Engine Specifications LGA-340 • Bore x Stroke : 84 mm x 64 mm, Single cylinder, Air Cooled • Swept Volume : 338 cc • Compression ratio : 8:1 • Rated Power : 8 kW @ 4400 rpm • Max Torque : 19 Nm @ 3000 rpm • Valve Timing System : Belt Driven Single Overhead Camshaft • Lubrication : Forced Lubrication Vane Pump • Luboil : 15W40 CF4 multi grade oil • Luboil Capacity : 1.7 ltrs • Starting System : Electric Start with Auto-Decomp on Camshaft • Electric System : 12V, 18 amps flywheel mounted alternator, • Recommended Battery : 12 V, 44 Ah • Weight of Engine : 30.5 kg Engine Layout Overall Dimensions Intake System Exhaust System Lubrication System Fuel Circuit The petrol feed pump will be supplied in loose condition. Petrol
Use of feed pump will allow locating Filter
fuel tank at bottom portion of vehicle with negative head. Electric This will ensure the continuous flow of Feed fuel to engine as and when demanded which is essential for good Pump performance of vehicle. This also will ensure better safety during fuel filling operation, since fuel Return Line spilt will not be on the vehicle hot or to Tank electrical parts. To Carburettor The spillage tray can be eliminated and better packaging is possible. Engine Electrical System LOMBARDINI SCOPE Modifcations in Engine At Lombardini, continuous improvement in products through R&D is carried out for end customer delightment. Following are major modifications in LGA340 engines are made. 1. Modification in Piston Profile for Indian Market, CNG / LPG application 2. Chrome Plated Rings, 3. Spark Timing modification, 4. Higher Power Starter Motor for better start ability, 5. Increased Main Journal Diameter of Crankshaft for durability, 6. Carburettor modification with drain arrangement, 7. Wear Resistant Valve Seat Special Instruction • Before carrying any welding activity, ensure spark plug cable removed and remove Battery terminal cables. This will prevent burning of wiring harness and HT Coil. • Do not tamper Engine Intake System including Air Filter & it’s Position. Tampering Intake system will reduce power and may yield in misfiring during vehicle retardation. • In case, if the silencer position need to be modified because of packaging constraints, ensure back pressure does not exceed 450 mm of Water Column. • Fill the measured quantity of luboil from the Rocker Cover Filling Cap, wait for 10 minutes to allow oil to reach bottom portion in crankcase and then measure the level. If necessary, drain the excess oil by loosening side drain plugs. Luboil level must be between lower and upper mark of Dipstick. Level to be checked when vehicle on horizontal road. • Fuel Pipes to be used should be of good quality petrol hoses. Thanks!
Contact Details: Devendra Nene Prashant Sisodiya email : dnene@lombardini.it email : psisodiya@lombardini.it Mobile : 9922504064 Mobile : 9922504066