Documente Academic
Documente Profesional
Documente Cultură
vorpe_01@hotmail.com viga
1. Goemetry
1.1 Nodes: The structure has 3 nodes. The position of each nodeis given below. (Unit of Length: 'm'.) Node Number 1 2 3 x 0 3 6 y 0 0 0
See Figure 1 for the graphical representation of the structure's geometry. 1.2 Members: The structure consists of 2 members. The position, type and properties ID for each member is listed below. Member Number 1 2 1st Node 1 2 2nd Node 2 3 Type Frame Frame Properties ID 1 1
2. Supports: The structure rests on 3 supports. The position and type of each support are
shown in the table below. Support Number 1 2 3 Position (node) 1 2 3 Type 'Pin' 'RollerX' 'RollerX'
3. Loads: The structure is subjected to 2 applied loads. The position, type and magnitude of
each load are given below. (Unit of Force: 'KN'; Unit of Length: 'm'.) Load #: 1 Load Type: Distributed Member Force m: 1 a: 0 W: -100 b: 0 S: -100 r: 90
Load #: 2
4. Section and Material Properties: The structure has 1 corss-section. The type of
the cross-section and its dimensions are given below. (Unit of Length: 'cm'.) Section #: 1
w: 12
h: 12
Member Number 1 2
Section # 1 1
5. Nodal Displacements:
each node. Node # 1 2 3
x-displacement (mm) 0 0 0
y-displacement (mm) 0 0 0
See Figures 3 and 4 for the graphical representation of the displaced shape of the structure.
The maximum axial force in each structural member is given in the table below. (Unit of Force: KN) Force 0 0 Direction Tension Tension
The maximum shear force in each structural member is given in the table below. (Unit of Force: KN) Force 187.5 187.5
The maximum bending moment in each structural member is given in the table below. (Unit of Force: KN; Unit of Length: 'm')
1 1
2 2
100 KN/m
100 KN/m
100 KN/m
0 KN-m
112.5 KN
187.5 KN
-112.5 KN-m
0.2 KN
Normal Force
0 KN
Shear
112.5 KN
-187.5 KN
Moment
112.5 KN-m
187.5 KN
112.5 KN
0 KN-m
0.2 KN
Normal Force
0 KN
187.5 KN
Shear
-112.5 KN
Moment
-112.5 KN-m
0 KN-m