ID: 081-19-882; Level 2, Term 2 Daffodil International University Bangladesh ø ønalog multimeters, the instruments that are used to measure electrical quantities such as voltage, current, resistance, and power signal. Basic functionality includes measurement of Potential in volts, Resistance in ohms, and Current in amps. ønalog multimeters are used to find electronic and electrical problems. In this project, we make dc ønalog multimeter. Which is mainly use to measure the current and voltage. É ø multimeter can be a hand-held device useful for basic fault finding and field service work or a bench instrument which can measure to a very high degree of accuracy. They can be used to troubleshoot electrical problems in a wide array of industrial and household devices such as batteries, motor controls, appliances, power supplies, and wiring systems. ø multimeter is a device that can measure voltage, current and resistance.
Ð jensitive meter movement Ð jelector switch ( 7 pins ) Ð Potentiometers, ( 0-100k ) Ð Three variable resistors ( 10k ) Ð jix resistor ( 10k ) Ð Bread board Ð Three banana jack j
Þ ø øn analog multimeter can be use as- Ý DC Voltage Measurement Ý DC Current Measurement ²Þ Ý jet the range selector to the proper DCV position. Ý Keeping certain to observe correct polarity, connect the test leads in parallel to the load to be measured. Ý Read the value on the DC scale, be sure to use the correct scale for the range selected. ²ÞÞ Ýjet the range selector to the proper DC mø position. ÝConnect the test leads in series to the load to be measured. In other words, the meter ø ønalog multimeters can measure a range of different electrical outputs, such as- ~voltage ~current ~resistance ² Ð ønalog multimeters do take some energy from the circuit they are testing Ð ønalog multimeters can sometimes be difficult to read because they display data as a needle moving along a scale Ð To give an accurate reading analog multimeters need a high level of sensitivityȄotherwise, the results may be skewed ² Þ 9enerally speaking, analog meter resistance should be ten times the circuit resistance to ensure accurate readings. ø high sensitivity is necessary to prevent upsetting the test circuit. When it comes to price, a quality analog multimeter will cost about the same as a digital multimeter. ønalog meters have several different options for displaying data. However, the width of the pointer and subsequent vibration can alter the resolution of a reading. Other common errors occur as a result of a userǯs inability to read the results properly. : http://www.thomasnet.com/articles/engineering-consulting/analog- multimeters