selected air temperature and humidity conditions for the crew and cargo compartments/passengers along with the pressurization.
The system cab be operated at all engine
ratings on ground or in air except at TAKE OFF power rating. AIR CONDITIONING SYSTEM LAY OUT CONTROLS & INDICATIONS AIR FLOW RATE CONTROL AIR PRESSURE (PORT/STBD) SUPPLY BY AIR BLEED (Selected switch 4 position) VALVE FROM THE ENG AUTO, NEUTRAL, OPEN, 10TH STAGE CLOSE AIR FLOW RATE SUPPLIED AIR PRESSURE INDICATION FROM THE ENG 10TH (PORT/STBD) STAGE (3.5 to 4.5 Units) (Operational range 2-4.5) CABIB AIR COND SYST FOR SYSTEM MODE (Selected switch 3 position) SELECTION AUTO, OFF, MANUAL
PORT/STBD FOR MANUAL CONTROL
(Selected switch 3 position) OF AIR SUPPLIED HOT, OFF, COLD TEMPERATURE TEMP SETTER AUTO TEMPERATURE Operational range in auto CONTROL made 5C-25C ADD HEAT CREW CABIN Controls temperature in (Selected switch 4 position) CREW CABIN HOT, COLD, NEUTRAL, CLOSED This system is provided to keep cargo cabin at low temperature and crew cabin at high/normal temperature. If required keep the cargo compartment at below 15C temperature. The air is taken for additional heating from the STBD eng only by an electrical actuator. TEMP AIR SUPLLIED To energies the indicator (Selected switch 2 position) measuring the supplied air CREW CABIN, CARGO temperature to CABIN CREW/CARGO CABIN
TEMP AIR SUPPLIED To monitor the temperature
indicator of air supplied to the (0 to 120C) CREW/CARGO CABIN PORT & STBD CARGO CABIN TEMP To monitor the temperature Indicator of air supplied to the CARGO CABIN OPERATION ON GROUND
Having started the engines the system can be
operated as follows: CABIN AIR COND SYS switch MANUAL AUTO TEMP SETTER switch 20C/Selected desired temperature AIR FLOW RATE (PORT/STBD) Select to OPEN to achieve a flow rate of 2.5-3 UNITS then select to AUTO
Do not select airflow rate switch to AUTO mode directly.
After the eng have attained ground idle RPM, place the AIR FLOW RATE (PORT/STBD) switch to OPEN position 3 to 5 sec with interval of 1 to 2 sec up to 2.5-3 UNITS then only change to AUTO mode. Itll be within 3.5 to 4.5 UNITS. NOTE 1: Once the airflow rate is selected to AUTO, the flow rate should be settle between 3.5- 4.5 UNITS and the supplied air temperature should be between 2-120C.
NOTE 2: Air temperature drop to minus 20C and
raise up to plus 150C within less than 5 minutes is permissible.
NOTE 3: Prior to executing take off the air
conditioning system should be switched OFF by placing the AIR FLOW RATE switch to CLOSED position. OPERATION IN FLIGHT After take off, having engine power rating to MAX, continuously switch ON the system. If it was turned OFF prior to take off by placing the AIR FLOW RATE switch to AUTO. Check air flow rate between 3.5-4.5 UNITS and supplied air temperature between 2-120C. NOTE: The difference between the cargo cabin temperature & the selected temperature should not be more than 6C. if greater than that, adjust by using the TEMPERATURE SETTER. CAUTION: In case of wing & tail unit ice protection system is in operation, manually reduce the air flow rate down to 2 UNITS. SWITCHED OFF
Before engines are shut down and opening of
cargo doors. System should be OFF as follows:
CABIN AIR COND SYS switch OFF
AIR FLOW RATE (PORT/STBD) OFF and Monitor air flow rate drops to ZERO ALL SYSTEM SWITCHES Place to Initial position