Documente Academic
Documente Profesional
Documente Cultură
PRESENTED BY :
UNDER GUIDANCE OF :
G.VANI .
ALEFIAH MUBEEN.
PURPOSE OF PROJECT..
INTRODUCTION..
TV remote jammer is a circuit which is
CIRCUIT DIAGRAM..
COMPONENTS USED..
IR LED
Diode
IC 555
Battery
Resistor
Capacitor
CIRCUIT DESCRIPTIONS..
ORKING OF IC555 :-
1. GROUND:
2. TRIGGER:As
we can see that the voltage at the non-inverting end of the comparator is
Vin/3, so if the trigger input is used to set the output of the F/F to high state
by applying a voltage equal to or less than Vin/3 or any negative pulse, as
the voltage at the non-inverting end of the comparator is V in/3.
3.
OUTPUT:
This
. CONTROL VOLTAGE:
As we can see that the pin 5 is connected to the inverting input having a
voltage level of (2/3) Vin. It is used to override the inverting voltage to
change the width of the output signal irrespective of the RC timing network.
6. THRESHOLD:
7. DISCHARGE:
8. SUPPLY:
This pin is used to provide the IC with the supply voltage for the
functioning and carrying of the different operations to be fulfilled with the
555 timer.
USES:
RESISTOR:-
ADVANTAGES AND
DISADVANTAGES..
ADVANTAGES:we can use this signals so that the other
people cannot change the channel while
watching our favorite programs on TV.
It will not effect the signal receiving
capacity of the TV.
DISADVANTAGES:The circuit should be tuned correctly to
38 kHz frequency to get accurate result.
APPLICATIONS
CONCLUSION
THANK YOU