Documente Academic
Documente Profesional
Documente Cultură
Thank you for purchasing Ferro Works Nortech Security products. To ensure the best use of the product, please read the manual carefully before you operate your unit.
If you experience any issues while operating this unit, please do not return to the store. Contact Ferro Works customer service at 866 578 0101 or email to service@ferro-works.com for help.
The content in this manual is provided by the manufacturer for information use only, the information contained is subject to change without notice, and should not be deemed as a commitment by Ferro Works. Ferro Works takes no responsibility or liability for any errors or inaccuracies that may appear in this operation manual. All other products names, trademarks, or registered trademarks, in this document are the property of their respective holders.
(4)
Keep away this unit from water, do not use this unit close to any water places including but not limiting to bathroom, wash basin, kitchen sink, and the other close to water areas.
(5)
Do not use liquid cleansers and other chemicals to clean the unit;
only use a damp cloth for cleaning. Always disconnect the unit from the wall outlet before any cleaning. (6) (7) Place the unit only on an even surface. Do not attempt to service this product yourself like opening or removing covers may expose you to dangerous voltage or other hazards. Refer all serving to qualified service personnel. (8) Turn off the camera and receiver while not in use.
Part list
E-CMKIT001 1 2.4GHz Wireless Camera X 2 2 2.4GHz Wireless Receiver X 1 3 Antenna for Receiver X 1 4 Remote Controller for Receiver X1 5 AV Cable X 1 6 Adapter for Camera X 2 7 Adapter for Receiver X 1
DIAGRAM
Product Identification
Camera
Receiver
Remote Control
Installation
1.
Put the camera to a specific position and then adjust it to a
suitable angle.
2.
3.
4.
5.
Connect the power adapter (DC 8V 200mA) to the receiver. Turn the power switch to ON position.
6.
7.
Set the channel of receiver same as that of camera by pressing the channel button continuously, and the pictures are displayed on the monitor/TV.
8.
Adjust the brightness, contrast and color of the monitor/TV for the perfect effect.
9.
Remove the battery insulation space from the Remote Controller. Now you can remote control the receiver
Operations
A. CHANNEL BUTTON ON RECEIVER
B.
1. Press 2. Press
Trouble Shooting
Trouble No image, no sound Snowflake image, noisy sound Possible Solution 1. Check the power supply 2. Make sure that both the camera and receiver are connected with power adaptor 1. Check the receiver channel setting to make sure that the channel is set to match the camera 2. Make sure that the receiver is within certain distance to the camera 3. Move the receiver in another nearby position for a better reception 1. Make sure that the receiver is within certain distance to the camera and there is block between the receiver and the camera 2. Move the receiver in another nearby position for a better reception Mismatching system of TV (monitor) and cameras.