YELLOW (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: GREEN AT COL
Parking Lights: GRAY/BLACK (DR) & GRAY/RED (PS) (+) AT LGHT SWTCH *
Headlights:
Diesel Glow Plug:
Clutch Bypass Wire:
NOTES
Porsche 911 Carrera 1984-1985
FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm:
Dome
Lights/Superv:
BROWN (-) PASSENGER PN SWTCH
OEM Horn: BROWN/WHTE (-) STEERNG COLUMN HARNESS
Power Lock: ADD ACTUATORS N BOTH DOORS **
Power Unlock: ADD ACTUATORS N BOTH DOORS **
Trunk Release:
Alarm nput Wire: BROWN (-) PASSENGER PN SWTCH
NOTES * Split Parking Light System - must use relays to isolate the circuits from each other. **
See Note #204 - Adding Actuators Door Lock Diagram.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Porsche - Copyright 2004-2006 - 12 Volt Resource LLC Page 3 of 51
924 1987
KEY T-HARNESS MMOBLZER
N/A N/A N/A
FUNCTON COLOR LOCATON
12 VOLT CONSTANT RED (+) GNTON SWTCH HARNESS
STARTER RED/BLACK (+) GNTON SWTCH HARNESS
STARTER 2 N/A
GNTON 1 BLACK (+) GNTON SWTCH HARNESS
GNTON 2 N/A
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
BROWN (+) GNTON SWTCH HARNESS
ACCESSORY/HEATER
BLOWER 2
N/A
KEYSENSE N/A
PARKNG LGHTS ( - ) N/A
PARKNG LGHTS ( + )
GRAY/BLACK (+) and
GRAY/PURPLE (+) Use both,
See NOTE *1
@ FUSE PANEL, See
DAGRAM
POWER LOCK
ADD ACTUATORS, See NOTE
*2
TO BOTH DOORS,
POWER UNLOCK
ADD ACTUATORS, See NOTE
*2
TO BOTH DOORS,
DOOR TRGGER BROWN/YELLOW (-) N DRVERS KCK PANEL
DOMELGHT SUPERVSON USE DOOR TRGGER
TRUNK RELEASE N/A
SLDNG POWER DOOR N/A
HORN N/A
TACH N/A
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Porsche - Copyright 2004-2006 - 12 Volt Resource LLC Page 24 of 51
WAT TO START LGHT N/A
BRAKE N/A
FACTORY ALARM DSARM N/A
ANT-THEFT N/A
EXTRA NFORMATON
NOTE *1 this vehicle uses a 2-Wire PARKNG LGHT Circuit and will require (2) extra Relays Part
#775 to connect, . NOTE *2 to add KEYLESS ENRTY to this vehicle will require the adding of DOOR
LOCK ACTUATORS Part #742 to each Door, to connect, .
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Porsche - Copyright 2004-2006 - 12 Volt Resource LLC Page 25 of 51
Make: Model: Year:
Porsche 928 1979-1984
FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS
gnition #1: BLACK GNTON SWTCH HARNESS
gnition #2: BLACK/RED GNTON SWTCH HARNESS
gnition #3:
Accessory:
Brake Light: N/A
Tach Signal:
BLACK OR VOLET @
COL
OR GREEN @ GNTON MOD. OR DASH
TACH
Parking Lights: GRAY/BLACK (DR) & GRAY/RED (PS) (+) AT LGHT SWTCH *
Headlights:
Diesel Glow Plug:
Clutch Bypass Wire:
NOTES
Porsche 928 1979-1984
FUNCTON COLOR LOCATON
Constant +12 Volts: RED AND RED GNTON SWTCH HARNESS
OEM Alarm Disarm:
Dome
Lights/Superv:
BROWN/WHTE (-) AT PN SWTCH OR COURTESY LGHT
OEM Horn:
Power Lock: ADD ACTUATORS N BOTH DOORS **
Power Unlock: ADD ACTUATORS N BOTH DOORS **
Trunk Release:
Alarm nput Wire: BROWN/WHTE (-) AT PN SWTCH OR COURTESY LGHT
NOTES * Split Parking Light System - must use relays to isolate the circuits from each other. **
See Note #204 - Adding Actuators Door Lock Diagram.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Porsche - Copyright 2004-2006 - 12 Volt Resource LLC Page 26 of 51
Make: Model: Year:
Porsche 928 1985-1986
FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS
gnition #1: BLACK GNTON SWTCH HARNESS
gnition #2: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #3:
Accessory:
Brake Light:
Tach Signal:
BLACK/VOLET AT
ENGNE
CONTROL MODULE OR GREEN AT DASH
TACH
Parking Lights: GRAY/BLACK (DR) & GRAY/RED (PS) (+) AT LGHT SWTCH *
Headlights:
Diesel Glow Plug:
Clutch Bypass Wire:
NOTES
Porsche 928 1985-1986
FUNCTON COLOR LOCATON
Constant +12 Volts: RED AND RED GNTON SWTCH HARNESS
OEM Alarm Disarm:
Dome
Lights/Superv:
BROWN/WHTE (-) AT PN SWTCH OR COURTESY LGHT
OEM Horn: BLACK/YELLOW (+) AT HORN
Power Lock: BRN/RED OR GRN/BLK DRVER'S KCK PANEL **
Power Unlock: BRN/GRN OR YELLOW DRVER'S KCK PANEL **
Trunk Release:
Alarm nput Wire: BROWN/WHTE (-) AT PN SWTCH OR COURTESY LGHT
NOTES * Split Parking Light System - must use relays to isolate the circuits from each other. **
See Note #201 - Negative Pulse Door Lock Diagram.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Porsche - Copyright 2004-2006 - 12 Volt Resource LLC Page 27 of 51
928 1987
KEY T-HARNESS MMOBLZER
N/A N/A N/A
FUNCTON COLOR LOCATON
12 VOLT CONSTANT RED (+) GNTON SWTCH HARNESS
STARTER YELLOW(+) GNTON SWTCH HARNESS
STARTER 2 N/A
GNTON 1 BLACK (+) GNTON SWTCH HARNESS
GNTON 2 N/A
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
BLUE (+) GNTON SWTCH HARNESS
ACCESSORY/HEATER
BLOWER 2
N/A
KEYSENSE N/A
PARKNG LGHTS ( - ) N/A
PARKNG LGHTS ( + )
GRAY/RED (+) and
GRAY/BLACK (+) use both, See
NOTE *1
@ HEADLGHT SWTCH,
POWER LOCK GREEN/BLACK (TYPE B) N DRVERS KCK PANEL
POWER UNLOCK YELLOW (TYPE B) N DRVERS KCK PANEL
DOOR TRGGER BROWN/WHTE (-) N DRVERS KCK PANEL
DOMELGHT SUPERVSON USE DOOR TRGGER
TRUNK RELEASE N/A
SLDNG POWER DOOR N/A
HORN N/A
TACH N/A
WAT TO START LGHT N/A
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Porsche - Copyright 2004-2006 - 12 Volt Resource LLC Page 28 of 51
BRAKE BLACK/RED (+)
@ CRUSE CONTROL
MODULE, UNDER
PASSENGER SEAT
FACTORY ALARM DSARM N/A
ANT-THEFT N/A
EXTRA NFORMATON
NOTE *1 this vehicle uses a 2-Wire PARKNG LGHT Circuit and will require (2) extra Relays Part
#775 to connect, .
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Porsche - Copyright 2004-2006 - 12 Volt Resource LLC Page 29 of 51
928 1988
KEY T-HARNESS MMOBLZER
N/A N/A N/A
FUNCTON COLOR LOCATON
12 VOLT CONSTANT RED (+) GNTON SWTCH HARNESS
STARTER YELLOW(+) GNTON SWTCH HARNESS
STARTER 2 N/A
GNTON 1 BLACK (+) GNTON SWTCH HARNESS
GNTON 2 N/A
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
BROWN/WHTE (+) GNTON SWTCH HARNESS
ACCESSORY/HEATER
BLOWER 2
N/A
KEYSENSE N/A
PARKNG LGHTS ( - ) N/A
PARKNG LGHTS ( + )
GRAY/RED (+) and
GRAY/BLACK (+) use both, See
NOTE *1
@ HEADLGHT SWTCH,
POWER LOCK RED (TYPE B) N DRVERS KCK PANEL
POWER UNLOCK LGHT GREEN (TYPE B) N DRVERS KCK PANEL
DOOR TRGGER BROWN/WHTE (-) N DRVERS KCK PANEL
DOMELGHT SUPERVSON USE DOOR TRGGER
TRUNK RELEASE N/A
SLDNG POWER DOOR N/A
HORN N/A
TACH N/A
WAT TO START LGHT N/A
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Porsche - Copyright 2004-2006 - 12 Volt Resource LLC Page 30 of 51
BRAKE BLACK/RED (+)
@ SWTCH ABOVE BRAKE
PEDAL
FACTORY ALARM DSARM N/A
ANT-THEFT N/A
EXTRA NFORMATON
NOTE *1 this vehicle uses a 2-Wire PARKNG LGHT Circuit and will require (2) extra Relays Part
#775 to connect, .
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Porsche - Copyright 2004-2006 - 12 Volt Resource LLC Page 31 of 51
968 1992
KEY T-HARNESS MMOBLZER
N/A N/A N/A
FUNCTON COLOR LOCATON
12 VOLT CONSTANT RED (+) GNTON SWTCH HARNESS
STARTER RED/BLACK (+) GNTON SWTCH HARNESS
STARTER 2 N/A
GNTON 1 BLACK (+) GNTON SWTCH HARNESS
GNTON 2 N/A
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
BLACK/YELLOW (+) GNTON SWTCH HARNESS
ACCESSORY/HEATER
BLOWER 2
BLACK/YELLOW (+) GNTON SWTCH HARNESS
KEYSENSE N/A
PARKNG LGHTS ( - ) N/A
PARKNG LGHTS ( + )
GRAY/RED (+) and
GRAY/BLACK (+) use both, See
NOTE *1
@ HEADLGHT SWTCH,
POWER LOCK BROWN/WHTE (TYPE B) N DRVERS KCK PANEL
POWER UNLOCK BROWN/RED (TYPE B) N DRVERS KCK PANEL
DOOR TRGGER BROWN/YELLOW (-) N DRVERS KCK PANEL
DOMELGHT SUPERVSON USE DOOR TRGGER
TRUNK RELEASE N/A
SLDNG POWER DOOR N/A
HORN N/A
TACH BLACK @ GNTON COL
WAT TO START LGHT N/A
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Porsche - Copyright 2004-2006 - 12 Volt Resource LLC Page 43 of 51
BRAKE RED/WHTE (+)
@ SWTCH ABOVE BRAKE
PEDAL
FACTORY ALARM DSARM N/A
ANT-THEFT N/A
EXTRA NFORMATON
NOTE *1 this vehicle uses a 2-Wire PARKNG LGHT Circuit and will require (2) extra Relays Part
#775 to connect, .
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Porsche - Copyright 2004-2006 - 12 Volt Resource LLC Page 44 of 51
968 1993
KEY T-HARNESS MMOBLZER
N/A N/A N/A
FUNCTON COLOR LOCATON
12 VOLT CONSTANT Connect to BATTERY
STARTER RED/BLACK (+) GNTON SWTCH HARNESS
STARTER 2 N/A
GNTON 1 BLACK (+) GNTON SWTCH HARNESS
GNTON 2 N/A
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
N/A
ACCESSORY/HEATER
BLOWER 2
N/A
KEYSENSE N/A
PARKNG LGHTS ( - ) N/A
PARKNG LGHTS ( + )
GRAY/RED (+) and
GRAY/BLACK (+) use both, See
NOTE *1
@ HEADLGHT SWTCH,
POWER LOCK BROWN/GREEN (TYPE B) N DRVERS KCK PANEL
POWER UNLOCK BROWN/RED (TYPE B) N DRVERS KCK PANEL
DOOR TRGGER BROWN/GREEN (-) N DRVERS KCK PANEL
DOMELGHT SUPERVSON USE DOOR TRGGER
TRUNK RELEASE RED/WHTE (+) @ TRUNK RELEASE SWTCH
SLDNG POWER DOOR N/A
HORN N/A
TACH N/A
WAT TO START LGHT N/A
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Porsche - Copyright 2004-2006 - 12 Volt Resource LLC Page 45 of 51
BRAKE N/A
FACTORY ALARM DSARM N/A
ANT-THEFT N/A
EXTRA NFORMATON
NOTE *1 this vehicle uses a 2-Wire PARKNG LGHT Circuit and will require (2) extra Relays Part
#775 to connect, .
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Porsche - Copyright 2004-2006 - 12 Volt Resource LLC Page 46 of 51