Documente Academic
Documente Profesional
Documente Cultură
Objectives
In this course, we will discuss the following:
Common electrical hazards
Standards relating to those hazards Electrical equipment defects/hazards Tools/techniques used in identifying hazards
conductors.
Indirect falls from ladders, scaffolds, or other
appliance or by current flowing through high resistance due to faulty wiring, setting fire to insulation and surrounding materials.
General Requirements
1926.403(a)
General Requirements
1926.403(b)(1)
General Requirements
Listed, labeled, or
1926.403(b)(2)
certified equipment must be installed and used in accordance with instructions included in the listing, labeling or certification.
Testing Laboratories
General Requirements
Equipment shall be
1926.403(b)(2)
General Requirements
Splices
1926.403(e)
Splicing devices suitable for use Welding/brazing/soldering Mechanically/electrically secure before soldering Covered with insulation equivalent to that of the conductors Insulating device suitable for purpose
General Requirements
Each service, feeder,
1926.403(h)
and branch circuit, at its disconnecting means or over current device, shall be legibly marked to indicate its purpose.
General Requirements
1926.403(i)
volts or more shall be guarded against accidental contact by cabinets or other forms of enclosures, or by another suitable method.
1926.404(a)(2)
No grounded conductor Neutral may be attached to any terminal or lead so as to reverse designated polarity Hot
Ground
Neutral
Reversed Polarity
1926.404(b)(1)(i)
1926.404(f)(3)
1926.404(f)(3)
The frame of the generator is bonded to the vehicle frame, and Generator supplies only equipment located on the vehicle and/or equipment plugged into the generator, and
(cont)
1926.404(f)(3)
The noncurrent-carrying metal parts of equipment and grounding conductor terminals of the receptacles are bonded to the generator frame, and The system complies with all other provisions of this section.
1926.404(f)(6)
1926.404(f)(7)(iv)
1926.404(f)(7)(iv)
Hand held motor-operated tools Equipment used in wet and/or conductive locations Portable hand lamps
1926.405(a)(2)(ii)[I]
1926.405(a)(2)(ii)(J)
tools and appliances must be of three-wire type and must be designed for hard or extra-hard usage.
1926.405(b)(1)
1926.405(b)(1)
1926.405(b)(1)
1926.405(b)(2)
1926.405(g)(1)
1926.405(g)(1)
1926.405(g)(1)(iii)
and cables
As substitute for fixed wiring of structure
Run through holes in walls, ceilings or floors Run through doors, windows or similar openings Attached to building surfaces Concealed behind building walls, ceilings, or floors
1926.405(g)(2)(iv)
1926.416(b)(2)
1926.416(e)
Summary
In this course, we discussed:
Common electrical hazards Standards relating to those hazards Electrical equipment defects/hazards Tools/techniques used in identifying hazards
Final Questions?