Sunteți pe pagina 1din 96

EEE Engineers day(2013-2014) QUIZ COMPETITION ROUND-2

10-09-2013

2 MARKS

3 MARKS

4 MARKS

2 MARKS ?

1 6 11

2 7 12

3 8 13

4 9 14

5 10 15

3 MARKS ?

16 21 26

17 22 27

18 23 28

19 24 29

20 25 30

4 MARKS ?

31 36 41

32 33 37 42 38 43

34 39 44

35 40 45

1.Newton/coulomb is the unit of

2. When a sample of germanium and silicon having same impurity density are kept at room temperature then? a) Both will have equal value of resistivity b) Both will have equal value negative resistivity c) Resistivity of germanium will be higher than that of silicon d) Resistivity of silicon will be higher than that of germanium

3. Star- delta starter of an induction motor

A) Inserts resistance in rotor circuit B) Inserts resistance in stator circuit C) Applies reduced voltage to rotor D) Applies reduced voltage to stator

4. Sumpner's test is conducted on transformers to find A. Temperature B. Stray losses C. All-day efficiency D. None of the above

5. One coulomb is approximately equivalent to electrons

6. Pole changing method of speed control is used in (A) slip ring induction motor (B) dc shunt motor (C) dc series motor (D) squirrel cage induction motor.

7. Surge voltage originate in power systems due to (A) lightning (B) switching operations (C) faults (D) any of the above.

8. In overhead transmission lines the effect of capacitance can be neglected when the length of line is less than (A) 200 km (B) 160 km (C) 100 km (D) 80 km.

9. Which of the following is a leading power system ? (A) Underground cables (B) Reactors (C) Mercury arc rectifiers (D)Transformers.

10) . Large capacity generators are manufactured to generate power at (A) 440 V (B) 6.3 to 10.5 kV (C) 132 kV to 220 kV (D) 400 kV.

11. 100 watt lamp has__________ resistance than a 40 watt lamp.

12. Production of heat due to current is related by which law (A) Ohm's law (B) Joule's law (C) Kelvin's law (D) Maxwell's law.

13. The transformer laminations are insulated from each other by A. Mica strip B. Thin coat of varnish C. Paper D. Any of the above

14. Load factor is defined as the ratio of A. max demand/ average demand B. average demand/ connected load C. average demand/ max. demand D. connected load/ max demand

15. The sole purpose of a commutator in a dc generator is to a. increase output voltage b. reduce sparking at brushes c. provide smoother output d. convert the induced ac into dc

16. An ideal dc generator has .......... voltage regulation. a. low b. zero c. positive d. negative

17. The voltage regulation of an over compound dc generator is always a. Positive b. negative c. zero d. high

18. Star- delta starter of an induction motor A. Inserts resistance in rotor circuit B. Inserts resistance in stator circuit C. Applies reduced voltage to rotor D. Applies reduced voltage to stator

19. The thrust developed by a linear induction motor depends on A. Synchronous speed B. Rotor input C. Number of poles D. both A and B

20. A diode can be used as a frequency multiplier because of its A. Junction capacitance B. Non linearity C. Avalanche voltage D. Forward breakover E. Charge carrier concentration

21. The VA rating of a transformer is an expression of A. The maximum frequency at which it can function B. The type of core material it has C. The voltage step-up or step-down ratio D. The impedance transfer ratio E. None of the above

22. A power gain of 30dB is equivalent to which amplification factor? A. 0.001 B. 1/30 C. 30 D. 1000

23. A hot-wire ammeter A. Can measure ac as well as dc B. Registers current changes very fast C. Can indicate very low voltages D. Measures electrical energy

24. A voltmeter should have A. Low internal resistance B. High internal resistance C. Electrostatic plates D. A sensitive amplifier

25. A transistor is in active region whena) IB = IC b) IC = IB c) IC = IE d) IC = IB

26. In a JFET gates are always? a) forward biased b) reverse biased c) unbiased d) none

27. Synchronous capacitor is A. An ordinary static capacitor bank B. An over excited synchronous motor driving mechanical load C. An over excited synchronous motor running without mechanical load D. None of the above

28. Which of the following has least conductivity? A. Silver

B. Copper
C. Aluminum D. Gold

29. A branch of a network is said to be passive when it contains A. Voltmeter

B. voltage source
C. current source D. Battery

30. An electrical circuit with 10 branches and 7 nodes will have A. 10 loop equations

B. 7 loop equations
C. 3 loop equations. D. 4 loop equations.

31. Consider the circuit: Which of the following statement is correct ? A. passive and linear B. active and linear C. passive and non-linear D. active and non-linear

32. Constantan contains A. silver & tin. B. tungsten & silver C. copper and tungsten D. copper and nickel

33. If the resistance of a conductor does not vary in accordance with the Ohms laws it is known as A. Non-conductor

B. Non-linear conductor
C. Bad conductor D. Reverse conductor

34. Generators works on the principle of production A. Dynamically induced emf.

B. Static induced emf.


C. None of the above. D. both A and B.

35. Pelton wheel turbine is a A. high head turbine. B. medium head turbine. C. low head turbine. D. none of above.

36. Which of the following is a reaction turbines. A. pelton turbine and Francis turbine. B. Francis turbine and Kaplan turbine. C. Kaplan and pelton turbine. D. None of these.

37. The safety factor of insulators is defined as ratio of A. Flash over voltage to puncture voltage

B. Puncture voltage to flash over voltage


C. Current to voltage D. Current to power

38. In Induction Motor the 7th harmonic torque may make the motor rotate at (1/7)th synchronous speed. This is called A. crawling B. resonance C. harmonics D. cogging

39. Which motor used in Lathe machineA. D.C . Series motor. B. D.C. Shunt motor. C. D.C. cumulative compound motor D. none of the above.

40. when bundle conductor are used in place of single conductor the effective inductance and capacitance will respectively A. decrease and increase B. increase and decrease C. increase and remain unaffected D. decrease and remain unaffected

41. In a transistor amplifier the ______junction is reverse biased. A. collector base junction

B. Emitter base junction


C. CE base junction D. none of these.

42. Which type of dc motor is employed in a domestic vacuum cleaner A. dc series motor

B. dc shunt
C. dc short shunt compound D. dc long shunt compound

43. Advantage of active filter is A. do not offer gain B. easy to tune C. both D. derive high impedance load

44. What type of dielectric material is used in capacitors used for fans and for p.f correction A. oil impregnated paper

B. vacuum
C. glass D. mica

45. Which combination is true for short lines A. A =1, B=Z, C=0, D=1 B. . A=0, B=1, C= Z, D=1 C. A=1, B=1, C= Z, D=0 D. A=0, B=0, C=1, D=Z

1. Electric field intensity.

2. d

3.D

4.A

5. 6*10^18

6.D

7.D

8.D

9.A

10.B

11.LESS

12.B

13.B

14.D

15.D

16.B

17.B

18.D

19.D

20.B

21.E

22.D

23.A

24.B

25.B

26.C

27.C

28.C

29.A

30.D

31.B

32.D

33.B

34.D

35.A

36.B

37.B

38.A

39.B

40.A

41.A

42.A

43.B

44.A

45.A

END

S-ar putea să vă placă și