Documente Academic
Documente Profesional
Documente Cultură
Installation Guide
System requirement
OS : Windows XP, Windows Vista
RAM: 256 MB or more
1/5
< IPPVR Installation >
We recommend installing the latest software of IPPVR. Please contact your dealer for the latest version.
Warning! If your IP is “127.0.0.001”, it’s not actual IP address. Try to ask your network manger.
2/5
DHCP:
If your LAN is using a DHCP server (mostly used in home networks), the IP address and subnet mask will
be assigned automatically:
• DHCP / Static : DHCP ( Change “ DHCP -> Static -> DHCP ” to get actual IP address )
• IP Address : it’ll be filled automatically
• Subnet Mask: it’ll be filled automatically
• Gateway : it’ll be filled automatically
• PVR Server IP Address: input the IP address of your computer which is shown in IPPVR.exe
software
i.e. 192.168.011.126.
Attention : “PVR Server IP Address” and your computer IP address must be identical.
STATIC:
If your local network LAN is using static IP addresses, as used in bigger networks, input the relevant IP
addresses, subnet mask, gateway and the IP address of your computer.
• DHCP / Static : Static
• IP Address : put your static IP address.
• Subnet Mask: put your static IP address.
• Gateway: put your static IP address.
• PVR Server IP Address: kindly put IP address of your computer.
Attention : “PVR Server IP Address” and your computer IP address must be identical.
3/5
3. How to record with IPPVR
--------------------------------------------------------
1. When you want to record a channel, press REC button on remote controller during watching.
2. When you want to finish recording, press STOP button on remote controller
( button for remote controller without STOP button).
3. You can change the record folder and other settings by clicking button.
4. You can open actual record folder by clicking button.
4. Trouble shooting
1. IPSTB doesn't get IP address.
a. Check your LAN cable is firmly connected to ethernet port and yellow blink and green light stay on.
b. Turn Off and On again, Set-Top-Box is getting IP address from router only during boot up time.
c. Set-Top-Box is set to DHCP but your LAN is using static IP addresses. Change settings to
STATIC and Input correct static IP, subnet mask and gateway addresses.
2. "Failed to connect xxx.xxx.xxx.xxx" message on TV screen when Press REC button to start recording
a. Make sure check IPSTB gets IP address from router.
b. IPPVR software in your PC must be launched.
c. Check PVR Server IP Address and your PC IP address are same.
d. Allow your firewall the communication between PC and Set-Top-Box.
e. IPSTB and your PC must be connected on same local network.
WARNING: Most of channels and contents have copyright and any of their recording, copying and
distribution may break copyright law.
4/5
5.Example IPPVR network configuration
1. Router + Wired configuration
5/5