Documente Academic
Documente Profesional
Documente Cultură
( Page 1 of 2 )
________________________________________________________
Date: __________________________________________
NAME ____________________________________________________________________
TITLE __________________________________________
COMPANY ____________________________________________________
PHONE ________________________________________
ADDRESS __________________________________________________________
FAX
EMAIL ________________________________________
MATERIAL
Carbon Steel
304 Stainless Steel
316 Stainless Steel
Fiberglass
Plastic
Special: __________
CAPACITY
Gallons: __________
Diameter: _________
Shell Length: ______
Freeboard: ________
Open
Ducted
Scrubber
Padded
__________________________________________
Fax:
Above ground
Email: sales@oecfh.com
Below ground
UL Atmospheric
API-650
External Slope
Internal Slope
Dish (ASME)
Conical
Min. Clearance: _____ Slope: _____ (in/ft) Cone Angle: ____ (degrees of horizontal)
Support: Skirt
Legs
Side Legs
Saddles
Clearance: _____________________
OPERATING ENVIRONMENT
Service: Storage
VENTING
Process
Inside
Outside
Products: ___________
____________
___________
_____________
Concentrations: ___________
____________
___________
_____________
Internal Pressure: Operating: + _____ ____ PSI (or In WC) Design: + _____ _____ PSI (or In WC)
Seismic Zone: _______ Wind Speed: ______ mph
HEATING/COOLING Heating
Cooling Both
Heating Design: Exterior Dimple Jacket
Internal Pipe Coil
Exterior Half Pipe Coil Bayonet Coil
Heat Source: Steam Hot Oil Hot Water Pressure: ________
SAFETY OPTIONS
Ladder
w/Cage
Safety Railing Platform w/Grating
Material of Construction:
Carbon Steel Galvanized
Fiberglass
Aluminum
Other: ___________________________
LEVEL
Red Primer (no blast) SP6 blast with epoxy primer Special: _______
____
Internal lining, please specify: _______________________________________________
INSULATION SYSTEMS
External bolt & skin
Injected foam
MIXING
CONNECTIONS
NPT threaded connections, specify # and sizes:
___2, ___3, ___4, ___6, ___8, ___10
Flanged connections: 150 lb. Flange 300 lb. Flange
Specify # and sizes:
___2, ___3, ___4, ___6, ___8, ___10, ___12, ___16
Serving the Fluid Handling Process Needs of Industry
( Page 2 of 2 )
Go to www.oecfh.com, download and print 2-page worksheet. Fill out and return to OECFH.
______________________________________________
Name:
______________________________________________________
____________________________________________________________________________________________________________________________________________________________________________________________________________________________
Fax:
____________________________________________________________________________________________________________________________________________________________________________________________________________________________
Email: sales@oecfh.com
DIMENSIONS:
(check one)
inches
mm
Specify dimensions
and indicate the
approximate nozzle
locations using these
diagrams.
90
270
180
FLAT TOP
DOME TOP
ANGLE RING
(ID)
SUPPORT LUG
CONE ANGLE
____ DEGREES
OF HORIZONTAL
INTERNAL SLOPE
____ DEGREES
FLAT BOTTOM
DISH BOTTOM
CONE BOTTOM
# OF LEGS ____