Q
Reliance
POLYMERS
BS 600 HIGH DENSITY POLYETHYLENE
BLOW MOULDING GRADE
856003 isa High Density Polyethylene (HDPE) grade suitable for general purpose extrusion blow moulding applications. Articles blown,
{from this grade exhibit good stiffness, The resin offers good mele strength, ESCR and impact resistance and typically used for packaging of
‘ol, vanaspati, general purpose containers, jerry can, et.
‘Typical Characteristics
Property ‘Test Method Unit “Typical Value**
Density 23°C) ‘ASTM DI505 wee 0.956
MFI(190°CI5 ka) ASTM D238 ‘10 min 1S
“Tensile Strength at Yield ASTM 638 MPa %
Elongation at Break ASTM 638 % 350)
Flexural Modulus ASTM D 790 MPa 900)
Hardness ‘ASTM D 2240, Shore D @
Vieat Softening Paint ASTM D 1525 c 128
‘pial Characterize and notte taken a spacaion
‘Mechanical Propertes areon jection Molded Specimen
Applications
(Ol, vanaspati and general purpose containers, jerry cans.
Regulatory Information
+ Meets the requirements stipulated in standard IS : 10146 on "Specification for Polyethylene for safe use in contact with foodstuff,
pharmaceuticals, and drinking water". It also conforms to the postive lst of constituents as prescribed in IS : 10141. The grade
and the additives incorporated init also comply withthe FDA:CFR Title 2, 177.1520, Olefin polymers.
Storage Recommendations
+ Bags shouldbe storedin dry/closed conditions at temperatures below 50°C and protected from UV/ direct sunlight
7 T08. Emapamer peppers Wate wen
=e tn nd rv a an dew th oe Mi Nera gnine mrad nviigatroarc T
‘tipanaanéattentyoeso