Documente Academic
Documente Profesional
Documente Cultură
Figure 1 Mass of water droplet vs. drying time at air temperature 48.4oC and air velocity 1.0m/s Solutions: (Method-1: based on the energy balance) From tables, Pr a a Kd = 0.7027 = 19.46 x 10-6 kg/ms = 1.098kg/m3 = 27.7895 x 10-3 W/m.K
For estimation of the convective heat transfer coefficient, we have the following correlation:
D v a hcD = 2.0 + 0.6 a Kd
0 .5
( Pr ) 0.33
(1)
Substituting the corresponding values, Eq 1 yields hc= 105.28W/m2.K Droplet surface area: A= D2= 1.323 x 10-5 m2
Temperature difference between drying air and droplet: T= 48.4 27.2 = 21.2 oC Latent heat of water: = 2417.44 kJ/kg
(2)
i.e.: Nc= [(105.28) * (1.323 x10-5) * (21.2)] / (2417.44)= 1.22 x 10-5 g/s From the graph in Figure 1, the evaporation rate is obtained as1.28 10 5 g/s Thus, the error by computation is = [(1.28 x10-5- 1.22 x 10-5)/ 1.28 x10-5] x 100%= 4.7%, which is negligible. In fact the error in estimation of h using empirical correlations can exceed 10%
Solution: (Method-2: Based on mass transfer/diffusion equation) For mass transfer from a spherical droplet subjected to a relative velocity of a drying medium, we have the Sherwood number correlation as follows:
Sh = kc D a 1 / 3 Dv a 1 / 2 1/ 2 = 2.0 + 0.6 Sc 1 / 3 Re p = 2.0 + 0.6( ) ( ) Dg a D g a
kc = =
Dg D
[ 2. 0 + 0. 6(
a 1 / 3 Dv a 1 / 2 ) ( ) ] a D g a
2.91 10 5 19 .46 10 6 0.002052 1.0 1.098 1 / 2 [ 2.0 + 0.6 ( )1 / 3 ( ) = 0.0776 ( m / s ) 5 0.002052 1.098 2.91 10 19 .46 10 6
Based on the initial dry-bulb and wet-bulb temperatures of air, the humidity is found from the psychrometric chart as 0.013 kgH2O/kg dryair. Then, the vapor concentration at the droplet surface ( C s )(kmol/m3); vapor concentration in the bulk gas ( C g ) (kmol/m3). They are defined as
Cs = psat (T p ) RT p pop RT g = 3600 = 1.443 10 3 (mol / m 3 ) 8314 300 0.013 / 18 101325 = 7.78 10 4 (mol / m 3 ) 1.0 / 29 + 0.013 / 18 8314 321 .4
Cg = X i
Based on the mass transfer equation, the mass transfer rate from the water droplet surface to the bulk air is calculated as
N c = k c A p M p (C s C g ) = 0.0776 1.323 10 5 18 10 3 (1.443 10 3 7.78 10 4 ) =1.23 10 5 ( g / s )
(a) Effect of air humidity Assume the absolute humidity is increased to 0.016 kg H2O/kg dry air. Then,
Cg = X i pop RT g = 0.016 / 18 101325 = 9.53 10 4 (mol / m 3 ) 1.0 / 29 + 0.016 / 18 8314 321 .4
The reduced percentage of the evaporation rate is due to the increase of humidity in air is computed by
=
1.23 10 5 9.06 10 6 100% = 26.3% 1.23 10 5
The increase of drying time is (499-370) = 129(s). Reduction in mass transfer driving potential is responsible for this reduction. (b) Effect of the operating pressure Assume the operating pressure is only half of the normal ambient atmospheric pressure, i.e., 50663Pa. Therefore,
Cg = X i pop RT g = 0.013 / 18 50663 = 3.89 10 4 (mol / m 3 ) 1.0 / 29 + 0.013 / 18 8314 321 .4
The increased percentage of the evaporation rate due to the decrease of the operating pressure in air is computed by
100 % = 58 .5%
The decrease of drying time is (370-232) = 138(s) (c) Effect of the air velocity Assume the air velocity is increased to 5.0m/s. Then,
kc = = Dg D [ 2.0 + 0.6(
a 1 / 3 Dv a 1 / 2 ) ( ) ] a D g a
2.91 10 5 19 .46 10 6 0.002052 5.0 1.098 1 / 2 [2.0 + 0.6 ( )1 / 3 ( ) = 0.2019 ( m / s ) 5 0.002052 1.098 2.91 10 19 .46 10 6
The increased percentage of the evaporation rate due to increase of air velocity is computed from:
=
1.23 10 5 3.2 10 5 1.23 10 5 100 % = 160 %
(d) Effect of the air temperature Assume the air temperature is increased to 71.85oC. From the corresponding tables, the following parameter values for air can be obtained Pr a a = 0.698 = 20.52 x 10-6 kg/ms = 1.023kg/m3
Dg
=3.24x10-5m/s
a 1 / 3 Dv a 1 / 2 ) ( ) ] a D g a
3.24 10 5 20 .52 10 6 0.002052 1.0 1.023 1 / 2 [2.0 + 0.6 ( )1 / 3 ( ) = 0.113 ( m / s ) 5 0.002052 1.023 3.24 10 20 .52 10 6
The increased percentage of the evaporation rate due to the increase of air temperature is computed by
=
1.23 10 5 1.79 10 5 1.23 10 5 100 % = 45 .5%
The decrease of drying time is (370-252) =118(s) From the above computation, we can conclude that: (1) When the air humidity is increased, the evaporation rate is decreased. (2) When the air operating pressure is decreased, the evaporation rate is increased and vice versa. (3) When the relative velocity between air and droplet is increased, the evaporation rate is increased, as well. (4) When the air temperature is increased, the evaporation rate is increased.