Documente Academic
Documente Profesional
Documente Cultură
In:
Section 3.8.3 Concrete and Steel Internal Structures of Steel or Concrete Containments Section 3.8.4 Other Seismic Category I Structures
The Standard Review Plan for the Review of an Application for a Mixed Oxide (MOX) Fuel Fabrication Facility (NUREG-1718), 2000, refers to
N690-1984 in Section 11.4.6.1 Regulatory Guidance
ANSI/AISC N690
SRP (3.8.3 and 3.8.4) refer to N690 in relation to the following for steel structures
Applicable codes, standards and specifications Loads and load combinations Design and analysis procedures Structural acceptance criteria Materials, quality control, special construction techniques and quality assurance
ANSI/AISC N690
SRP references (additional examples) SRP 3.8.4 - II.3 Loads and Load Combinations
All loads and load combinations are to be in accordance with AISC N690-1994 including Supplement 2 (2004). This specification uses the allowable stress design (ASD) method. The supplemental criteria on the use of loads and load combinations presented above for concrete structures also apply to steel structures.
Reference is to ASD methods (as opposed to the use of LRFD for concrete structures)
4
Use of LRFD approach (with ASD as an alternative) which is consistent with the code for concrete structures (ACI-349) Standard for Modular Composite Construction (SC) (planned Appendix N9)
5
SC construction is still outside the scope of existing US standards for safety-related structures Case-by-case review is still done for current applications, license amendments and potential new applications Standard under development by Ad-hoc subcommittee to AISCs Task Committee 12 (TC 12)
Planned as Appendix N9 to ANSI/AISC N690
Sponsoring numerical modeling research for interpretation of testing, benchmarking and confirmatory analysis tools Reviewing international codes and guidance
JEAC-4618 (2009) Japan ASD approach KEPIC (2010) Korea LRFD approach
Review of SC Standard
Resulting designs must satisfy regulations Resulting designs would (as examples):
Provide adequate strength and stiffness Prevent non-ductile failure modes Provide durability through the use of adequate materials, control of concrete cracking, prevention of steel and rebar corrosion Provide clear load paths avoiding load path discontinuities
Review of SC Standard
Challenges (examples)
Design criteria for connections and connections to other construction types, e.g., reinforced concrete Experimental database for combined load effects Designs should be based on sound engineering principles and validated methods
Staff continues the review of the technical bases for the provisions in the US standard under development as well as review of the scope of the provisions
Effort includes review of existing international standards (E.g., JEAC and KEPIC)
Background work is being done to review AISCs white paper or other publicly available publication on the SC standard under development (Appendix N9)
9
Acronyms
AISC American Institute of Steel Construction ANSI American National Standards Institute ASD Allowable Stress Design JEAC Japan Electric Association Code KEPIC Korea Electric Power Industry Code LRFD Load and Resistance Factor Design SC Modular Composite Construction (Wall modules constructed from large prefabricated sections of steel plates spaced apart and joined with intermittent steel members or tie bars, joined with other modules at the site, and then filled with concrete) SRP Standard Review Plan
10