Documente Academic
Documente Profesional
Documente Cultură
2.5 mm 4.0 mm
15 mm 20 mm 25 mm 25 mm 30 mm
300 mm to 1575 mm
Operating Conditions:
Metric (Imperial) Temperature Operating Speed, maximum Compressive Strength Coefficient of Friction dry -40 C to 121 C (-40 F to 250 F) 1.0 m/sec (200 ft/min) 345 N/mm (50,000 psi) 0.15
2
0.2 (8)
0.4 (16)
0.6 (24)
0.8 (32)
1.0 (40)
1.2 (48)
1.4 (56)
www.chesterton.com
d C
D3
Note: Diagram is for dimensional purposes only and should not be used for designing a rod or piston gland.
Design Criteria:
Design: 16K Metric Bearing Band Strip Bearing Band Cross-section: S = 2.5 & 4.0 mm Groove width tolerance: L+ 0.25/ -0.00 mm Cross-sectional Tolerance: S + 0.00 / - 0.08 mm
Dia. Range mm Rod Gland Diameter Rod Bearing Groove Diameter Piston Diameter Piston Bearing Groove Diameter
Min.
300 630
Max.
630 1000
*C
d + 0.75 d + 0.75 d + 0.75
D3
d + 2 (S + 0.08) d + 2 (S + 0.10) d + 2 (S + 0,13) + 0.05 0.00 + 0.05 0.00 + 0.05 0.00
*P
D - 0.75 D - 0.75 D - 0.75
d2
D 2 (S + 0.08) D 2 (S + 0.12) D 2 (S + 0.15) 0.00 0.05 0.00 0.05 0.00 0.05
> 1000
Cutting Instructions: To obtain the proper length bearing strip for rod or piston
Outside Diameter, millimeter > 30 mm or < 630 mm > 630 mm or < 1000 mm > 1000 mm Gap, millimeter 5 mm 7 mm 9 mm
Rod: (rod diameter + cross section of bearing strip) x 3.14 - gap from the chart Piston: (bore diameter - cross section of bearing strip) x 3.14 + gap from the chart
Technical Data reflects results of laboratory tests and is intended to indicate general characteristics only. A.W. CHESTERTON CO. DISCLAIMS ALL WARRANTIES EXPRESSED, OR IMPLIED, INCLUDING WARRANTIES OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE OR USE. LIABILITY, IF ANY, IS LIMITED TO PRODUCT REPLACEMENT ONLY.
Hydraulic/Pneumatic Division
A Supporting Member of FSA/ESA
Middlesex Industrial Park, 225 Fallon Road, Stoneham, Massachusetts 02180-9101 USA Telephone: 781-438-7000 Fax: 781-438-8971 www.chesterton.com
A.W. CHESTERTON CO., 2002. All rights reserved. Registered trademark owned and licensed by A.W. CHESTERTON CO. in USA and other countries.
DISTRIBUTED BY: