Documente Academic
Documente Profesional
Documente Cultură
PHONE
BASED
DTMF
CONTROLLED
GARAGE DOOR OPENING
SYSTEM.
Prepared By:
Imtinungla
Esther Kath
Antaripa Bhuyan
OUTLINES :
Introduction.
Overview.
Design.
Flow
OUTLINES :
Introduction.
Overview.
Design.
Flow chart of the project.
Components Used.
Future work.
Bibliography
INTRODUCTION
Objective of this project is to unlock a garage
door by a mobile phone.
Based on the concept of DTMF (dual tone multi frequency).
Further this project can be incorporated
with an EEPROM i.e., a non-volatile
memory.
OUTLINES :
Introduction.
Overview.
Design.
Flow chart of the project.
Components Used
Future work.
Bibliography.
OVERVIEW:
The
OUTLINES :
Introduction.
Overview.
Design.
Flow chart of the project.
Components Used.
Future work.
Bibliography.
Design :
OUTLINES :
Introduction.
Overview.
Design.
Flow
Working
Future work.
Bibliography.
OUTLINES
Introduction.
Overview.
Design.
Flow
COMPONENTS
Future work.
Bibliography.
USED.
DTMF :
16 button keypad.
DTMF DECODER:
This DTMF decoder
circuit identifies the
dial tone from the
telephone line and
decodes
the
key
pressed on the remote
telephone.
MICROCONTROLLER :
8K
Regulator
TRANSFORMER
The
RECTIFIER
The
VOLTAGE REGULATOR(78050)
330r
10uF
10K
33pF
330K
0.1uF
100K
22K
.47uF
22pF
RESISTOR
470uF
CAPACITOR
LED
For
DC MOTOR IC (L293D)
L293D
is a dual H-bridge
motor driver integrated
circuit (IC).
Motor drivers act as current
amplifiers since they take a
low-current control signal
and provide a highercurrent signal.
This higher current signal is
used to drive the motors.
DC MOTOR
Initiates
SOFTWARE REQUIREMENT:
Keil
C compilers-Compiles HLL
Circuit
Description
& Working.
CIRCUIT DIAGRAM
WORKING
The DTMF Decoder(MT8870) with a 3.5 MHz Crystal compares
the input tones and converts in into binary form that is
acceptable by the microcontroller.
This BCD data is passed through HEX CMOS inverters
(74LSO4) the output of which are duly pulled up and connected
to port-1 pin no 1 to 4 as buffer between the DTMF IC and the
MC.
Thus the microcontroller gets the 4 bit binary data and while
i.e. executed by the program develops corresponding output at
pin 26, 27&28 of part 2 for the motor driver IC L293D to rotate
as desired for opening or closing the door motor.
An SPDT limit switch is used the common point of which is
connected such that while the motor shaft reaches one extreme
end the limit switch provides a logic zero that are connected
INT0 & INT1 i.e. pin 12& 13 of microcontroller, to stop the
motor so that locked rotor condition is avoided.
OPENING
CLOSING
SPECIALTY OF THE
PROJECT
Can
Future work
The system can be improve our system
first by using a sensor to check the status
of the door before applying the users
order
then by making the system send a
message to the user to confirm the
success of the process,
BIBLIOGRAPHY
TEXT BOOKS REFERED:
WEBSITES
www.atmel.com
www.beyondlogic.org
www.wikipedia.org
www.howstuffworks.com
www.alldatasheets.com