Sunteți pe pagina 1din 60

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws.

f you acquired this


document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Subaru - Copyright 2004-2006 - 12 Volt Resource LLC Page 1 of 60




Subaru Securty, Remote Start, Keyess Entry & Navgaton
Wre Coors Verson 4.2









PLEASE NOTE

The information contained is accurate to the best of our knowledge. 12 Volt Resource LLC
makes no representation or warranty with respect to the information contained in this
document including its accuracy or completeness. 12 Volt Resource LLC disclaims all
liability or responsibility for errors or omissions therein or any decision made by the
recipient in reliance thereon.

nstallations should be attempted by experienced installers only. Proper installation
remains the responsibility of the installer. t is the installer's responsibility to test and verify
all circuitry with the proper test equipment prior to installation.


Additional nformation:

This information is sorted alphabetically by vehicle model. f there are multiple
years for a particular vehicle model, then the oldest year comes first.

The installation notes referenced below and the full installation guide are located
in the nstall nstructions & Notes folder on this CD-ROM.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Subaru - Copyright 2004-2006 - 12 Volt Resource LLC Page 2 of 60

Subaru 1600 1982-1983

FUNCTON COLOR LOCATON
Start: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #1: BLACK GNTON SWTCH HARNESS
gnition #2:
gnition #3:
Accessory:
Brake Light: GREEN (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal:
Parking Lights: RED (+) AT LGHT SWTCH
Headlights:
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES:

Subaru 1600 1982-1983

FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE GNTON SWTCH HARNESS
OEM Alarm Disarm:
Dome
Lights/Superv:
BLACK/RED (-) NSTR. PANEL HARN. OR DOME LGHT
OEM Horn:
Power Lock: ADD ACTUATORS N ALL DOORS **
Power Unlock: ADD ACTUATORS N ALL DOORS **
Trunk Release:
Alarm nput Wire: BLACK/RED (-) NSTR. PANEL HARN. OR DOME LGHT

NOTES: ** See Note #204 - Adding Actutor Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Subaru - Copyright 2004-2006 - 12 Volt Resource LLC Page 3 of 60

Subaru 1800 1982-1983

FUNCTON COLOR LOCATON
Start: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #1: BLACK GNTON SWTCH HARNESS
gnition #2:
gnition #3:
Accessory:
Brake Light: GREEN (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal:
Parking Lights: RED (+) AT LGHT SWTCH
Headlights:
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES:

Subaru 1800 1982-1983

FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE GNTON SWTCH HARNESS
OEM Alarm Disarm:
Dome
Lights/Superv:
BLACK/RED (-) NSTR. PANEL HARN. OR DOME LGHT
OEM Horn:
Power Lock: ADD ACTUATORS N ALL DOORS **
Power Unlock: ADD ACTUATORS N ALL DOORS **
Trunk Release:
Alarm nput Wire: BLACK/RED (-) NSTR. PANEL HARN. OR DOME LGHT

NOTES: ** See Note #204 - Adding Actutor Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Subaru - Copyright 2004-2006 - 12 Volt Resource LLC Page 4 of 60

Make: Model: Year:
Subaru 1800 Turbo 1983-1984


FUNCTON COLOR LOCATON
Start: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #1: BLACK GNTON SWTCH HARNESS
gnition #2: BLUE GNTON SWTCH HARNESS
gnition #3:
Accessory:
Brake Light: GREEN (-) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: YELLOW AT COL OR AT DASH TACHOMETER
Parking Lights: RED (+) AT LGHT SWTCH
Headlights:
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES:

Subaru 1800 Turbo 1983-1984

FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE GNTON SWTCH HARNESS
OEM Alarm Disarm:
Dome
Lights/Superv:
BLACK/RED (-) NSTR. PANEL HARNESS OR DOME LGHT
OEM Horn:
Power Lock: ADD ACTUATORS N ALL DOORS **
Power Unlock: ADD ACTUATORS N ALL DOORS **
Trunk Release:
Alarm nput Wire: BLACK/RED (-) NSTR. PANEL HARNESS OR DOME LGHT

NOTES: ** See Note #204 - Adding Actuator Door Lock Diagram.



This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Subaru - Copyright 2004-2006 - 12 Volt Resource LLC Page 5 of 60

B9 TRIBECA 2006

KEY
T-
HARNES
S
MMOBLZER
N/A N/A
SUBARU'S TRANSPONDER ANT-THEFT SYSTEM, REQURES BYPASS and
EXTRA GNTON KEY

FUNCTON COLOR LOCATON
12 VOLT CONSTANT WHTE (+)
@ GNTON SWTCH
HARNESS
STARTER WHTE/BLACK (+)
@ GNTON SWTCH
HARNESS
STARTER 2 N/A
GNTON 1 GREEN (+)
@ GNTON SWTCH
HARNESS
GNTON 2 BLUE (+)
@ GNTON SWTCH
HARNESS
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
YELLOW (+)
@ GNTON SWTCH
HARNESS
ACCESSORY/HEATER
BLOWER 2
N/A
KEYSENSE N/A
PARKNG LGHTS ( - ) BLACK/WHTE (-)
@ COMBNATON LGHT
SWTCH
PARKNG LGHTS ( + )
WHTE/GREEN (+) or ORANGE
(+)
@ PARKNG LGHT SWTCH
POWER LOCK BROWN/WHTE (TYPE B)
N DRVERS KCK PANEL or
BU, 35-Pin Plug, Pin 15, See
NOTE *1
POWER UNLOCK BROWN/BLACK (TYPE B)
N DRVERS KCK PANEL or
BU, 35-Pin Plug, Pin 29, See
NOTE *1

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Subaru - Copyright 2004-2006 - 12 Volt Resource LLC Page 6 of 60

DOOR TRGGER See NOTE *2


@ BU, 35-Pin Plug, See NOTE
*1
DOMELGHT SUPERVSON BROWN (-)
N DRVERS KCK PANEL or
BU, 30-Pin Plug, Pin 3, See
NOTE *1
TRUNK RELEASE
GREEN/RED to YELLOW (-)
See NOTE *3
N DRVERS KCK PANEL or
BU, 28-Pin Plug, Pin 22, See
NOTE *1
SLDNG POWER DOOR N/A
HORN RED to RED/WHTE (-)
@ HORN SWTCH or BU, 30-
Pin Plug, Pin 11, See NOTE *1
TACH PNK to RED/WHTE
@ ECM, 35-Pin Plug, Pin 22,
See NOTE *4
WAT TO START LGHT N/A
BRAKE BROWN/WHTE (+)
@ SWTCH above BRAKE
PEDAL
FACTORY ALARM DSARM
DSARMS with FACTORY
REMOTE ONLY!!!

ANT-THEFT
TRANSPONDER ANT-THEFT
SYSTEM, REQURES BYPASS
and EXTRA GNTON KEY
@ GNTON SWTCH
TUMBLER

EXTRA NFORMATON
NOTE *1 the BU (Body ntegrated Unit) is to the RGHT of the Steering Column. NOTE *2 the
DRVERS DOOR TRGGER is a BLUE/WHTE (-) at Pin 19, the PASSENGER DOOR TRGGER is a
BLUE/ORANGE (-) at Pin 32, the DRVERS REAR DOOR TRGGER is a YELLOW/RED (-) at Pin 31
and the PASSENGER REAR DOOR TRGGER is a WHTE/GREEN (-) at Pin 18. When connecting
to an Alarm System use all 4 wires and DODE SOLATE, NOTE *3 TEST this wire while opening the
rear hatch from the rear handle of the vehicle. NOTE *4 the ECM (Engine Control Module) is located
below the GLOVE BOX, under the carpet


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Subaru - Copyright 2004-2006 - 12 Volt Resource LLC Page 7 of 60

Make: Model: Year:
Subaru Baja 2003-2006


FUNCTON COLOR LOCATON
Start: White/Black (+) gnition switch harness
gnition #1: Green (+) gnition switch harness
gnition #2: N/A gnition switch harness
gnition #3: N/A gnition switch harness
Accessory: Yellow (+) gnition switch harness
Brake Light: White/Black (+) Brake pedal switch
Tach Signal: Orange/White (AC) ECM below glove box
Parking Lights: White/Green or Orange
(+)
Parking light switch
Headlights: N/A
Diesel Glow Plug: N/A
Clutch Bypass Wire: N/A

NOTES:

Subaru Baja 2003-2006

FUNCTON COLOR LOCATON
Constant +12 Volts: White (+) gnition switch harness
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
White/Red (-) Blue plug at integrated module
OEM Horn: Red/Green (-) Steering column harness
Power Lock: White (-) Gray plug at integrated module*
Power Unlock: Green/Red (-) Gray plug at integrated module*
Trunk Release: N/A
Alarm nput Wire: White/Red (-) Blue plug at integrated module

NOTES: *The integrated module is to the left of the steering column. See Note #201 Negative
Trigger Door Locks


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Subaru - Copyright 2004-2006 - 12 Volt Resource LLC Page 8 of 60

Make: Model: Year:
Subaru Brat 1984-1985


FUNCTON COLOR LOCATON
Start: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #1: BLACK GNTON SWTCH HARNESS
gnition #2: N/A
gnition #3: N/A
Accessory: BLUE GNTON SWTCH HARNESS
Brake Light: GREEN (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: YELLOW AT COL *
Parking Lights: RED OR RED/BLUE (+) AT LGHT SWTCH
Headlights:
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Carburated Engine.

Subaru Brat 1984-1985

FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE GNTON SWTCH HARNESS
OEM Alarm Disarm:
Dome
Lights/Superv:
BLACK/RED (-) NSTR. PANEL HARNESS OR DOME LGHT
OEM Horn:
Power Lock: ADD ACTUATORS N ALL DOORS **
Power Unlock: ADD ACTUATORS N ALL DOORS **
Trunk Release:
Alarm nput Wire: BLACK/RED (-) NSTR. PANEL HARNESS OR DOME LGHT

NOTES: ** See Note #204 - Adding Actuator Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Subaru - Copyright 2004-2006 - 12 Volt Resource LLC Page 9 of 60

Make: Model: Year:
Subaru Brat 1986-1987


FUNCTON COLOR LOCATON
Start: BLACK/WHTE GNTON SWTCH HARNESS
gnition #1: BLACK GNTON SWTCH HARNESS
gnition #2:
gnition #3:
Accessory: BLUE GNTON SWTCH HARNESS (HEAT/AC)
Brake Light: GREEN/BLACK (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: YELLOW AT COL *
Parking Lights: RED OR RED/BLACK (+) AT LGHT SWTCH OR AT FUSE BOX
Headlights:
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Carburated Engine.

Subaru Brat 1986-1987

FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE GNTON SWTCH HARNESS
OEM Alarm Disarm:
Dome
Lights/Superv:
BLACK/RED (-) NSTR. PANEL HARNESS OR DOME LGHT
OEM Horn:
Power Lock: ADD ACTUATORS N ALL DOORS **
Power Unlock: ADD ACTUATORS N ALL DOORS **
Trunk Release:
Alarm nput Wire: BLACK/RED (-) NSTR. PANEL HARNESS OR DOME LGHT

NOTES: ** See Note #204 - Adding Actuator Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Subaru - Copyright 2004-2006 - 12 Volt Resource LLC Page 10 of 60

Make: Model: Year:
Subaru Coupe 1987-1989


FUNCTON COLOR LOCATON
Start: BLACK/WHTE OR BLACK/YELLOW - GNTON SWTCH
HARN.
gnition #1: BLACK GNTON SWTCH HARNESS
gnition #2: YELLOW/BLUE GEAR SELECT SWTCH *
gnition #3:
Accessory:
Brake Light: GREEN/BLACK(+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: YELLOW AT COL, DSTRBUTOR OR DASH TACH.
Parking Lights: RED OR RED/BLACK (+) AT LGHT SWTCH OR AT FUSE BOX
Headlights:
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Some Models Carburated.

Subaru Coupe 1987-1989

FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE GNTON SWTCH HARNESS
OEM Alarm Disarm:
Dome
Lights/Superv:
BLACK/RED (-) NSTR. PANEL HARNESS OR DOME LGHT
OEM Horn:
Power Lock: ADD ACTUATORS N ALL DOORS **
Power Unlock: ADD ACTUATORS N ALL DOORS **
Trunk Release:
Alarm nput Wire: BLACK/RED (-) NSTR. PANEL HARNESS OR DOME LGHT

NOTES: ** See Note #204 - Adding Actuator Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Subaru - Copyright 2004-2006 - 12 Volt Resource LLC Page 11 of 60

Make: Model: Year:
Subaru DL 1984


FUNCTON COLOR LOCATON
Start: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #1: BLACK GNTON SWTCH HARNESS
gnition #2: N/A
gnition #3: N/A
Accessory: BLUE GNTON SWTCH HARNESS
Brake Light: GREEN (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: YELLOW AT COL *
Parking Lights: RED/BLUE (+) AT LGHT SWTCH
Headlights:
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Carburated Engine.

Subaru DL 1984

FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE GNTON SWTCH HARNESS
OEM Alarm Disarm:
Dome
Lights/Superv:
BLACK/RED (-) NSTR. PANEL HARNESS OR DOME LGHT
OEM Horn:
Power Lock: ADD ACTUATORS N ALL DOORS **
Power Unlock: ADD ACTUATORS N ALL DOORS **
Trunk Release:
Alarm nput Wire: BLACK/RED (-) NSTR. PANEL HARNESS OR DOME LGHT

NOTES: ** See Note #204 - Adding Actuator Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Subaru - Copyright 2004-2006 - 12 Volt Resource LLC Page 12 of 60

Make: Model: Year:
Subaru Forester 1998-2002


FUNCTON COLOR LOCATON
Start: WHTE/BLACK GNTON SWTCH HARNESS
gnition #1: YELLOW GNTON SWTCH HARNESS
gnition #2: GREEN/ORANGE GNTON SWTCH HARNESS
gnition #3:
Accessory: GREEN
Brake Light: WHTE/BLACK AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: BLUE N 3 PN PLUG AT GNTON COL
Parking Lights: PURPLE 10 PN WHTE CONN. N DRVER'S KCK
Headlights:
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES:

Subaru Forester 1998-2002

FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE GNTON SWTCH HARNESS
OEM Alarm Disarm:
Dome
Lights/Superv:
YELLOW (-) BLUE 28 PN CONN. ABOVE STEERNG
COL.
OEM Horn: GREEN/RED (-) STEERNG COLUMN HARNESS
Power Lock: RED/WHTE (-) N 10 PN CONN. N DRVER'S KCK *
Power Unlock: YELLOW/RED (-) N 10 PN CONN. N DRVER'S KCK *
Trunk Release:
Alarm nput Wire: YELLOW (-) BLUE 28 PN CONN. ABOVE STEERNG
COL.

NOTES: * See Note #201 - Negative Pulse Door Lock Diagram. The Wires Should Be Located At
The Key


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Subaru - Copyright 2004-2006 - 12 Volt Resource LLC Page 13 of 60

Make: Model: Year:
Subaru Forester 2003-2006


FUNCTON COLOR LOCATON
Start: White/Blue (+) gnition switch harness
gnition #1: Green (+) gnition switch harness
gnition #2: N/A gnition switch harness
gnition #3: N/A gnition switch harness
Accessory: Yellow (+) gnition switch harness
Brake Light: White/Black (+) Brake pedal switch
Tach Signal: Green (AC) Plug at ECM*
Parking Lights: Black/Red or Orange (+) Parking light switch
Headlights: N/A
Diesel Glow Plug: N/A
Clutch Bypass Wire: N/A

NOTES: *The Engine Control Module (ECM) is below the glove box. The tach wire is also found
behind the intrument cluster in the middle plug.

Subaru Forester 2003-2006

FUNCTON COLOR LOCATON
Constant +12 Volts: White (+) gnition switch harness
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
Yellow (-) Gray plug at integrated module**
OEM Horn: Red/Green (-) Steering column harness
Power Lock: Red/White (-) Gray plug at integrated module**
Power Unlock: Yellow/Red (-) Gray plug at integrated module**
Trunk Release: N/A
Alarm nput Wire: Yellow (-) Gray plug at integrated module**

NOTES: **The integrated module is to the left of the steering column. See Note #201 Negative
Trigger Door Locks


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Subaru - Copyright 2004-2006 - 12 Volt Resource LLC Page 14 of 60

Make: Model: Year:
Subaru GeneraI - AII ModeIs 1979


FUNCTON COLOR LOCATON
Start: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #1: BLACK GNTON SWTCH HARNESS
gnition #2:
gnition #3:
Accessory:
Brake Light: GREEN OR
GREEN/BLACK(+
AT SWTCH ABOVE BRAKE PEDAL
Tach Signal:
Parking Lights: RED (+) AT LGHT SWTCH OR AT FUSE BOX
Headlights:
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES:

Subaru GeneraI - AII ModeIs 1979

FUNCTON COLOR LOCATON
Constant +12 Volts: GREEN GNTON SWTCH HARNESS
OEM Alarm Disarm:
Dome
Lights/Superv:
RED/YELLOW (-) AT PN SWTCH OR AT DOME LGHT
OEM Horn:
Power Lock: ADD ACTUATORS N ALL DOORS *
Power Unlock: ADD ACTUATORS N ALL DOORS *
Trunk Release:
Alarm nput Wire: RED/YELLOW (-) AT PN SWTCH OR AT DOME LGHT

NOTES: * See Note #204 - Adding Actuator Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Subaru - Copyright 2004-2006 - 12 Volt Resource LLC Page 15 of 60

Make: Model: Year:
Subaru GeneraI - AII ModeIs 1980-1981


FUNCTON COLOR LOCATON
Start: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #1: BLACK/RED OR BLACK GNTON SWTCH HARNESS
gnition #2:
gnition #3:
Accessory:
Brake Light: GREEN OR
GREEN/BLACK(+
AT SWTCH ABOVE BRAKE PEDAL
Tach Signal:
Parking Lights: RED (+) AT LGHT SWTCH OR AT FUSE BOX
Headlights:
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES:

Subaru GeneraI - AII ModeIs 1980-1981

FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE GNTON SWTCH HARNESS
OEM Alarm Disarm:
Dome
Lights/Superv:
BLACK/RED (-) AT
NSTR
PANEL HARN OR GREEN/YELLOW AT
LGHT
OEM Horn:
Power Lock: ADD ACTUATORS N ALL DOORS *
Power Unlock: ADD ACTUATORS N ALL DOORS *
Trunk Release:
Alarm nput Wire: BLACK/RED (-) AT
NSTR
PANEL HARN OR GREEN/YELLOW AT
LGHT

NOTES: *See Note #204 - Adding Actuator Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Subaru - Copyright 2004-2006 - 12 Volt Resource LLC Page 16 of 60

Make: Model: Year:
Subaru GL 1984


FUNCTON COLOR LOCATON
Start: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #1: BLACK GNTON SWTCH HARNESS
gnition #2: N/A
gnition #3: N/A
Accessory: BLUE GNTON SWTCH HARNESS
Brake Light: GREEN (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: YELLOW AT COL *
Parking Lights: RED/BLUE (+) AT LGHT SWTCH
Headlights:
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Carburated Engine.

Subaru GL 1984

FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE GNTON SWTCH HARNESS
OEM Alarm Disarm:
Dome
Lights/Superv:
BLACK/RED (-) NSTR. PANEL HARNESS OR DOME LGHT
OEM Horn:
Power Lock: ADD ACTUATORS N ALL DOORS **
Power Unlock: ADD ACTUATORS N ALL DOORS **
Trunk Release:
Alarm nput Wire: BLACK/RED (-) NSTR. PANEL HARNESS OR DOME LGHT

NOTES: ** See Note #204 - Adding Actuator Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Subaru - Copyright 2004-2006 - 12 Volt Resource LLC Page 17 of 60

Make: Model: Year:
Subaru Hatchback 1985


FUNCTON COLOR LOCATON
Start: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #1: BLACK GNTON SWTCH HARNESS
gnition #2: N/A
gnition #3: N/A
Accessory: BLUE GNTON SWTCH HARNESS
Brake Light: GREEN (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: YELLOW AT COL *
Parking Lights: RED OR RED/BLUE (+) AT LGHT SWTCH
Headlights:
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Carburated Engine.

Subaru Hatchback 1985

FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE GNTON SWTCH HARNESS
OEM Alarm Disarm:
Dome
Lights/Superv:
BLACK/RED (-) NSTR. PANEL HARNESS OR COME LGHT
OEM Horn:
Power Lock: ADD ACTUATORS N ALL DOORS **
Power Unlock: ADD ACTUATORS N ALL DOORS **
Trunk Release:
Alarm nput Wire: BLACK/RED (-) NSTR. PANEL HARNESS OR COME LGHT

NOTES: ** See Note #204 - Adding Actuator Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Subaru - Copyright 2004-2006 - 12 Volt Resource LLC Page 18 of 60

Make: Model: Year:
Subaru Hatchback 1986-1988


FUNCTON COLOR LOCATON
Start: BLACK/WHTE OR BLACK/YELLOW - GNTON SW. HARNESS
gnition #1: BLACK GNTON SWTCH HARNESS
gnition #2: BLUE GNTON SWTCH HARNESS *
gnition #3:
Accessory:
Brake Light: GREEN/BLACK AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: YELLOW AT COL, DSTRBUTOR OR DASH TACH
Parking Lights: RED OR RED/BLACK (+) AT LGHT SWTCH OR FUSE BOX
Headlights:
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Some Models Are Carburated.

Subaru Hatchback 1986-1988

FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE GNTON SWTCH HARNESS
OEM Alarm Disarm:
Dome
Lights/Superv:
BLACK/RED (-) NSTR. PANEL HARNESS OR DOME LGHT
OEM Horn:
Power Lock: ADD ACTUATORS N ALL DOORS **
Power Unlock: ADD ACTUATORS N ALL DOORS **
Trunk Release:
Alarm nput Wire: BLACK/RED (-) NSTR. PANEL HARNESS OR DOME LGHT

NOTES: ** See Note #204 - Adding Actuator Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Subaru - Copyright 2004-2006 - 12 Volt Resource LLC Page 19 of 60

Make: Model: Year:
Subaru Impreza 1993-1994


FUNCTON COLOR LOCATON
Start: BLUE/RED GNTON SWTCH HARNESS
gnition #1: RED GNTON SWTCH HARNESS
gnition #2: RED/YELLOW GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: RED/YELLOW GNTON SWTCH HARNESS
Brake Light: WHTE/BLACK (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: RED PN 4 ON ECM BEHND CENTER OF DASH
Parking Lights: RED (+) AT FUSE BOX
Headlights: BLUE/BLACK (-) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES:

Subaru Impreza 1993-1994

FUNCTON COLOR LOCATON
Constant +12 Volts: BLACK GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
YELLOW (-) AT DOME LGHT
OEM Horn: RED/GREEN (-) STEERNG COLUMN HARNESS
Power Lock: ADD ACTUATOR N DRVER'S DOOR *
Power Unlock: ADD ACTUATOR N DRVER'S DOOR *
Trunk Release: N/A
Alarm nput Wire: YELLOW (-) AT DOME LGHT

NOTES: * See Note #204 - Adding Actuator Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Subaru - Copyright 2004-2006 - 12 Volt Resource LLC Page 20 of 60

Make: Model: Year:
Subaru Impreza 1995


FUNCTON COLOR LOCATON
Start: BLUE/RED GNTON SWTCH HARNESS
gnition #1: RED GNTON SWTCH HARNESS
gnition #2: RED/YELLOW GNTON SWTCH HARNESS
gnition #3:
Accessory:
Brake Light: WHTE/BLACK (+) OR
GRN
AT SWTCH ABOVE BRAKE PEDAL(OR
GRN/BLK
Tach Signal: BLK/BLUE
26 PN CONN. AT ECM UNDER PASS.
FLOOR
Parking Lights: GREEN/RED (+) PASSENGER SDE OF STEERNG
COLUMN
Headlights:
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES:

Subaru Impreza 1995

FUNCTON COLOR LOCATON
Constant +12 Volts: BLACK/YELLOW GNTON SWTCH HARNESS
OEM Alarm Disarm:
Dome
Lights/Superv:
YELLOW PN 16 N BLUE 18 PN CONN/DRV DASH
OEM Horn:
Power Lock: *
Power Unlock: *
Trunk Release:
Alarm nput Wire: YELLOW PN 16 N BLUE 18 PN CONN/DRV DASH

NOTES: *For Door Locks See Note #204 Adding Door Lock Actuators.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Subaru - Copyright 2004-2006 - 12 Volt Resource LLC Page 21 of 60

Make: Model: Year:
Subaru Impreza 1996-1997


FUNCTON COLOR LOCATON
Start: BLUE/RED GNTON SWTCH HARNESS
gnition #1: RED GNTON SWTCH HARNESS
gnition #2: N/A
gnition #3: N/A
Accessory: RED/YELLOW GNTON SWTCH HARNESS
Brake Light: WHTE/BLACK AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: BLUE AT GNTON COL*
Parking Lights: BLACK/YELLOW (+) HEADLGHT SWTCH
Headlights: BLUE/BLACK (-) HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * gnition coil is located on top of engine, can also be found at gnitor at center rear of
engine.

Subaru Impreza 1996-1997

FUNCTON COLOR LOCATON
Constant +12 Volts: BLACK/YELLOW GNTON SWTCH HARNESS
OEM Alarm Disarm:
Dome
Lights/Superv:
YELLOW (-) AT ANY DOOR PN SWTCH
OEM Horn:
Power Lock: ADD ACTUATOR N DRVER'S DOOR
Power Unlock: ADD ACTUATOR N DRVER'S DOOR
Trunk Release:
Alarm nput Wire: YELLOW (-) AT ANY DOOR PN SWTCH

NOTES: ** See Note #204 - Adding Actuators Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Subaru - Copyright 2004-2006 - 12 Volt Resource LLC Page 22 of 60

Make: Model: Year:
Subaru Impreza 1998-2001


FUNCTON COLOR LOCATON
Start: BLACK/WHTE GNTON SWTCH HANRESS
gnition #1: GREEN GNTON SWTCH HARNESS
gnition #2:
gnition #3:
Accessory: BLACK/BLUE GNTON SWTCH HARNESS
Brake Light: WHTE/BLACK AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: BLUE AT COL ON TOP OF ENGNE
Parking Lights: ORANGE (+) WHTE MOLEX FROM STEERNG COLUMN
Headlights:
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES:

Subaru Impreza 1998-2001

FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
YELLOW (-) PASSENGER KCK PANEL
OEM Horn:
Power Lock: BLUE/GREEN (-) DRVER'S KCK PANEL**
Power Unlock: YELLOW (-) DRVER'S KCK PANEL
Trunk Release: N/A
Alarm nput Wire: YELLOW (-) PASSENGER KCK PANEL

NOTES: **See Note #201 Negative Trigger Door Locks.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Subaru - Copyright 2004-2006 - 12 Volt Resource LLC Page 23 of 60

Make: Model: Year:
Subaru Impreza 2002


FUNCTON COLOR LOCATON
Start: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #1: BLACK GNTON SWTCH HARNESS
gnition #2: N/A
gnition #3: N/A
Accessory: BLACK/BLUE GNTON SWTCH HARNESS
Brake Light: WHTE/BLACK AT SWTCH ABOVE BRAKE PEDAL
Tach Signal:
Parking Lights: PURPLE (+) AT HEADLGHT SWTCH OR FUSE PANEL
Headlights:
Diesel Glow Plug: N/A
Clutch Bypass Wire:

NOTES:

Subaru Impreza 2002

FUNCTON COLOR LOCATON
Constant +12 Volts: BLACK/WHTE GNTON SWTCH HARNESS
OEM Alarm Disarm:
Dome
Lights/Superv:
YELLOW (-) AT KEYLESS ENTRY MODULE LEFT OF
STEERNG COLUMN
OEM Horn:
Power Lock: RED/WHTE (-) AT KEYLESS ENTRY MODULE LEFT OF
STEERNG COLUMN*
Power Unlock: YELLOW/RED (-) AT KEYLESS ENTRY MODULE LEFT OF
STEERNG COLUMN*
Trunk Release: N/A
Alarm nput Wire: YELLOW (-) AT KEYLESS ENTRY MODULE LEFT OF
STEERNG COLUMN

NOTES: *See Note #201 Negative Trigger Door Locks.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Subaru - Copyright 2004-2006 - 12 Volt Resource LLC Page 24 of 60

Make: Model: Year:
Subaru Impreza 2003-2006


FUNCTON COLOR LOCATON
Start: Black/Yellow to
White/Black (+)
gnition switch harness
gnition #1: Black to Green (+) gnition switch harness
gnition #2: N/A
gnition #3: N/A
Accessory: Black/Blue to Yellow (+) gnition switch harness
Brake Light: White/Black (+) Brake pedal switch
Tach Signal: Green (AC) nstrument cluster or ECM*
Parking Lights: Orange (+) Headlight switch
Headlights: N/A
Diesel Glow Plug: N/A
Clutch Bypass Wire: N/A

NOTES: *The Engine Control Module (ECM) is behind the passenger side dash.

Subaru Impreza 2003-2006

FUNCTON COLOR LOCATON
Constant +12 Volts: Black/White to White (+) gnition switch harness
OEM Alarm Disarm: Factory remote only
Dome
Lights/Superv:
Yellow (-) Keyless entry module**
OEM Horn: Red/Green (-) Steering column harness
Power Lock: Red/White (-) Keyless entry module**
Power Unlock: Yellow/Red (-) Keyless entry module**
Trunk Release: N/A
Alarm nput Wire: Yellow (-) Keyless entry module**

NOTES: **The keyless entry module is to the left of the steering column. See Note #201
Negative Trigger Door Locks.



This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Subaru - Copyright 2004-2006 - 12 Volt Resource LLC Page 25 of 60

IMPREZA OUTBACK 1996 -1997



KEY T-HARNESS MMOBLZER
N/A SUB-1 N/A

FUNCTON COLOR LOCATON
12 VOLT CONSTANT BLACK/YELLOW (+) GNTON SWTCH HARNESS
STARTER BLUE/RED (+) GNTON SWTCH HARNESS
STARTER 2 N/A
GNTON 1 RED (+) GNTON SWTCH HARNESS
GNTON 2 N/A
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
RED/YELLOW (+) GNTON SWTCH HARNESS
ACCESSORY/HEATER
BLOWER 2
N/A
KEYSENSE N/A
PARKNG LGHTS ( - ) BLACK/GREEN (-) @ HEADLGHT SWTCH
PARKNG LGHTS ( + ) RED/BLUE (+)
N GRAY CONNECTOR, NEAR
UNDER DASH LGHT
POWER LOCK
ADD ACTUATOR, See NOTE
*1
TO DRVERS DOOR ONLY,
POWER UNLOCK
ADD ACTUATOR, See NOTE
*1
TO DRVERS DOOR ONLY,
DOOR TRGGER RED/BLACK (-)
N BROWN CONNECTOR,
NEAR UNDER DASH LGHT
DOMELGHT SUPERVSON USE DOOR TRGGER
TRUNK RELEASE N/A
SLDNG POWER DOOR N/A
HORN RED/GREEN (-)
@ STEERNG COLUMN
HARNESS
TACH RED @ ECM, See NOTE *2
WAT TO START LGHT N/A
BRAKE WHTE/BLACK (+)
@ SWTCH ABOVE BRAKE
PEDAL
FACTORY ALARM DSARM N/A
ANT-THEFT N/A


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Subaru - Copyright 2004-2006 - 12 Volt Resource LLC Page 26 of 60

EXTRA NFORMATON
NOTE *1 this vehicle uses a CENTRAL DOOR LOCKNG SYSTEM, when connecting a KEYLESS
ENTRY, you will need to add a Door Lock Actuator part #742 in the Drivers Door Only!!, some units
will also require (2) extra relays, part #775, to complete the installation, to connect, NOTE *2 the
ECM (Electronic Control Module) is located BEHND the PASSENGER Side of the DASH, the tach
wire is RED at PN 64.



This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Subaru - Copyright 2004-2006 - 12 Volt Resource LLC Page 27 of 60

IMPREZA OUTBACK 1998 -1999



KEY T-HARNESS MMOBLZER
N/A SUB-1 N/A

FUNCTON COLOR LOCATON
12 VOLT CONSTANT WHTE (+) GNTON SWTCH HARNESS
STARTER WHTE/BLACK (+) GNTON SWTCH HARNESS
STARTER 2 N/A
GNTON 1 GREEN (+) GNTON SWTCH HARNESS
GNTON 2 N/A
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
YELLOW (+) GNTON SWTCH HARNESS
ACCESSORY/HEATER
BLOWER 2
N/A
KEYSENSE N/A
PARKNG LGHTS ( - ) BLACK/WHTE (-) @ HEADLGHT SWTCH
PARKNG LGHTS ( + ) RED/YELLOW (+) N DRVERS KCK PANEL
POWER LOCK BLUE/GREEN (TYPE B) N DRVERS KCK PANEL
POWER UNLOCK
YELLOW or YELLOW/RED
(TYPE B)
N DRVERS KCK PANEL
DOOR TRGGER YELLOW (-) @ PASSENGER PN SWTCH
DOMELGHT SUPERVSON USE DOOR TRGGER
TRUNK RELEASE N/A
SLDNG POWER DOOR N/A
HORN RED/GREEN (-)
@ STEERNG COLUMN
HARNESS
TACH BLUE @ GNTON COL
WAT TO START LGHT N/A
BRAKE WHTE/BLACK (+)
@ SWTCH ABOVE BRAKE
PEDAL
FACTORY ALARM DSARM N/A
ANT-THEFT N/A



This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Subaru - Copyright 2004-2006 - 12 Volt Resource LLC Page 28 of 60

Make: Model: Year:
Subaru Justy 1987-1993


FUNCTON COLOR LOCATON
Start: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #1: BLACK/WHTE GNTON SWTCH HARNESS
gnition #2: N/A
gnition #3: N/A
Accessory: BLUE GNTON SWTCH HARNESS
Brake Light: GREEN/BLACK (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: YELLOW/BLUE AT COL
Parking Lights: RED/YELLOW (+) AT LGHT SWTCH
Headlights: RED/YELLOW (LO) (+)
OR
RED/WHTE (H) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES:

Subaru Justy 1987-1993

FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
BLACK (-) AT PN SWTCH
OEM Horn: GREEN/WHTE (-) STEERNG COLUMN HARNESS-NO
RELAY
Power Lock: ADD ACTUATORS N ALL DOORS *
Power Unlock: ADD ACTUATORS N ALL DOORS *
Trunk Release: N/A
Alarm nput Wire: BLACK (-) AT PN SWTCH

NOTES: * See Note #204 - Adding Actuator Door Lock Diagram.



This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Subaru - Copyright 2004-2006 - 12 Volt Resource LLC Page 29 of 60

Make: Model: Year:
Subaru Legacy 1990-1994


FUNCTON COLOR LOCATON
Start: BLUE/RED GNTON SWTCH HARNESS
gnition #1: RED GNTON SWTCH HARNESS
gnition #2: RED/YELLOW GNTON SWTCH HARNESS (HEATER)
gnition #3: N/A
Accessory: N/A
Brake Light: WHTE/BLACK (+) SWTCH ON BRACKET ABOVE BRAKE
PEDAL
Tach Signal: BLACK/BLUE
AT MPF CONTROL UNT BEHND DR.
DASH*
Parking Lights: RED (+) AT FUSEBOX OR FUSE SX
Headlights: BLUE/BLACK (-) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Multi Port Fuel njection Module s A Gold Module Located Behind Driver's Dash.

Subaru Legacy 1990-1994

FUNCTON COLOR LOCATON
Constant +12 Volts: BLACK/YELLOW GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
RED/WHTE (-) 16 PN CONNECTOR ABOVE BRAKE
OEM Horn: RED/GREEN (-) STEERNG COLUMN HARNESS OR AT
RELAY
Power Lock: ADD ACTUATOR N DRVER'S DOOR *
Power Unlock: ADD ACTUATOR N DRVER'S DOOR *
Trunk Release: N/A
Alarm nput Wire: RED/WHTE (-) 16 PN CONNECTOR ABOVE BRAKE

NOTES: ** See Note #204 - Adding Actuator Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Subaru - Copyright 2004-2006 - 12 Volt Resource LLC Page 30 of 60

Make: Model: Year:
Subaru Legacy 1995


FUNCTON COLOR LOCATON
Start: BLUE/RED GNTON SWTCH HARNESS
gnition #1: RED GNTON SWTCH HARNESS
gnition #2: N/A
gnition #3: N/A
Accessory: RED/YELLOW GNTON SWTCH HARNESS
Brake Light: WHTE OR
WHTE/BLACK
(+) ABOVE BRAKE PEDAL
Tach Signal: BLACK/BLUE
ENGNE CONTROL MOD.UNDER
PASS.FLOOR
Parking Lights: GREEN/RED (+) PASSENGER SDE OF STEERNG
COLUMN
Headlights:
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES:

Subaru Legacy 1995

FUNCTON COLOR LOCATON
Constant +12 Volts: RED/YELLOW GNTON SWTCH HARNESS
OEM Alarm Disarm: WLL DSARM WHEN DOORS ARE
UNLOCKED
Dome
Lights/Superv:
RED/WHTE (-) PASSSENGER SDE WNDSHELD POST
OEM Horn: RED/GREEN (-)
Power Lock: ADD ACTUATOR N DRVER'S DOOR *
Power Unlock: ADD ACTUATOR N DRVER'S DOOR *
Trunk Release: N/A
Alarm nput Wire: RED/WHTE (-) PASSSENGER SDE WNDSHELD POST

NOTES: * See Note #204 - Adding Actuator Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Subaru - Copyright 2004-2006 - 12 Volt Resource LLC Page 31 of 60

Make: Model: Year:
Subaru Legacy 1996-1997


FUNCTON COLOR LOCATON
Start: BLUE/RED GNTON SWTCH HARNESS
gnition #1: RED GNTON SWTCH HARNESS
gnition #2: RED/YELLOW GNTON SWTCH HARNESS (HEAT/AC)
gnition #3: N/A
Accessory:
Brake Light: WHTE/BLACK (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: BLUE AT COL
Parking Lights: RED/GREEN (+) AT HEADLGHT SWTCH
Headlights:
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES:


Subaru Legacy 1996-1997

FUNCTON COLOR LOCATON
Constant +12 Volts: BLACK/YELLOW GNTON SWTCH HARNESS
OEM Alarm Disarm: WHTE/GREEN (-) PANEL
Dome
Lights/Superv:
RED/WHTE (-) DRVER KCK PANEL
OEM Horn:
Power Lock: ADD ACTUATOR N DRVER'S DOOR *
Power Unlock: ADD ACTUATOR N DRVER'S DOOR *
Trunk Release:
Alarm nput Wire: RED/WHTE (-) DRVER KCK PANEL

NOTES: * See Note #204 - Adding Actuator Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Subaru - Copyright 2004-2006 - 12 Volt Resource LLC Page 32 of 60


Make: Model: Year:
Subaru Legacy 1997-1999


FUNCTON COLOR LOCATON
Start: BLUE/RED GNTON SWTCH HARNESS
gnition #1: RED GNTON SWTCH HARNESS
gnition #2: RED/YELLOW GNTON SWTCH HARNESS (HEAT/AC)
gnition #3:
Accessory:
Brake Light: WHTE/BLACK (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: BLUE AT COL
Parking Lights: RED/GREEN (+) AT HEALDGHT SWTCH
Headlights:
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES:

Subaru Legacy 1997-1999

FUNCTON COLOR LOCATON
Constant +12 Volts: BLACK/YELLOW GNTON SWTCH HARNESS
OEM Alarm Disarm: WHTE/GREEN (-) DRVER KCK PANEL
Dome
Lights/Superv:
RED/WHTE (-) DRVER KCK PANEL
OEM Horn:
Power Lock: WHTE/RED DRVER'S KCK PANEL *
Power Unlock: WHTE DRVER'S KCK PANEL *
Trunk Release:
Alarm nput Wire: RED/WHTE (-) DRVER KCK PANEL

NOTES: * See Note #201 - Negative Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Subaru - Copyright 2004-2006 - 12 Volt Resource LLC Page 33 of 60

Make: Model: Year:
Subaru Legacy 2000-2001


FUNCTON COLOR LOCATON
Start: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #1: BLACK GNTON SWTCH HARNESS
gnition #2: N/A
gnition #3: N/A
Accessory: BLACK/BLUE GNTON SWTCH HARNESS
Brake Light: WHTE/BLACK AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: BLUE AT COL MODULE TOP OF ENGNE
Parking Lights: ORANGE (+) N HARNESS, NEAR GNTON HARNESS
Headlights:
Diesel Glow Plug: N/A
Clutch Bypass Wire:

NOTES:

Subaru Legacy 2000-2001

FUNCTON COLOR LOCATON
Constant +12 Volts:
OEM Alarm Disarm:
Dome
Lights/Superv:

OEM Horn: RED/GREEN (-) N HARNESS, NEAR GNTON HARNESS
Power Lock: WHTE (-) N KEYLESS/ALARM MOD. PASSANGER
KCK *
Power Unlock: GREEN/RED (-) N KEYLESS/ALARM MOD. PASSANGER
KCK *
Trunk Release: N/A
Alarm nput Wire:

NOTES: * See nstallation Note #201 - Negative Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Subaru - Copyright 2004-2006 - 12 Volt Resource LLC Page 34 of 60

Make: Model: Year:
Subaru Legacy 2001-2002


FUNCTON COLOR LOCATON
Start: WHTE/BLACK GNTON SWTCH HARNESS
gnition #1: GREEN GNTON SWTCH HARNESS
gnition #2: N/A
gnition #3: N/A
Accessory: YELLOW GNTON SWTCH HARNESS
Brake Light: WHTE/BLACK AT SWTCH ABOVE PEDAL OR DR. KCK
PANEL
Tach Signal: YELLOW/GREEN AT COL MODULE
Parking Lights: ORANGE (+) AT PARKNG LGHT SWTCH
Headlights: BLUE/YELLOW (-) AT HEADLGHT SWTCH
Diesel Glow Plug: N/A
Clutch Bypass Wire:

NOTES:

Subaru Legacy 2001-2002

FUNCTON COLOR LOCATON
Constant +12 Volts: BLACK/YELLOW GNTON SWTCH HARNESS
OEM Alarm Disarm: DSARMS THROUGH
FACTORY
REMOTE ONLY
Dome
Lights/Superv:
PNK/BLACK (-) N WHTE PLUG BEHND THE FUSEBOX
OEM Horn: RED/GREEN (-) STEERNG COLUMN HARNESS
Power Lock: WHTE (-) N DRVER'S KCK PANEL COMNG FROM
DOOR
Power Unlock: GREEN/RED (-) N DRVER'S KCK PANEL COMNG FROM
DOOR
Trunk Release: LT. GREEN/YELLOW (5-
WRE)
MOTOR N TALGATE OF WAGON ONLY
Alarm nput Wire: PNK/BLACK (-) N WHTE PLUG BEHND THE FUSEBOX

NOTES: ** See nstallation Note #201 - Negative Pulse Door Lock System.



This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Subaru - Copyright 2004-2006 - 12 Volt Resource LLC Page 35 of 60
Make: Model: Year:
Subaru Legacy 2003-2004


FUNCTON COLOR LOCATON
Start: White/Black (+) gnition switch harness
gnition #1: Green (+) gnition switch harness
gnition #2: N/A
gnition #3: N/A
Accessory: Yellow (+) gnition switch harness
Brake Light: White/Black (+) Brake pedal switch
Tach Signal: Yellow/Green (AC) gnition coil
Parking Lights: Orange (+) Parking light switch
Headlights: N/A
Diesel Glow Plug: N/A
Clutch Bypass Wire: N/A

NOTES:

Subaru Legacy 2003-2004

FUNCTON COLOR LOCATON
Constant +12 Volts: White (+) gnition switch harness
OEM Alarm Disarm: Factory remote only
Dome
Lights/Superv:
Pink/Black (-) gnition switch harness
OEM Horn: Red/Green (-) Steering column harness
Power Lock: White (-) Drivers kick panel door harness**
Power Unlock: Green/Red (-) Drivers kick panel door harness**
Trunk Release: N/A
Alarm nput Wire: Pink/Black (-) gnition switch harness

NOTES: See Note #201 Negative Trigger Door Locks.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Subaru - Copyright 2004-2006 - 12 Volt Resource LLC Page 36 of 60

Subaru Legacy 2005-2006

FUNCTON COLOR LOCATON
Start: White/Black (+) gnition switch harness
gnition #1: Green (+) gnition switch harness
gnition #2: N/A
gnition #3: N/A
Accessory: Yellow (+) gnition switch harness
Brake Light: White/Black (+) Brake pedal switch
Tach Signal: Yellow/Green (AC) gnition coil
Parking Lights: Orange (+) Parking light switch
Headlights: N/A
Diesel Glow Plug: N/A
Clutch Bypass
Wire:
N/A
Notes:

Subaru Legacy 2005-2006

FUNCTON COLOR LOCATON
Constant +12
Volts:
White (+) gnition switch harness
OEM Alarm
Disarm:
Factory remote only
Dome
Lights/Superv:
Pink/Black (-) gnition switch harness
OEM Horn: Red/Green (-) Steering column harness
Power Lock: Brown/White(-) Drivers kick panel door
harness**

Power Unlock: Brown/Black (-) Drivers kick panel door
harness**

Trunk Release: N/A
Alarm nput Wire: Pink/Black (-) gnition switch harness
Notes: See Note #201 Negative Trigger Door Locks.



This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Subaru - Copyright 2004-2006 - 12 Volt Resource LLC Page 37 of 60

LEGACY OUTBACK 1995



KEY T-HARNESS MMOBLZER
N/A N/A N/A

FUNCTON COLOR LOCATON
12 VOLT CONSTANT BLACK/YELLOW (+) GNTON SWTCH HARNESS
STARTER BLUE/RED (+) GNTON SWTCH HARNESS
STARTER 2 N/A
GNTON 1 RED (+) GNTON SWTCH HARNESS
GNTON 2 N/A
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
RED/YELLOW (+) GNTON SWTCH HARNESS
ACCESSORY/HEATER
BLOWER 2
RED/YELLOW (+) GNTON SWTCH HARNESS
KEYSENSE N/A
PARKNG LGHTS ( - ) N/A
PARKNG LGHTS ( + ) RED with BLUE Dots (+)
@ STEERNG COLUMN
HARNESS
POWER LOCK
ADD ACTUATOR, See NOTE
*1
TO DRVERS DOOR ONLY,
POWER UNLOCK
ADD ACTUATOR, See NOTE
*1
TO DRVERS DOOR ONLY,
DOOR TRGGER RED/WHTE (-) N PASSENGER KCK PANEL
DOMELGHT SUPERVSON USE DOOR TRGGER
TRUNK RELEASE N/A
SLDNG POWER DOOR N/A
HORN N/A
TACH BLUE @ GNTON COL

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Subaru - Copyright 2004-2006 - 12 Volt Resource LLC Page 38 of 60

WAT TO START LGHT N/A


BRAKE WHTE/BLACK (+)
@ SWTCH ABOVE BRAKE
PEDAL
FACTORY ALARM DSARM WHTE/GREEN (-) N DRVERS KCK PANEL
ANT-THEFT N/A

EXTRA NFORMATON
NOTE *1 this vehicle uses a CENTRAL DOOR LOCKNG SYSTEM, when connecting a KEYLESS
ENTRY, you will need to add a Door Lock Actuator part #742 in the Drivers Door Only!!, some units
will also require (2) extra relays, part #775, to complete the installation, to connect,




This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Subaru - Copyright 2004-2006 - 12 Volt Resource LLC Page 39 of 60

LEGACY OUTBACK 1996



KEY T-HARNESS MMOBLZER
N/A N/A N/A

FUNCTON COLOR LOCATON
12 VOLT CONSTANT BLACK/YELLOW (+)
GNTON SWTCH HARNESS,
See NOTE *1
STARTER BLUE/RED (+)
GNTON SWTCH HARNESS,
See NOTE *1
STARTER 2 N/A
GNTON 1 RED (+)
GNTON SWTCH HARNESS,
See NOTE *1
GNTON 2 N/A
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
RED/YELLOW (+)
GNTON SWTCH HARNESS,
See NOTE *1
ACCESSORY/HEATER
BLOWER 2
N/A
KEYSENSE N/A
PARKNG LGHTS ( - ) BLACK/GREEN (-) @ HEADLGHT SWTCH
PARKNG LGHTS ( + ) N/A
POWER LOCK
ADD ACTUATOR, See NOTE
*2
TO DRVERS DOOR ONLY,
POWER UNLOCK
ADD ACTUATOR, See NOTE
*2
TO DRVERS DOOR ONLY,
DOOR TRGGER RED/WHTE (-)
N BLACK PLUG, ABOVE
HOOD RELEASE
DOMELGHT SUPERVSON USE DOOR TRGGER
TRUNK RELEASE N/A
SLDNG POWER DOOR N/A

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Subaru - Copyright 2004-2006 - 12 Volt Resource LLC Page 40 of 60

HORN RED/GREEN (-)


@ 3-PN BLACK PLUG, AT
COLUMN
TACH BLUE with RED Dots @ GNTON COL
WAT TO START LGHT N/A
BRAKE
WHTE/BLACK with SLVER
Dots (+)
@ SWTCH ABOVE BRAKE
PEDAL
FACTORY ALARM DSARM GREEN/LGHT BLUE (-) N DRVERS KCK PANEL
ANT-THEFT N/A

EXTRA NFORMATON
NOTE *1 these wires are in a 6-PN Plug located in the STEERNG COLUMN. NOTE *2 this vehicle
uses a CENTRAL DOOR LOCKNG SYSTEM, when connecting a KEYLESS ENTRY, you will need
to add a Door Lock Actuator part #742 in the Drivers Door Only!!, some units will also require (2)
extra relays, part #775, to complete the installation, to connect,



This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Subaru - Copyright 2004-2006 - 12 Volt Resource LLC Page 41 of 60

Make: Model: Year:
Subaru Legacy Outback 1997-1999


FUNCTON COLOR LOCATON
Start: BLUE/RED GNTON SWTCH HARNESS
gnition #1: RED GNTON SWTCH HARNESS
gnition #2: RED/YELLOW GNTON SWTCH HARNESS *
gnition #3: N/A
Accessory: N/A
Brake Light: WHTE/BLACK AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: YELLOW/BLUE AT GNTER **
Parking Lights: BLACK/GREEN (-) AT HEADLGHT SWTCH
Headlights: BLUE/BLACK (-) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * gnition 2 must be programmed to not be ""Hot"" during crank or a ""Check Engine""
light will appear in the instrument cluster. ** gnitor is located at center rear of engine
compartment.

Subaru Legacy Outback 1997-1999

FUNCTON COLOR LOCATON
Constant +12 Volts: BLACK/YELLOW GNTON SWTCH HARNESS
OEM Alarm Disarm: WHTE/GREEN (-) AT SECURTY MODULE BEHND GLOVE
BOX
Dome
Lights/Superv:
RED/WHTE (-) AT DOME LGHT OR COMB. METER
OEM Horn: RED/GREEN (-) STEERNG COLUMN HARNESS
Power Lock: WHTE/RED (-) AT TMER MOD. BEHND RT. SDE DASH ***
Power Unlock: WHTE (-) AT TMER MOD. BEHND RT. SDE DASH ***
Trunk Release: N/A
Alarm nput Wire: RED/WHTE (-) AT DOME LGHT OR COMB. METER

NOTES: *** See Note #201 Negative Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Subaru - Copyright 2004-2006 - 12 Volt Resource LLC Page 42 of 60

Make: Model: Year:
Subaru LoyaIe 1990-1993


FUNCTON COLOR LOCATON
Start: BLACK/WHTE GNTON SWTCH HARNESS
gnition #1: BLACK GNTON SWTCH HARNESS
gnition #2: N/A
gnition #3: N/A
Accessory: BLUE GNTON SWTCH HARNESS
Brake Light: GREEN/BLACK AT SWTCH
Tach Signal: YELLOW AT COL
Parking Lights: RED/BLACK (+) AT HEADLGHT SWTCH
Headlights: RED/BLACK (-) AT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES:

Subaru LoyaIe 1990-1993

FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
BLACK/RED (-) DOME LGHT OR NSTRUMENT CLUSTER
HARN
OEM Horn: GREEN/BLACK
Power Lock: ADD ACTUATOR N DRVER'S DOOR *
Power Unlock: ADD ACTUATOR N DRVER'S DOOR *
Trunk Release: N/A
Alarm nput Wire: BLACK/RED (-) DOME LGHT OR NSTRUMENT CLUSTER
HARN

NOTES: * See Note #204 - Adding Actuator Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Subaru - Copyright 2004-2006 - 12 Volt Resource LLC Page 43 of 60

Make: Model: Year:
Subaru Outback 1999


FUNCTON COLOR LOCATON
Start: BLUE/RED GNTON SWTCH HARNESS
gnition #1: RED GNTON SWTCH HARNESS
gnition #2: N/A
gnition #3: N/A
Accessory: RED/YELLOW GNTON SWTCH HARNESS
Brake Light: WHTE/BLACK AT SWTCH ABOVE PEDAL OR DR. KCK
PANEL
Tach Signal: BLUE AT COL MODULE OR RED AT ECM *
Parking Lights: RED/BLUE (+) N 12 PN MOLEX NEXT TO GN. HARNESS
Headlights:
Diesel Glow Plug: N/A
Clutch Bypass Wire:

NOTES: * ECM s Located n Passenger Floor. Red Wire s n Position #64.

Subaru Outback 1999

FUNCTON COLOR LOCATON
Constant +12 Volts: BLACK/YELLOW GNTON SWTCH HARNESS
OEM Alarm Disarm:
Dome
Lights/Superv:
RED/WHTE (-) AT KEYLESS MOD. ABOVE BRAKE PEDAL
OEM Horn: RED/BLUE (-) AT KEYLESS MOD. ABOVE BRAKE PEDAL
Power Lock: WHTE/RED (-) AT KEYLESS MOD. ABOVE BRAKE PEDAL
**
Power Unlock: WHTE (-) AT KEYLESS MOD. ABOVE BRAKE PEDAL
**
Trunk Release: N/A
Alarm nput Wire: RED/WHTE (-) AT KEYLESS MOD. ABOVE BRAKE PEDAL

NOTES: ** See nstallation Note #201 - Negative Pulse Door Lock System.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Subaru - Copyright 2004-2006 - 12 Volt Resource LLC Page 44 of 60

Make: Model: Year:
Subaru Outback 2000-2002


FUNCTON COLOR LOCATON
Start: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #1: BLACK GNTON SWTCH HARNESS
gnition #2: N/A
gnition #3: N/A
Accessory: BLACK/BLUE GNTON SWTCH HARNESS
Brake Light: WHTE/BLACK AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: BLUE AT COL MODULE TOP OF ENGNE
Parking Lights: ORANGE (+) N HARNESS, NEAR GNTON HARNESS
Headlights:
Diesel Glow Plug: N/A
Clutch Bypass Wire:

NOTES:

Subaru Outback 2000-2002

FUNCTON COLOR LOCATON
Constant +12 Volts:
OEM Alarm Disarm:
Dome
Lights/Superv:

OEM Horn: RED/GREEN (-) N HARNESS, NEAR GNTON HARNESS
Power Lock: WHTE (-) N KEYLESS/ALARM MOD. PASSANGER
KCK *
Power Unlock: GREEN/RED (-) N KEYLESS/ALARM MOD. PASSANGER
KCK *
Trunk Release: N/A
Alarm nput Wire:

NOTES: * See nstallation Note #201 - Negative Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Subaru - Copyright 2004-2006 - 12 Volt Resource LLC Page 45 of 60

Make: Model: Year:
Subaru Outback 2003-2006


FUNCTON COLOR LOCATON
Start: White/Black (+) gnition switch harness
gnition #1: Green (+) gnition Switch Harness
gnition #2: N/A gnition switch harness
gnition #3: N/A gnition switch harness
Accessory: Yellow (+) gnition switch harness
Brake Light: White/Black (+) Brake pedal switch
Tach Signal: Yellow/Green (AC) gnition coil
Parking Lights: Orange (+) Parking light switch
Headlights:
Diesel Glow Plug: N/A
Clutch Bypass Wire: N/A

NOTES:

Subaru Outback 2003-2006

FUNCTON COLOR LOCATON
Constant +12 Volts: White (+) gnition switch harness
OEM Alarm Disarm: Factory remote only
Dome
Lights/Superv:
Pink/Black (-) White plug behind the fusebox
OEM Horn: Red/Green (-) Steering column harness
Power Lock: White (-) Drivers kick panel door harness**
Power Unlock: Green/Red (-) Drivers kick panel door harness**
Trunk Release:
Alarm nput Wire: Pink/Black (-) White plug behind the fusebox

NOTES: **See Note #201 Negative Trigger Door Locks.




This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Subaru - Copyright 2004-2006 - 12 Volt Resource LLC Page 46 of 60

OUTBACK SPORT 2000 -2001



KEY T-HARNESS MMOBLZER
N/A SUB-2 N/A

FUNCTON COLOR LOCATON
12 VOLT CONSTANT WHTE (+) GNTON SWTCH HARNESS
STARTER WHTE/BLACK (+) GNTON SWTCH HARNESS
STARTER 2 N/A
GNTON 1 GREEN (+) GNTON SWTCH HARNESS
GNTON 2 N/A
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
YELLOW (+) GNTON SWTCH HARNESS
ACCESSORY/HEATER
BLOWER 2
N/A
KEYSENSE N/A
PARKNG LGHTS ( - ) BLACK/WHTE (-) @ HEADLGHT SWTCH
PARKNG LGHTS ( + ) ORANGE (+) @ PARKNG LGHT SWTCH
POWER LOCK BLUE/GREEN (TYPE B)
@ KEYLESS MODULE, LEFT
OF STEERNG COLUMN
POWER UNLOCK YELLOW/RED (TYPE B)
@ KEYLESS MODULE, LEFT
OF STEERNG COLUMN
DOOR TRGGER YELLOW (-)
@ KEYLESS MODULE, LEFT
OF STEERNG COLUMN
DOMELGHT SUPERVSON USE DOOR TRGGER
TRUNK RELEASE N/A
SLDNG POWER DOOR N/A

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Subaru - Copyright 2004-2006 - 12 Volt Resource LLC Page 47 of 60

HORN RED/GREEN (-)


@ STEERNG COLUMN
HARNESS
TACH BLUE or RED/GREEN @ GNTON COL
WAT TO START LGHT N/A
BRAKE WHTE/BLACK (+)
@ SWTCH ABOVE BRAKE
PEDAL
FACTORY ALARM DSARM N/A
ANT-THEFT N/A

EXTRA NFORMATON
NOTE *1 the DOOR LOCK TMER is located high up in the DRVERS KCK PANEL, the TMER has
a 6-PN PLUG.




This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Subaru - Copyright 2004-2006 - 12 Volt Resource LLC Page 48 of 60

OUTBACK SPORT 2002



KEY T-HARNESS MMOBLZER
N/A N/A N/A

FUNCTON COLOR LOCATON
12 VOLT CONSTANT BLACK/WHTE to WHTE (+) GNTON SWTCH HARNESS
STARTER
BLACK/YELLOW to
WHTE/BLACK (+)
GNTON SWTCH HARNESS
STARTER 2 N/A
GNTON 1 BLACK to GREEN (+) GNTON SWTCH HARNESS
GNTON 2 N/A
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
BLACK/BLUE to YELLOW (+) GNTON SWTCH HARNESS
ACCESSORY/HEATER
BLOWER 2
N/A
KEYSENSE N/A
PARKNG LGHTS ( - ) N/A
PARKNG LGHTS ( + ) ORANGE (+) @ HEADLGHT SWTCH
POWER LOCK RED/WHTE (TYPE B)
@ KEYLESS MODULE, LEFT
OF STEERNG COLUMN
POWER UNLOCK YELLOW/RED (TYPE B)
@ KEYLESS MODULE, LEFT
OF STEERNG COLUMN
DOOR TRGGER YELLOW (-)
@ KEYLESS MODULE, LEFT
OF STEERNG COLUMN
DOMELGHT SUPERVSON USE DOOR TRGGER
TRUNK RELEASE N/A
SLDNG POWER DOOR N/A

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Subaru - Copyright 2004-2006 - 12 Volt Resource LLC Page 49 of 60

HORN RED/GREEN (-)


@ STEERNG COLUMN
HARNESS
TACH GREEN
@ NSTRUMENT CLUSTER or
ECM, See NOTE *1
WAT TO START LGHT N/A
BRAKE WHTE/BLACK (+)
@ SWTCH ABOVE BRAKE
PEDAL
FACTORY ALARM DSARM
DSARMS with FACTORY
REMOTE ONLY!!!

ANT-THEFT N/A

EXTRA NFORMATON
NOTE *1 the ECM (Electronic Control Module) is located BEHND the PASSENGER KCK.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Subaru - Copyright 2004-2006 - 12 Volt Resource LLC Page 50 of 60

Make: Model: Year:
Subaru Sedan 1985-1989


FUNCTON COLOR LOCATON
Start: BLACK/WHTE OR BLACK/YELLOW - GNTON SWTCH
HARN.
gnition #1: BLACK GNTON SWTCH HARNESS
gnition #2: BLUE GNTON SWTCH HARNESS
gnition #3:
Accessory:
Brake Light: GREEN/BLACK (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: YELLOW AT COL *
Parking Lights: RED/BLACK (+) AT LGHT SWTCH
Headlights:
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Some Models Carburated.

Subaru Sedan 1985-1989

FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE GNTON SWTCH HARNESS
OEM Alarm Disarm:
Dome
Lights/Superv:
BLCK/RED (-) NSTR. PANEL HARNESS OR DOME LGHT
OEM Horn:
Power Lock: ADD ACTUATOR N DRVER'S DOOR **
Power Unlock: ADD ACTUATOR N DRVER'S DOOR **
Trunk Release:
Alarm nput Wire: BLCK/RED (-) NSTR. PANEL HARNESS OR DOME LGHT

NOTES: ** See Note #204 - Adding Actuator Door Lock Diagram.




This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Subaru - Copyright 2004-2006 - 12 Volt Resource LLC Page 51 of 60

SVX 1992

KEY T-HARNESS MMOBLZER
N/A N/A N/A

FUNCTON COLOR LOCATON
12 VOLT CONSTANT Connect to BATTERY
STARTER BLACK/YELLOW (+) GNTON SWTCH HARNESS
STARTER 2 N/A
GNTON 1 BLACK or WHTE (+) GNTON SWTCH HARNESS
GNTON 2 N/A
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
BLACK/BLUE (+) GNTON SWTCH HARNESS
ACCESSORY/HEATER
BLOWER 2
N/A
KEYSENSE N/A
PARKNG LGHTS ( - ) N/A
PARKNG LGHTS ( + ) RED/WHTE (+) or RED (+)
@ STEERNG COLUMN
HARNESS
POWER LOCK
BLUE/BROWN or ORANGE
(TYPE B)
N DRVERS KCK PANEL
POWER UNLOCK
ORANGE or BLUE/ORANGE
(TYPE B)
N DRVERS KCK PANEL
DOOR TRGGER
WHTE/RED (+) or BLACK/RED
(-)
@ UNDERDASH LGHT
DOMELGHT SUPERVSON USE DOOR TRGGER
TRUNK RELEASE N/A
SLDNG POWER DOOR N/A

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Subaru - Copyright 2004-2006 - 12 Volt Resource LLC Page 52 of 60

HORN N/A
TACH YELLOW or YELLOW/WHTE @ GNTON COL
WAT TO START LGHT N/A
BRAKE WHTE/RED (+)
@ SWTCH ABOVE BRAKE
PEDAL
FACTORY ALARM DSARM N/A
ANT-THEFT N/A




This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Subaru - Copyright 2004-2006 - 12 Volt Resource LLC Page 53 of 60

SVX 1993

KEY T-HARNESS MMOBLZER
N/A N/A N/A

FUNCTON COLOR LOCATON
12 VOLT CONSTANT BLACK/YELLOW (+) GNTON SWTCH HARNESS
STARTER BLACK/WHTE (+) GNTON SWTCH HARNESS
STARTER 2 N/A
GNTON 1 RED (+) GNTON SWTCH HARNESS
GNTON 2 N/A
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
RED/YELLOW (+) GNTON SWTCH HARNESS
ACCESSORY/HEATER
BLOWER 2
N/A
KEYSENSE N/A
PARKNG LGHTS ( - ) N/A
PARKNG LGHTS ( + ) RED (+) @ HEADLGHT SWTCH
POWER LOCK ORANGE (TYPE B) BEHND GLOVEBOX
POWER UNLOCK BLUE/ORANGE (TYPE B) BEHND GLOVEBOX
DOOR TRGGER GREEN/BLACK (-) @ UNDERDASH LGHT
DOMELGHT SUPERVSON USE DOOR TRGGER
TRUNK RELEASE N/A
SLDNG POWER DOOR N/A
HORN N/A
TACH YELLOW/WHTE @ GNTON COL
WAT TO START LGHT N/A

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Subaru - Copyright 2004-2006 - 12 Volt Resource LLC Page 54 of 60

BRAKE WHTE/RED (+)


@ SWTCH ABOVE BRAKE
PEDAL
FACTORY ALARM DSARM N/A
ANT-THEFT N/A




This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Subaru - Copyright 2004-2006 - 12 Volt Resource LLC Page 55 of 60

SVX 1994 -1997



KEY T-HARNESS MMOBLZER
N/A N/A N/A

FUNCTON COLOR LOCATON
12 VOLT CONSTANT BLACK/YELLOW (+) GNTON SWTCH HARNESS
STARTER BLACK/WHTE (+) GNTON SWTCH HARNESS
STARTER 2 N/A
GNTON 1 RED (+) GNTON SWTCH HARNESS
GNTON 2 N/A
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
RED/YELLOW (+) GNTON SWTCH HARNESS
ACCESSORY/HEATER
BLOWER 2
N/A
KEYSENSE N/A
PARKNG LGHTS ( - ) N/A
PARKNG LGHTS ( + ) RED/WHTE (+) @ HEADLGHT SWTCH
POWER LOCK ORANGE (TYPE B)
@ CENTER CONSOLE
SWTCH
POWER UNLOCK ORANGE/GREEN (TYPE B)
@ CENTER CONSOLE
SWTCH
DOOR TRGGER WHTE/RED (-) @ UNDERDASH LGHT
DOMELGHT SUPERVSON USE DOOR TRGGER
TRUNK RELEASE N/A
SLDNG POWER DOOR N/A
HORN GREEN/BLACK (-)
@ STEERNG COLUMN
HARNESS

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Subaru - Copyright 2004-2006 - 12 Volt Resource LLC Page 56 of 60

TACH YELLOW @ ECM, See NOTE *1


WAT TO START LGHT N/A
BRAKE WHTE/RED (+)
@ SWTCH ABOVE BRAKE
PEDAL
FACTORY ALARM DSARM N/A
ANT-THEFT N/A

EXTRA NFORMATON
NOTE *1 the ECM (Electronic Control Module) is located UNDER the DRVERS SDE of the DASH,
the Tach wire is in a 16-PN Plug, Pin 16.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Subaru - Copyright 2004-2006 - 12 Volt Resource LLC Page 57 of 60

Subaru Wagon 1985-1989


FUNCTON COLOR LOCATON
Start: BLACK/WHTE OR BLACK/YELLOW - GNTON SW. HARNESS
gnition #1: BLACK GNTON SWTCH HARNESS
gnition #2: BLUE GNTON SWTCH HARNESS
gnition #3:
Accessory:
Brake Light: GREEN/BLACK (+) AT SWTCH ABOVE BRAKE SWTCH
Tach Signal: YELLOW AT COL *
Parking Lights: RED/BLACK (+) AT LGHT SWTCH
Headlights:
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Some Models Carburated.

Subaru Wagon 1985-1989

FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE GNTON SWTCH HARNESS
OEM Alarm Disarm:
Dome
Lights/Superv:
BLACK/RED (-) NSTR. PANEL HARNESS OR DOME LGHT
OEM Horn:
Power Lock: ADD ACTUATOR N DRVER'S DOOR **
Power Unlock: ADD ACTUATOR N DRVER'S DOOR **
Trunk Release:
Alarm nput Wire: BLACK/RED (-) NSTR. PANEL HARNESS OR DOME LGHT

NOTES: ** See Note #204 - Adding Actuator Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Subaru - Copyright 2004-2006 - 12 Volt Resource LLC Page 58 of 60


Make: Model: Year:
Subaru XT 1988-1991


FUNCTON COLOR LOCATON
Start: BLACK/WHTE GNTON SWTCH HARNESS
gnition #1: BLACK GNTON SWTCH HARNESS
gnition #2: BLUE GNTON SWTCH HARNESS
gnition #3:
Accessory:
Brake Light: GREEN/BLACK AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: YELLOW AT COL OR DASH TACHOMETER
Parking Lights: RED/BLACK (+) AT LGHT SWTCH
Headlights:
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES:

Subaru XT 1988-1991

FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE GNTON SWTCH HARNESS
OEM Alarm Disarm:
Dome
Lights/Superv:
BLACK/RED (-) NSTR. PANEL HARNESS OR DOME LGHT
OEM Horn:
Power Lock: ADD ACTUATOR N DRVER'S DOOR *
Power Unlock: ADD ACTUATOR N DRVER'S DOOR *
Trunk Release:
Alarm nput Wire: BLACK/RED (-) NSTR. PANEL HARNESS OR DOME LGHT

NOTES: * See Note #204 - Adding Actuator Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Subaru - Copyright 2004-2006 - 12 Volt Resource LLC Page 59 of 60

Make: Model: Year:
Subaru XT-6 1988-1991


FUNCTON COLOR LOCATON
Start: BLACK/WHTE GNTON SWTCH HARNESS
gnition #1: BLACK GNTON SWTCH HARNESS
gnition #2: BLUE GNTON SWTCH HARNESS
gnition #3:
Accessory:
Brake Light: GREEN/BLACK AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: YELLOW AT COL OR DASH TACHOMETER
Parking Lights: RED/BLACK (+) AT LGHT SWTCH
Headlights:
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES:

Subaru XT-6 1988-1991

FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE GNTON SWTCH HARNESS
OEM Alarm Disarm:
Dome
Lights/Superv:
BLACK/RED (-) NSTR. PANEL HARNESS OR DOME LGHT
OEM Horn:
Power Lock: ADD ACTUATOR N DRVER'S DOOR *
Power Unlock: ADD ACTUATOR N DRVER'S DOOR *
Trunk Release:
Alarm nput Wire: BLACK/RED (-) NSTR. PANEL HARNESS OR DOME LGHT

NOTES: * See Note #204 - Adding Actuator Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Subaru - Copyright 2004-2006 - 12 Volt Resource LLC Page 60 of 60

Make: Model: Year:
Subaru XT Coupe 1985-1987


FUNCTON COLOR LOCATON
Start: BLACK/WHTE GNTON SWTCH HARNESS
gnition #1: BLACK GNTON SWTCH HARNESS
gnition #2: BLUE GNTON SWTCH HARNESS
gnition #3:
Accessory:
Brake Light: GREEN/BLACK(+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: YELLOW AT COL OR DASH TACHOMETER
Parking Lights: RED/BLACK (+) AT LGHT SWTCH
Headlights:
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES:

Subaru XT Coupe 1985-1987

FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE GNTON SWTCH HARNESS
OEM Alarm Disarm:
Dome
Lights/Superv:
BLACK/RED - NSTR. PANEL HARNESS OR BLACK/WHTE AT
DOME
OEM Horn:
Power Lock: ADD ACTUATOR N DRVER'S DOOR *
Power Unlock: ADD ACTUATOR N DRVER'S DOOR *
Trunk Release:
Alarm nput Wire: BLACK/RED - NSTR. PANEL HARNESS OR BLACK/WHTE AT
DOME

NOTES: * See Note #204 - Adding Actuator Door Lock Diagram.

S-ar putea să vă placă și