Sunteți pe pagina 1din 2

Scheme E

Sample Question Paper


Course Name : Electronics Engineering Group Course Code : ET/EN/EJ/EX/ED/EI Semester Subject Marks Instructions: 1. All questions are compulsory. 2. Illustrate your answers with neat sketches wherever necessary. 3. Figures to the right indicate full marks. 4. Assume suitable data if necessary. 5. Preferably, write the answers in sequential order. Q.1(A) Attempt any THREE a. Define the terms track on sector related to HDD with a proper sketch. b. List Four features of FIREWIRE. c. Describe the working of optoelectronic key switch with diagram and label any two parts of the switch. d. Describe the meaning of passive preventive maintenance and write the procedure for the same in five steps. 12 Marks : Fifth : Principles of Computer Architecture and Maintenance : 100 Time: 3 Hours

Q.1(B) Attempt any ONE 06 Marks a. Draw neat diagram of CENTRONICS interface, label it and describe function of INIT and SELECTIN signals. b. Draw block diagram of SMPS and describe working of the PWM. Q.2 Attempt any FOUR a. State meaning of BIOS and list any four functions. b. List eight features of PCI-EXPRESS bus. c. Describe the recording methods i.e. FM and MFM used for HDD with one bit pattern, draw no of pulses required by each of them. d. Draw block diagram of CD-ROM drive and state functions of any two blocks. e. State the meaning of following characteristics of monitor with neat sketch. 1. Dot-pitch 2. Resolution f. Draw block diagram of CRT color monitor. Q.3 Attempt any FOUR a. Draw block diagram of internal MODEM; describe two points in which it defers from external MODEM. 16 Marks

16 Marks

b. Draw block diagram of opt mechanical mouse and describe its working. c. Define following characteristics of power supply 1. Line regulation 2. Load regulation. d. List and describe the four problem related to power supply. e. List four features of SCSI and describe active and passive termination. Q.4 (a) Attempt any THREE a. Draw diagram of North /South bridge architecture, label it and write functions of the same. b. State meaning of Servo, its types i.e. embedded, wedge and dedicated servo with sketch. c. List four features of PATA HDD. d. State any four advantages and disadvantages of CRT monitor over LCD Monitor. Q.4 (b) Attempt any ONE a. Explain the Architecture Intel Chipset 945G. b. Describe the preventative maintenance of HDD, List six steps for that. Q.5 Attempt any FOUR a. Write the steps used in OCR software for flat bed scanner. b. For the bit pattern given find out no .of pulses required in MFM and RLL recording methods , draw the waveforms and state which method in better 101111011 c. Describe High level formatting in four steps. d. Diagnose the following problem and write the steps to solve them: the monitor appears completely unreadable. e. Explain the working & installation of Keyboard. f. Draw diagram of RS232 interface , mention its voltage levels and significance of RTS and CTS signal. Q.6 Attempt any FOUR a. If scanning lines for some monitor are given as 625, Draw diagram for interface and non- interfaced scanning showing scanning lines, trace and retrace path. b. Draw pin diagram of ATX type SMPS. c. Diagnose the following problem and write four steps to solve them. The system wont boot up, it says missing operating system on the screen. d. List two problems and their causes related to Dot matrix printer e. For High speed gaming application, give the specification of the following. i) HDD ii)RAM iii)CPUs frequency iv) Monitor resolution 12 Marks

06 Marks

16 Marks

16 Marks

S-ar putea să vă placă și