Documente Academic
Documente Profesional
Documente Cultură
This type of operation will be useful for all owners of LG DVD recorder of the family RH177 / RH188 / RH198 who encounter problems of reliability of reading and burning with the rewriter 6721RFN021A. Indeed the small footprint of the 6721RFN021A not allows its replacement directly by the GH22NP20. Be a little bit patient and meticulous and you will be able to make it. Nothing is insurmountable for a good handyman!
1
Original rewriter
Check of GH22NP20
2
Lift up the black mechanical lock and unplug the optical ribbon cable.
Unclip the printed circuit and unplug the 3rd ribbon cable on the left side.
10
Remove the optical mechanism by unscrewing the 2 screws and slide the 2 silent blocks.
All these parts will not be useful for the following. You can keep them for memories or put them into garbage can.
Frame , screws for optical mechanism and metal covers must be kept for final reassembly.
Push the 2 clips on each side to remove the front and pull out the frame.
Lift up the black mechanical lock and unplug the optical ribbon cable.
Unplug the 2 front ribbon cables, lift up the printed circuit and unplug the 3rd ribbon cable.
Remove the optical mechanism by unscrewing the 2 screws and slide the 2 silent blocks. 7
This frame and the metal covers will not be useful for the following. You can keep them for memories or put them into garbage can.
Before modification
After modification
9
Before modification
After modification
LED removed
10
Reassembly
Did you sort all part you need ?
Final reassembly
Bend the clip not used for the new printed circuit board.
Put the optical mechanism by sliding the silent blocs with a small screwdriver in the centre then screw the 2 screws.
Plug the 3 ribbon cables and insert the printed circuit by using the clip then plug the optical ribbon cable .
Reassembly
7 8 9
Check if the loader can be locked without force by moving the mechanism to the left.
Its very important to have a good thermal contact between these 2 components and the metal cover. Its why you have to intercalate a metalic plate . See below to make it. 37 8 17 8 16 5 20
aluminium plate 12 Aluminium sheet thickness 1mm Dimensions in mm Tolerances +- 0.5 mm 2 holes diameter 3mm
10
25
<
35
Reassembly
11 12
<
Put the plate in the angle of the metal cover and drill 2 holes then screw or rivet the plate. ! File the screws or the rivets in order to avoid electrical contact with the printed circuit. Risk of short circuit ! When all is OK you can reassemble the 2 metal covers.
13
13