Documente Academic
Documente Profesional
Documente Cultură
Apply and
commit all
Filter.
To create sector filter, at step 2, choose Cell (GSM) ->attributes -> ID.
On step 3, choose operator: CONTAIN, then put A on dialog box. This for sector 1. Click next until finished.
Add again for sector 2, and follow the same step, just put B on dialog box. For sector C, at step 2, choose AND logical
and add again Cell (GSM)->attributes-> ID. On step 3, choose operator CONTAIN and check NOT, at the dialog box
each attributes ID put A and B. Meaning not A and not B sector, so it will come sector 3. click next until finish. Dont forget
to commit, close.
NOTE: This step use only if you have 1 sector with 1 MAL-ID. If all sector will use 1 MAL-ID, no need to create filter
Click Global
Edit
GLOBAL EDIT
Cell Layer tab
Filter for
Sector 1
Frequency
Hopping setting
Cell Layer, put the
layer that already
created (eq. Warid
default)
Click allocate
layer
Frequency Hopping
Check the thick box for Frequency Hopping, Enable FH, and Sync as Hopping method.
Total TRX allocated for total carrier allocated put 7 as maximum configuration for WARID will use 8/8/8
GLOBAL EDIT
Carrier Layer tab BCCH setting
Go to
allocated/fixed/
forbidden tab.
Check the box
for Fix all
allocated
Click BCCH
Allocate the
BCCH layer
Put 1 on
dialog box for
carrier
required
GLOBAL EDIT
Carrier Layer tab MAL setting
Allocate
MAL1 for
sector 1
Total carrier of
MAL
Click MAL1
Set the
fractional load
for 50%
Apply
the
editor
Sample: at
GSM default
of sector 2
Carrier tab
Go to Cell
Layer tab, and
select the
Layer
Click add, and
give terminal
name
Technology:
GSM
Click apply,
then commit
Clutter types of
terminal. Put
density value as
Warid RFP
requirement
Coverage/Interference
Serving and
interfering cells
Check BCCH as
interfering signal
Best server
margin
Click OK
Click select
view
Next
Note: show all the map which have site location. We will use clutter traffic as we dont have the exact live traffic data
from costumer
Click WARID
terminal, Next
Click next
until finish
Click create
new plan and
start plan
After status is
Finished, then
go to Tools, and
apply to database
Now you have BCCH carrier for database. Please take note that this is INITIAL FREQUENCY PLAN. This not
good result, since still doesnt have interference tables. You can check at Site database (page 11 of this
document), now you will have allocated frequency per cell. Click commit all as it will be calculated again to have
good clean frequency
To have good frequency plan, you have to do the frequency plan again, with Interference table loaded.
WARNING! My PC
have insufficient
memory
Interference area
due to initial
frequency plan not
included
interference table
calculation
At the end of the step, please save the Interference table as it will be calculate at cost matrix frequency plan
Click VIEW->
load plan list
Thick create
new plan
Initial cost of
new frequency
plan
The higher initial cost, the longest time to plan. To have the good result, leave PC running for several
days to have higher Iteration.
After done, apply the database. Since we will have 1 MAL ID per sector, we dont need to plan MAL-ID,
and MAIO.
Result of ILSA.
More accurate plan, the Minimum Reuse will have far distance.
Now we can continue to next step
Select filter
for HSN plan
Select Plan,
and click OK
CONGRATULATION!!!
Now we have proper frequency plan